IllustrationMY 2004 RENDEZVOUS STALLED 3 TIMES. TOOK IT TO DEALER WHO SAID SOME CODES WERE STORED AND THEY SAID SOME WIRES WERE STRETCHED. ABOUT 2 WEEKS LATER IT STALLED AGAIN. WHEN IT STALLS I LOSE POWER STEERING AND POWER BRAKES MAKING IT HARD TO CONTROL. *JB
2004 Buick Rendezvous
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Buick Rendezvous do not stand out strongly from the model-year median of 138.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rendezvous years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
440–25K
2125–50K
2550–75K
2075–100K
33100–150K
19150K+
162 reports with mileage · 38 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports2 fire reports13 injury reports
Electrical System complaints
76 reportsVEHICLE STALLED IN TRAFFIC SOMETIMES WITH CRUISE CONTROL ON AND SOMETIMES WITH CRUISE CONTROL OFF. WHILE ON THE HIGHWAY AT 55 MPH VEHICLE JUST STOPPED AND WAS ALMOST REAR ENDED BY A TRACTOR TRAILER. THE IGNITION AND THE COMPUTER WERE CHANGED. DEALER STATED THERE WAS NOTHING DEFECTIVE.*AK ON SEVERAL OCCASIONS WHILE DRIVIN…
Read full complaint
VEHICLE STALLED IN TRAFFIC SOMETIMES WITH CRUISE CONTROL ON AND SOMETIMES WITH CRUISE CONTROL OFF. WHILE ON THE HIGHWAY AT 55 MPH VEHICLE JUST STOPPED AND WAS ALMOST REAR ENDED BY A TRACTOR TRAILER. THE IGNITION AND THE COMPUTER WERE CHANGED. DEALER STATED THERE WAS NOTHING DEFECTIVE.*AK ON SEVERAL OCCASIONS WHILE DRIVING WITH NO WARNING THE VEHICLE CAME TO A COMPLETE STOP. CONSUMER COULD HEAR OTHER VEHICLE APPLYING THIER BRAKES AND THE CAR FOLLOWING SWERVED TO THE RIGHT TO AVOID HITTING THE VEHICLE, WHICE COULD HAVE RESULTED IN A SERIOUS ACCIDENT OR/AND DEATH. *BF *NM
STALLS SLOWING DOWN AT RED LIGHTS,CORNERS OR DRIVING THROUGH PARKING LOTS COULD RESULT IN BEING STRUCK FROM BEHIND WITH RESULTANT SERIOUS INJURIES. VISITED DEALER FOR FOURTH TIME AND INQUIRED AS TO ANY NEW SERVICE BULLETINS FROM GENERAL MOTORS AND WAS ADVISED THAT THERE WERE NONE.*AK
MY SECOND COMPLAINT (10110658). I WAS DRIVING DOWN THE HIGHWAY AT SPEEDS BETWEEN 55 - 65MPH; WHEN I SLOWED DOWN AS I WAS APPROACHING THE LIGHT, THE CAR CUT OFF. I SHIFT THE GEAR BACK TO PARK AND RESTARTED THE VEHICLE AND PROCEEDED. THE CAR HAD BEEN WARM FOR 20 MINUTES AND IT WAS AROUND 7:40 A.M. IN THE MORNING. THIS IS AT L…
Read full complaint
MY SECOND COMPLAINT (10110658). I WAS DRIVING DOWN THE HIGHWAY AT SPEEDS BETWEEN 55 - 65MPH; WHEN I SLOWED DOWN AS I WAS APPROACHING THE LIGHT, THE CAR CUT OFF. I SHIFT THE GEAR BACK TO PARK AND RESTARTED THE VEHICLE AND PROCEEDED. THE CAR HAD BEEN WARM FOR 20 MINUTES AND IT WAS AROUND 7:40 A.M. IN THE MORNING. THIS IS AT LEAST THE 8TH INCIDENT WHERE I'VE BEEN IN THE MIDDLE OF TRAFFIC AND HAVING TO RESTART MY VEHICLE. I'M CONCERNED ABOUT A POSSIBLE ACCIDENT IN THE NEAR BY FUTURE. AFTER TAKING IT BACK TO THE DEALERSHIP IN FEBRUARY, THEY SUGGESTED THAT I TRIED USING FUEL FROM MORE REPUTABLE GAS STATIONS SUCH AS SHELL, TEXACO, AMOCO. USING BETTER GAS HAS NOT RESOVED THIS PROBLEM.*AK
