A COMPLETE ELECTRICAL SYSTEM FAILURE OCCURS PERIODICALLY WITHOUT ANY WARNING ON MY 2004 BUICK RENDEZVOUS. THIS IS THE EXACT SAME PROBLEM IN THE RECALL NOTICE ISSUED BY NHTSA 05V157000. I CONTACT GM ABOUT THIS PROBLEM AND THEIR POSITION IS THE RECALL IS NOT SPECIFIC/COVERED BY MY VIN NUMBER. I SUGGEST ALL 2004 BUICK RENDEZVOUS BE…
Read full complaint
A COMPLETE ELECTRICAL SYSTEM FAILURE OCCURS PERIODICALLY WITHOUT ANY WARNING ON MY 2004 BUICK RENDEZVOUS. THIS IS THE EXACT SAME PROBLEM IN THE RECALL NOTICE ISSUED BY NHTSA 05V157000. I CONTACT GM ABOUT THIS PROBLEM AND THEIR POSITION IS THE RECALL IS NOT SPECIFIC/COVERED BY MY VIN NUMBER. I SUGGEST ALL 2004 BUICK RENDEZVOUS BE CONSIDERED FOR THIS RECALL AS THIS IS A POTENTIALLY SERIOUS PROBLEM. *TR
NHTSA ODI #10244974
67,000 miles · Apr 12, 2008
Electrical System
SPEED GAUGE KEEPS SPENDING AROUND WONT STAY ADJUSTED. MY REAR DEFROST WON'T WORK TRIED FUSES KEEP BLOWING OUT. *TR
NHTSA ODI #10224301
Mileage unknown · Sep 10, 2007
Electrical SystemCrashInjury
2004 BUICK RENDEZVOUS ENGINE STALLS WHILE DRIVING. CONSUMER STATES THAT HE WAS DRIVING AROUND 65 MPH WHEN THE ENGINE SHUT OFF WITHOUT WARNING. CUSTOMER STATES HE IS PAYING FOR BUICK'S MISTAKE. *KB THE CONSUMER WAS UNABLE TO STEER OR STOP THE VEHICLE. THE VEHICLE VEERED INTO ONCOMING TRAFFIC WHICH CAUSED THE CONSUMER TO HAVE A…
Read full complaint
2004 BUICK RENDEZVOUS ENGINE STALLS WHILE DRIVING. CONSUMER STATES THAT HE WAS DRIVING AROUND 65 MPH WHEN THE ENGINE SHUT OFF WITHOUT WARNING. CUSTOMER STATES HE IS PAYING FOR BUICK'S MISTAKE. *KB THE CONSUMER WAS UNABLE TO STEER OR STOP THE VEHICLE. THE VEHICLE VEERED INTO ONCOMING TRAFFIC WHICH CAUSED THE CONSUMER TO HAVE A FATAL ACCIDENT INVOLVING ANOTHER MOTORIST. THE CONSUMER WAS INJURED. EIGHT MONTHS LATER, THE CONSUMER RECEIVED A RECEIVED A RECALL STATING THE ENGINE COULD SHUT DOWN AND RESULT IN A CRASH. *JB THE CONSUMER REQUESTED RECALL INFORMATION. UPDATED 03/24/12
NHTSA ODI #10203725
35,000 miles · Apr 2, 2007
Electrical SystemSteering
WE HAVE A 2004 BUICK RENDEZVOUS THAT DOES NOT KEEP ACCURATE SPEEDOMETER READINGS AND IT JUMPS LANES OR SEVERELY PULLS TO THE LEFT. WE HAVE BEEN TRYING TO GET THIS REPAIRED BUT IT DOES NOT DO THESE THINGS WHEN THE DEALER DRIVES IT. THIS HAS GONE ON OVER 3 MONTHS. THE SPEEDOMETER READS EXCESSIVE SPEEDS OVER 100 MPH OR IT READS 20…
Read full complaint
WE HAVE A 2004 BUICK RENDEZVOUS THAT DOES NOT KEEP ACCURATE SPEEDOMETER READINGS AND IT JUMPS LANES OR SEVERELY PULLS TO THE LEFT. WE HAVE BEEN TRYING TO GET THIS REPAIRED BUT IT DOES NOT DO THESE THINGS WHEN THE DEALER DRIVES IT. THIS HAS GONE ON OVER 3 MONTHS. THE SPEEDOMETER READS EXCESSIVE SPEEDS OVER 100 MPH OR IT READS 20 MPH SITTING IN THE DRIVE. WE HAVE PICTURES OF THE SPEEDOMETER READING 100+ MILES PER HOUR BUT THEY WONT TAKE THOSE. THE DEALER CAN NOT GET THE NAC WARRANTY DEPARTMENT TO COVER OR REPLACE THE CLUSTER BECAUSE THEY CANT DUPLICATE THE PROBLEM. I RECENTLY READ WHERE THERE IS A CLASS ACTION LAWSUIT AGAINST GM DUE TO THE SAME SPEEDOMETER ISSUES. *JB
NHTSA ODI #10186733
Mileage unknown · Mar 9, 2007
Electrical SystemFuel System, Gasoline
