Electrical SystemEngine And Engine CoolingService Brakes, Air
SEVERE VIBRATION BETWEEN 50 TO 80 MI. PER HOUR. HAVE SPENT OVER $1000.00 TO TRY TO REMEDY PROBLEM. DEALERSHIP SAID THEY CAN'T DO ANYMORE AND IT MUST BE A MANUFACTURING DEFECT. THERE IS ALSO A VERY LOUD POPPING NOISE WHEN THE STEERING WHEEL IS TURNED IN EITHER DIRECTION. IT COMES FROM EITHER SIDE AND POSSIBLY CHASSIS. AT FIRST T…
Read full complaint
SEVERE VIBRATION BETWEEN 50 TO 80 MI. PER HOUR. HAVE SPENT OVER $1000.00 TO TRY TO REMEDY PROBLEM. DEALERSHIP SAID THEY CAN'T DO ANYMORE AND IT MUST BE A MANUFACTURING DEFECT. THERE IS ALSO A VERY LOUD POPPING NOISE WHEN THE STEERING WHEEL IS TURNED IN EITHER DIRECTION. IT COMES FROM EITHER SIDE AND POSSIBLY CHASSIS. AT FIRST THOUGHT IT WAS STRUTS OR BEARINGS. COMPLETE FRONT END REPAIR DID NOT FIX THE NOISE. CAR HAS NEVER BEEN IN AN ACCIDENT EITHER. THERE IS ALSO A PROBLEM WITH CHANGING GEAR SHIFT FROM PARKING TO REVERSE OR DRIVE ON AN INCLINE. SOMETIMES IT JAMS AND HAS TO BE JERKED VERY HAD TO GO INTO GEAR. OTHER TIMES IT SLIPS FROM GEAR TO ANOTHER. HAVE REPLACED BRAKES 2 TIMES. STILL HAS SHUDDER UPON PRESSING BRAKES REGARDLESS OF SPEED. AN OFFENSIVE ODOR LIKE ROTTEN EGGS, ESPECIALLY WHEN USING AIR CONDITIONER. DEALERSHIP SAID THEY FOUND THIS A LOT IN THIS CERTAIN VEHICLE. THEY DO NOT KNOW HOW TO FIX. IT IS A MANUFACTURING DEFECT. OWNER BEFORE ME HAS ALREADY REPLACE THE IGNITION MODULE. A DEALERSHIP SAID ANOTHER MANUFACTURING DEFECT. FUEL PUMP WIRES WERE BURNED AND REPLACED BY PREVIOUS OWNER. BATTERY CABLES ALSO SHORTED OUT AND WERE REPLACED ON 8/29/03. BATTERY CONTINUES TO BE DRAINED IF VEHICLE HAS NOT BEEN STARTED WITHIN A 3 DAY PERIOD. *CB
NHTSA ODI #10054313
Mileage unknown · Aug 24, 2001
Engine And Engine CoolingSuspension
WHILE SERVICING VEHICLE INDEPENDENT REPAIR SHOP INFORMED CONSUMER OF A STRUT ROD AND FRONT ENGINE MOUNTS BEING BROKEN, AND NEEDED TO BE REPLACED. MANUFACTURER WAS NOTIFIED, AND INFORMED CONSUMER THAT THOSE PARTS WERE NOT COVERED UNDER A RECALL.*AK
NHTSA ODI #895153
Mileage unknown · Oct 21, 1999
Suspension
WHILE DRIVING ABOVE 35 MPH VEHICLE PULLS TO THE RIGHT WHICH HAS NEARLY CAUSED SEVERAL COLLISIONS TO OCCUR. DEALER COULD NOT IDENTIFY THE PROBLEM. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #851416
Mileage unknown · Jan 1, 1998
Exterior LightingFuel System, GasolineFuel System, Other
FUEL TANK VAPOR LOCKS DUE TO FAULTY FUEL CAP, ROTORS RUSTED, HEADLIGHT DIMMER SWITCH FAILED.
SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INADVERTENT DEPLOYMENT OF THE AIR BAGS CAN OCCUR DUE TO WATER INTRUSION.
Consequence & remedy
Consequence: DEPLOYMENT OF THE AIR BAG WITHOUT WARNING COULD CAUSE A DRIVER TO LOSE VEHICLE CONTROL INCREASING THE RISK OF A VEHICLE CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL CLEAN THE EXTERIOR CASE OF THE SENSING AND DIAGNOSTIC MODULE (SDM) AND APPPLY A POTTING COMPOUND TO THE SDM CASE AND ELECTRICAL CONNECTOR BODY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
EA98004 · Inadvertent Air Bag Deployment
Opened Feb 24, 1998 · Closed Jun 16, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE98005 · Erratic Turn Signal Operation
Opened Feb 6, 1998 · Closed Aug 27, 1998
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
SQ97017 · Inadvertent Air Bag Deployment
Opened Jul 2, 1997 · Closed Feb 24, 1998
Status: closed (inferred from source dates) · Air Bags
IF A 1995 CADILLAC INTERIOR IS EXPOSED TO SIGNIFICANT WATER INTRUSION, SUCH AS FROM WATER LEAKS, A WINDOW LEFT OPEN IN THE RAIN, OR DRIVING THROUGH HIGH WATER UP TO THE CARPET LEVEL, THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) SYSTEM SENSING AND DIAGNOSTIC MODULE (SDM) CAN BE DAMAGED.IF THIS OCCURS, BOTH THE DRIVER AND PASSENGER AIR BAGS CAN DEPLOY WHEN THE IGNITION SWITCH IS TURNED ON, EVEN IF THERE HAS BEEN NO FRONTAL IMPACT OR CRASH.AS A RESULT OF THESE DEPLOYMENTS, GM CONDUCTED AN ADVISORY LETTER CAMPAIGN, NUMBER 51-01-08 ENTITLED INADVERTENT DEPLOYMENT OF AIR BAGS WHEN INTERIOR EXPOSED TO WET CONDITIONS, IN FEBRUARY 1996.LETTERS TO OWNERS MAILED PURSUANT TO THIS COMPAIGN WARNED OWNERS TO NOT START THEIR ENGINES IF THE VEHICLE INTERIOR HAD BEEN EXPOSED TO SUBSTANTIAL AMOUNTS OF WATER.ODI HAS RECEIVED A TOTAL 8 REPORTS OF INADVERTENT AIR BAG DEPLOYMENT IN 1995 CADILLAC VEHICLES.
EA95025 · Dash Trim Separation
Opened Aug 31, 1995 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Unknown Or Other
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
1995 Cadillac Deville Problems, Complaints & Recalls | Skip That Year
Illustration