WHILE DRIVING, THE VEHICLE WOULD JUST SHUT DOWN. THIS CAUSED ALL THE FUNCTIONS OF THE VEHICLE TO BECOME INOPERABLE. THERE WAS NO WARNING. THE VEHICLE WOULD NOT START AGAIN FOR A COUPLE OF HOURS. THE CONSUMER CONTACTED THE DEALER. HOWEVER, THE PROBLEM RECURRED. *AK IN ATTEMPTS TO CORRECT THE PROBLEM THE IGNITION RELAY #59 …
Read full complaint
WHILE DRIVING, THE VEHICLE WOULD JUST SHUT DOWN. THIS CAUSED ALL THE FUNCTIONS OF THE VEHICLE TO BECOME INOPERABLE. THERE WAS NO WARNING. THE VEHICLE WOULD NOT START AGAIN FOR A COUPLE OF HOURS. THE CONSUMER CONTACTED THE DEALER. HOWEVER, THE PROBLEM RECURRED. *AK IN ATTEMPTS TO CORRECT THE PROBLEM THE IGNITION RELAY #59 IN THE FUSE BOX AND THE DAMPNESS/CORROSION ON THE TERMINALS TO THE BODY CONNECTOR OF THE FUEL PUMP WERE REPLACED ON TWO SEPARATE OCCASIONS. *SC
THE VEHICLE STALLED WHEN DRIVING ON THE HIGHWAY. THE VEHICLE WOULD SOMETIMES CUT COMPLETELY OFF. THE VEHICLE WAS TAKEN TO THE DEALER FOR SERVICE, BUT THE DEALER COULD NOT DUPLICATE THE PROBLEM. *AK WHILE THE DEALER WAS TRYING TO FIND THE PROBLEM WITH THE STALLING, THEY FOUND THAT THE BRAKE MODULE LOST COMMUNICATION WITH TH…
Read full complaint
THE VEHICLE STALLED WHEN DRIVING ON THE HIGHWAY. THE VEHICLE WOULD SOMETIMES CUT COMPLETELY OFF. THE VEHICLE WAS TAKEN TO THE DEALER FOR SERVICE, BUT THE DEALER COULD NOT DUPLICATE THE PROBLEM. *AK WHILE THE DEALER WAS TRYING TO FIND THE PROBLEM WITH THE STALLING, THEY FOUND THAT THE BRAKE MODULE LOST COMMUNICATION WITH THE COMPUTER. THE STALLING PROBLEM CONTINUED TO OCCUR. OTHER PROBLEMS WERE: THE BATTERY LIGHT HAD COME ON FOLLOWED BY ENGINE STALLING, THE EBCM WAS INTERMITTENTLY DROPPING OUT THEREFORE THE IGNITION RELAY WAS REPLACED AND THE LIFTGATE DID NOT OPEN PROPERLY. *SC *JB
CONSUMER EXPERIENCED A PROBLEM WITH OIL LEAKING INTO AN ELECTRICAL WIRING SLEEVE NEAR THE OIL PLUG WHENEVER THE VEHICLE GOT AN OIL CHANGE. OIL LEAKING INTO THE WIRING SLEEVE MAY CAUSE A FIRE. DEALER WAS NOTIFIED.*AK
I TRAVEL FROM MICHIGAN TO FLORIDA EVERY YEAR AND IN JUNE 2004 BOUGHT A BUICK RENDEZVOUS. IT INTERMITTENTLY DOES NOT WANT TO START. NEVER KNOW WHEN IT WILL HAPPEN. IS THERE A RECALL OR PROBLEM WITH THIS? MY HUSBAND TOOK THE CAR TO THE DEALERSHIP AND LEFT IT AND THEY SHUTTLED HIM HOME. INSIDE THE SHUTTLE WAS ANOTHER MAN WITH…
Read full complaint
I TRAVEL FROM MICHIGAN TO FLORIDA EVERY YEAR AND IN JUNE 2004 BOUGHT A BUICK RENDEZVOUS. IT INTERMITTENTLY DOES NOT WANT TO START. NEVER KNOW WHEN IT WILL HAPPEN. IS THERE A RECALL OR PROBLEM WITH THIS? MY HUSBAND TOOK THE CAR TO THE DEALERSHIP AND LEFT IT AND THEY SHUTTLED HIM HOME. INSIDE THE SHUTTLE WAS ANOTHER MAN WITH THE SAME PROBLEM WITH HIS RENDEZVOUS. SOUNDS LIKE SOMETHING WE SHOULD WORRY ABOUT...