1. 2004 BUICK RENDEZVOUS STALLS DRIVING AT ALL SPEEDS. WILL NOT RESTART UNTIL IT SITS AWHILE. 2. STARTER STAYS ENGAGED AND WHINES AFTER ENGINE STARTS FOR APROX. 3 TO 4 SECONDS. 3. THE GAS TANK IS LEAKING AROUND THE FILLER NECK WHERE THE TANK IS (WELDED). ALL OF THESE PROBLEMS HAVE BEEN LOOKED AT BY 2 DEALERSHIPS AND I HAV…
Read full complaint
1. 2004 BUICK RENDEZVOUS STALLS DRIVING AT ALL SPEEDS. WILL NOT RESTART UNTIL IT SITS AWHILE. 2. STARTER STAYS ENGAGED AND WHINES AFTER ENGINE STARTS FOR APROX. 3 TO 4 SECONDS. 3. THE GAS TANK IS LEAKING AROUND THE FILLER NECK WHERE THE TANK IS (WELDED). ALL OF THESE PROBLEMS HAVE BEEN LOOKED AT BY 2 DEALERSHIPS AND I HAVE CONTACTED GM TO GET THESE PROBLEMS, ALL OF WHICH ARE RECALL PROBLEMS FIXED. GM WILL NOT REPAIR MY VEHICLE AFTER ONE OF THE DEALERSHIP SERVICE DEPARTMENTS STATED THAT MY VEHICLE WAS CONSIDERED UNDRIVEABLE AND A SERIOUS VEHICLE HAZARD. GM STATED THAT SINCE MY VEHICLE WAS A PART MADE BY A DIFFERENT MANUFACTURER THE EXACT PROBLEMS ON THE RECALL WOULD NOT APPLY. REPAIR COST ESTIMATE WAS APROX. $1200. GAS LEAK IS ABOUT 8 INCHES AWAY FROM THE LEFT REAR "HOT" BRAKE ROTOR "FIRE". *JB EA07-006.PCO
NHTSA ODI #10184687
23,685 miles · Feb 24, 2007
Electrical SystemEquipment
1) UPON RUNNING THE AIR CONDITIONER ON HOT DAYS, IT WOULD MAKE LOUD MOANING SOUND WHEN IGNITION WAS SHUT OFF 2) COMPRESSOR HAS GONE OUT FOR THE SECOND TIME AND AIR CONDITIONER WILL NO LONGER BLOW COLD AIR. 3) 03/05 REPLACED VALVE CORE AND 08/05 R&R OR REPLACED CASE. *JB
NHTSA ODI #10183418
42,000 miles · Nov 6, 2006
Electrical System
2004 BUICK RENDEZVOUS QUITS RUNNING. ENGINE SHUTS OFF WHILE DRIVING. DEALER REPLACED PCM AND SOME PART OF A WIRING HARNESS. CAR WAS GOOD FOR 3 MONTHS AND THEN THE PROBLEM CAME BACK. HAD IT TOWED TO A GARAGE THAT DISCONNECTED AND RECONNECTED MODULES AND WHATEVER. CAR WAS GOOD FOR A MONTH AND THEN TODAY IT QUIT RUNNING AGAIN. …
Read full complaint
2004 BUICK RENDEZVOUS QUITS RUNNING. ENGINE SHUTS OFF WHILE DRIVING. DEALER REPLACED PCM AND SOME PART OF A WIRING HARNESS. CAR WAS GOOD FOR 3 MONTHS AND THEN THE PROBLEM CAME BACK. HAD IT TOWED TO A GARAGE THAT DISCONNECTED AND RECONNECTED MODULES AND WHATEVER. CAR WAS GOOD FOR A MONTH AND THEN TODAY IT QUIT RUNNING AGAIN. IT IS A DANGEROUS SITUATION THAT NEEDS TO BE ADDRESSED. *NM
NHTSA ODI #10172798
33,000 miles · Mar 29, 2006
Electrical SystemCrash
DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED, THE KEYS WERE LEFT IN THE IGNITION. THE CONTACT'S TWO AND A HALF YEAR OLD CHILD TURNED THE KEYS TO THE ACCESSORY POSITION. ONCE THE KEY WAS TURNED, THE CHILD WAS ABLE TO TAKE THE VEHICLE OUT OF THE PARK POSITION AND PLACE THE GEAR SHIFTER INTO REVERSE WITHOUT DEPRESSING TH…
Read full complaint
DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED, THE KEYS WERE LEFT IN THE IGNITION. THE CONTACT'S TWO AND A HALF YEAR OLD CHILD TURNED THE KEYS TO THE ACCESSORY POSITION. ONCE THE KEY WAS TURNED, THE CHILD WAS ABLE TO TAKE THE VEHICLE OUT OF THE PARK POSITION AND PLACE THE GEAR SHIFTER INTO REVERSE WITHOUT DEPRESSING THE BRAKE PEDAL. THE VEHICLE ROLLED OUT OF THE DRIVEWAY, ROLLED 100 FEET THEN CRASHED INTO A FENCE. THE CHILD ESCAPED UNHARMED ALTHOUGH THERE WAS DAMAGED SUSTAINED TO THE VEHICLE AND THE FENCE. THE POLICE WERE NOT NOTIFIED SINCE THE INCIDENT HAPPENED ON PRIVATE PROPERTY. THE INSURANCE COMPANY WAS ALSO NOT NOTIFIED.
