SPARE TIRE IS SUSPENDED UNDER VEHICLE WITH A STEEL CABLE. THIS CABLE BROKE WHILE VEHICLE WAS IN MOTION AND TIRE FELL OFF OF VEHICLE. FORTUNATELY THE VEHICLE WAS TRAVELING AT ONLY 10 MPH. THIS COULD HAVE BEEN VERY SERIOUS! NO LESS THAN 2 PEOPLE HAVE BEEN KILLED IN THE CITY OF SYRACUSE BY SIMILLAR ACCIDENTS OVER THE PAST 15 YE…
Read full complaint
SPARE TIRE IS SUSPENDED UNDER VEHICLE WITH A STEEL CABLE. THIS CABLE BROKE WHILE VEHICLE WAS IN MOTION AND TIRE FELL OFF OF VEHICLE. FORTUNATELY THE VEHICLE WAS TRAVELING AT ONLY 10 MPH. THIS COULD HAVE BEEN VERY SERIOUS! NO LESS THAN 2 PEOPLE HAVE BEEN KILLED IN THE CITY OF SYRACUSE BY SIMILLAR ACCIDENTS OVER THE PAST 15 YEARS! THIS CABLE FAILED BECAUSE IT RUSTED THROUGH. IT IS ALSO IMPOSIBLE TO INSPECT THE CONDITION OF THIS CABLE WITHOUT REMOVING THE SPARE TIRE. THE CABLE SHOULD BE REPLACED WITH A STAINLESS STEEL CABLE. NON-STANLESS STEEL CABLES SHOULD NOT BE ALLOWED IN THIS SAFETY CRITICAL APPLICATION.
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence & remedy
Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Illustration