PURCHASED THE VEHICLE ON 7/15/04, 3 DAYS LATER UPON STARTUP THE SECURITY LIGHT ON THE DASHBOARD CAME ON AND STAYED ON UNTIL THE VEHICLE WAS RESTARTED. DEALER REPLACED A BODY CONTROL MODULE AND THAT SOLVED THE PROBLEM. IN OCTOBER 04, THE ENGINE STALLED WHILE PULLING INTO A PARKING SPACE; AS THE ENGINE STALLED THE CHECK ENGINE …
Read full complaint
PURCHASED THE VEHICLE ON 7/15/04, 3 DAYS LATER UPON STARTUP THE SECURITY LIGHT ON THE DASHBOARD CAME ON AND STAYED ON UNTIL THE VEHICLE WAS RESTARTED. DEALER REPLACED A BODY CONTROL MODULE AND THAT SOLVED THE PROBLEM. IN OCTOBER 04, THE ENGINE STALLED WHILE PULLING INTO A PARKING SPACE; AS THE ENGINE STALLED THE CHECK ENGINE LIGHT CAME ON. VEHICLE RESTARTED AND CHECK ENGINE LIGHT TURNED OFF. HAD VEHICLE TOWED TO THE DEALER AND SEVERAL BODY CONTROL MODULES WERE REPLACED. DURING THIS TIME HAD AN INTERMITTENT PROBLEM WITH THE RADIO NOT HOLDING PRESETS, ALSO UPON STARTUP THE RADIO WOULD RANDOMLY PICK A STATION THAT WAS NOT PRESET. I WILL HAVE TO RETURN TO THE DEALER IN THE NEAR FUTURE FOR A POSSIBLE PROBLEM WITH THE ANTI-THEFT; THE DASHBOARD LIGHT DOES NOT FLASH TO SHOW THAT IT IS ARMED, ALSO A RUBBING NOISE COMING FROM THE RIGHT FRONT AREA JUST AS THE VEHICLE STARTS TO MOVE EITHER FORWARD OR REARWARD. WORST AMERICAN CAR I HAVE EVER OWNED AND WILL NEVER BUY ANOTHER GM CAR AGAIN.*AK
VEHICLE STALLS INTERMITTANTLY WHILE IN MOTION. COULD BE DANGEROUS ON BUSY ROAD. WAS CHECKED BY DEALER TWICE BUT NO CAUSE FOUND.*AK
Official recalls
407V349000 · Fuel System, Gasoline:storage
Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
05V157000 · Electrical System:ignition
Apr 20, 2005
ON CERTAIN SPORT UTILITY VEHICLES, CONTAMINATION ON IGNITION RELAY CONTACTS CAN CAUSE HIGH RESISTANCE. THIS CAN AFFECT SIGNALS TO THE POWERTRAIN CONTROL MODULE AND, COULD CAUSE INTERMITTENT VEHICLE STALLS AT ANY TIME.
Consequence & remedy
Consequence: THE VEHICLE CANNOT BE RESTARTED IMMEDIATELY. IF THIS WERE TO OCCUR, IT COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION RELAY FREE OF CHARGE. THE RECALL BEGAN ON MAY 4, 2005. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND BUICK AT 1-866-608-8080.
04V150000 · Latches/locks/linkages:hatchback/liftgate:lock
Mar 29, 2004
ON CERTAIN SPORT UTILITY VEHICLES, A STRUCTURAL SUPPORT AT THE LATCH ATTACHMENT IN THE REAR LIFTGATE MAY BE INADEQUATE TO RETAIN THE LATCH TO THE LIFTGATE IN CERTAIN SEVERE VEHICLE CRASH EVENTS.
Consequence & remedy
Consequence: IF THE LIFTGATE WERE TO OPEN IN A VEHICLE CRASH, AN OCCUPANT COULD BE EJECTED FROM THE VEHICLE RESULTING IN INCREASED RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL ADD STRUCTURAL REINFORCEMENTS TO THE LIFTGATE IN THE AREA ADJOINING THE LATCH ASSEMBLY. OWNER NOTIFICATION SCHEDULE BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080. THIS IS AN EXPANSION TO A PREVIOUS RECALL (03V211).
03V454000 · Fuel System, Gasoline:storage
Nov 10, 2003
ON CERTAIN PASSENGER VEHICLES, A WELD BETWEEN THE FUEL TANK INLET CHECK VALVE AND THE FUEL TANK CAN FAIL.
Consequence & remedy
Consequence: IF THESE PARTS SEPARATE, THE DRIVER MAY NOTICE AN ODOR OF FUEL, THE SERVICE ENGINE SOON OR CHECK ENGINE LIGHT MAY ILLUMINATE, AND/OR FUEL MAY LEAK ONTO THE GROUND. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE SERIAL NUMBER OF THE FUEL TANK TO SEE IF IT IS ON THE LIST OF AFFECTED TANKS. IF THE SERIAL NUMBER MATCHES, THE FUEL TANK WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07006 · Fuel Tank Leakage
Opened Apr 18, 2007 · Closed Sep 13, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (5)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
RQ06009 · Fuel Tank Leakage
Opened Dec 14, 2006 · Closed Apr 18, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Additional source detail variants (4)
Fuel System, Gasoline
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
PE04075 · Ignition Relay Failure
Opened Nov 10, 2004 · Closed Apr 28, 2005
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:module
ON NOVEMBER 10, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE THE FAILURE, MALFUNCTION, OR OTHER UNSATISFACTORY PERFORMANCE OF THE ENGINE CONTROL SYSTEM WHICH MAY RESULT IN ENGINE STALLING IN CERTAIN MODEL YEAR (MY) 2004 BUICK RENDEZVOUS (GMT250) AND PONTIAC AZTEK (GMT250) VEHICLES ALLEGEDLY CAUSED BY IGNITION RELAY FAILURE.ODI IS AWARE OF 68 NON-DUPLICATIVE COMPLAINTS AND 1092 WARRANTY CLAIMS RELATED TO THE SUBJECT ISSUE.THERE ARE NO KNOWN CRASHES RELATED TO IGNITION RELAY FAILURE ON THE SUBJECT VEHICLES.BY LETTER DATED APRIL 19, 2005, GENERAL MOTORS CORP. (GM) HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-157) TO REPLACE DEFECTIVE IGNITION RELAY MODULES IN APPROXIMATELY 34,996 SUBJECT VEHICLES BUILT BETWEEN OCTOBER 13, 2003 AND MARCH 8, 2004.THIS PERIOD OF VEHICLE PRODUCTION IS ASSOCIATED WITH ESCALATED WARRANTY CLAIMS RATES AND COMPLAINTS THAT ALLEGE ENGINE STALL DUE TO IGNITION RELAY FAILURE.GM HAS IDENTIFIED PARTS SUPPLIERS WHO USED MATERIALS CONTAINING SILICONE IN THE MANUFACTURE OF SPECIFIC COMPONENTS FOR THE IGNITION RELAY MODULE.SILICONE CONTAMINATION CAN RESULT IN SILICA DEPOSITS FORMING ON THE CONTACTS AS THE RELAY SWITCHES AND THE HEAT GENERATED BY THE RESULTANT ARC CONVERTS THE SILICONE TO SILICA.SILICA BUILD-UP ON THE CONTACTS IS PROGRESSIVE AND MAY PRODUCE A VOLTAGE DROP ACROSS THE RELAY SUFFICIENT TO CAUSE AN INTERMITTENT NO-START OR ENGINE STALL CONDITION.WARRANTY ANALYSIS INDICATES THE INCIDENCE OF NO/HARD START VERSUS ENGINE STALL TO BE EQUAL.ANALYSIS OF TOWING CLAIMS AND DETAILED SERVICE RECORDS INDICATES THAT VEHICLES MAY EXPERIENCE RESTART DIFFICULTIES AFTER A STALLING INCIDENT APPROXIMATELY 20-30 PERCENT OF THE TIME.THE USE OF SILICONE MATERIALS IN THE MANUFACTURE OF THE SUBJECT IGNITION RELAY HAS BEEN DISCONTINUED.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:ignition
ON NOVEMBER 10, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE THE FAILURE, MALFUNCTION, OR OTHER UNSATISFACTORY PERFORMANCE OF THE ENGINE CONTROL SYSTEM WHICH MAY RESULT IN ENGINE STALLING IN CERTAIN MODEL YEAR (MY) 2004 BUICK RENDEZVOUS (GMT250) AND PONTIAC AZTEK (GMT250) VEHICLES ALLEGEDLY CAUSED BY IGNITION RELAY FAILURE.ODI IS AWARE OF 68 NON-DUPLICATIVE COMPLAINTS AND 1092 WARRANTY CLAIMS RELATED TO THE SUBJECT ISSUE.THERE ARE NO KNOWN CRASHES RELATED TO IGNITION RELAY FAILURE ON THE SUBJECT VEHICLES.BY LETTER DATED APRIL 19, 2005, GENERAL MOTORS CORP. (GM) HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-157) TO REPLACE DEFECTIVE IGNITION RELAY MODULES IN APPROXIMATELY 34,996 SUBJECT VEHICLES BUILT BETWEEN OCTOBER 13, 2003 AND MARCH 8, 2004.THIS PERIOD OF VEHICLE PRODUCTION IS ASSOCIATED WITH ESCALATED WARRANTY CLAIMS RATES AND COMPLAINTS THAT ALLEGE ENGINE STALL DUE TO IGNITION RELAY FAILURE.GM HAS IDENTIFIED PARTS SUPPLIERS WHO USED MATERIALS CONTAINING SILICONE IN THE MANUFACTURE OF SPECIFIC COMPONENTS FOR THE IGNITION RELAY MODULE.SILICONE CONTAMINATION CAN RESULT IN SILICA DEPOSITS FORMING ON THE CONTACTS AS THE RELAY SWITCHES AND THE HEAT GENERATED BY THE RESULTANT ARC CONVERTS THE SILICONE TO SILICA.SILICA BUILD-UP ON THE CONTACTS IS PROGRESSIVE AND MAY PRODUCE A VOLTAGE DROP ACROSS THE RELAY SUFFICIENT TO CAUSE AN INTERMITTENT NO-START OR ENGINE STALL CONDITION.WARRANTY ANALYSIS INDICATES THE INCIDENCE OF NO/HARD START VERSUS ENGINE STALL TO BE EQUAL.ANALYSIS OF TOWING CLAIMS AND DETAILED SERVICE RECORDS INDICATES THAT VEHICLES MAY EXPERIENCE RESTART DIFFICULTIES AFTER A STALLING INCIDENT APPROXIMATELY 20-30 PERCENT OF THE TIME.THE USE OF SILICONE MATERIALS IN THE MANUFACTURE OF THE SUBJECT IGNITION RELAY HAS BEEN DISCONTINUED.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:ignition:module
ON NOVEMBER 10, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE THE FAILURE, MALFUNCTION, OR OTHER UNSATISFACTORY PERFORMANCE OF THE ENGINE CONTROL SYSTEM WHICH MAY RESULT IN ENGINE STALLING IN CERTAIN MODEL YEAR (MY) 2004 BUICK RENDEZVOUS (GMT250) AND PONTIAC AZTEK (GMT250) VEHICLES ALLEGEDLY CAUSED BY IGNITION RELAY FAILURE.ODI IS AWARE OF 68 NON-DUPLICATIVE COMPLAINTS AND 1092 WARRANTY CLAIMS RELATED TO THE SUBJECT ISSUE.THERE ARE NO KNOWN CRASHES RELATED TO IGNITION RELAY FAILURE ON THE SUBJECT VEHICLES.BY LETTER DATED APRIL 19, 2005, GENERAL MOTORS CORP. (GM) HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-157) TO REPLACE DEFECTIVE IGNITION RELAY MODULES IN APPROXIMATELY 34,996 SUBJECT VEHICLES BUILT BETWEEN OCTOBER 13, 2003 AND MARCH 8, 2004.THIS PERIOD OF VEHICLE PRODUCTION IS ASSOCIATED WITH ESCALATED WARRANTY CLAIMS RATES AND COMPLAINTS THAT ALLEGE ENGINE STALL DUE TO IGNITION RELAY FAILURE.GM HAS IDENTIFIED PARTS SUPPLIERS WHO USED MATERIALS CONTAINING SILICONE IN THE MANUFACTURE OF SPECIFIC COMPONENTS FOR THE IGNITION RELAY MODULE.SILICONE CONTAMINATION CAN RESULT IN SILICA DEPOSITS FORMING ON THE CONTACTS AS THE RELAY SWITCHES AND THE HEAT GENERATED BY THE RESULTANT ARC CONVERTS THE SILICONE TO SILICA.SILICA BUILD-UP ON THE CONTACTS IS PROGRESSIVE AND MAY PRODUCE A VOLTAGE DROP ACROSS THE RELAY SUFFICIENT TO CAUSE AN INTERMITTENT NO-START OR ENGINE STALL CONDITION.WARRANTY ANALYSIS INDICATES THE INCIDENCE OF NO/HARD START VERSUS ENGINE STALL TO BE EQUAL.ANALYSIS OF TOWING CLAIMS AND DETAILED SERVICE RECORDS INDICATES THAT VEHICLES MAY EXPERIENCE RESTART DIFFICULTIES AFTER A STALLING INCIDENT APPROXIMATELY 20-30 PERCENT OF THE TIME.THE USE OF SILICONE MATERIALS IN THE MANUFACTURE OF THE SUBJECT IGNITION RELAY HAS BEEN DISCONTINUED.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.