NHTSA ODI #10153975
Mileage unknown · Mar 1, 2006
Electrical System
2004 BUICK RENDEZVOUS - EXTREMELY UNRELIABLE HORN (DESIGN FLAW). I HAVE NARROWLY ESCAPED MANY ACCIDENTS BY SHEER LUCK. HAVE HAD PEOPLE BACKING INTO ME & BEEN UNABLE TO HONK THE HORN BECAUSE I COULD NOT FIND THE VERY LIMITED "SWEET SPOT." WHEN THE STEERING WHEEL IS TURNED EVEN SLIGHTLY, IT IS IMPOSSIBLE TO FIND! *JB
NHTSA ODI #10151501
8,000 miles · Dec 28, 2005
Electrical System
I HAVE A 2004 BUICK RENDEZVOUS. BOUGHT IN DEC 04. THE FIRST STALL WAS SUMMER OF 05. THANK GOD EACH TIME IT STALLED, I WAS GOING 20 MPH OR LESS. I AM TRULY CONCERNED ABOUT THE SAFETY FACTOR. WE HAVE TAKEN IT TO THE DEALER EACH TIME - THE DID THE RECALL ON THE IGNITION SWITCH - STALLS CONTINUE TO HAPPEN. THEY ARE NOT ABLE TO…
Read full complaint
I HAVE A 2004 BUICK RENDEZVOUS. BOUGHT IN DEC 04. THE FIRST STALL WAS SUMMER OF 05. THANK GOD EACH TIME IT STALLED, I WAS GOING 20 MPH OR LESS. I AM TRULY CONCERNED ABOUT THE SAFETY FACTOR. WE HAVE TAKEN IT TO THE DEALER EACH TIME - THE DID THE RECALL ON THE IGNITION SWITCH - STALLS CONTINUE TO HAPPEN. THEY ARE NOT ABLE TO RECREATE THE PROBLEM. IT WILL BE GOING IN TO THE DEALER FOR THE 3RD TIME VERY SOON, AS IT STALLED AGAIN OVER CHRISTMAS. THE STARTER HAS BEGUN TO SOUND FUNNY - CAR HOLDS CRANK TOO LONG, DOES NOT SOUND RIGHT. *JB
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
ON CERTAIN SPORT UTILITY VEHICLES, CONTAMINATION ON IGNITION RELAY CONTACTS CAN CAUSE HIGH RESISTANCE. THIS CAN AFFECT SIGNALS TO THE POWERTRAIN CONTROL MODULE AND, COULD CAUSE INTERMITTENT VEHICLE STALLS AT ANY TIME.
Consequence & remedy
Consequence: THE VEHICLE CANNOT BE RESTARTED IMMEDIATELY. IF THIS WERE TO OCCUR, IT COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION RELAY FREE OF CHARGE. THE RECALL BEGAN ON MAY 4, 2005. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND BUICK AT 1-866-608-8080.
ON CERTAIN SPORT UTILITY VEHICLES, A STRUCTURAL SUPPORT AT THE LATCH ATTACHMENT IN THE REAR LIFTGATE MAY BE INADEQUATE TO RETAIN THE LATCH TO THE LIFTGATE IN CERTAIN SEVERE VEHICLE CRASH EVENTS.
Consequence & remedy
Consequence: IF THE LIFTGATE WERE TO OPEN IN A VEHICLE CRASH, AN OCCUPANT COULD BE EJECTED FROM THE VEHICLE RESULTING IN INCREASED RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL ADD STRUCTURAL REINFORCEMENTS TO THE LIFTGATE IN THE AREA ADJOINING THE LATCH ASSEMBLY. OWNER NOTIFICATION SCHEDULE BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080. THIS IS AN EXPANSION TO A PREVIOUS RECALL (03V211).
ON CERTAIN PASSENGER VEHICLES, A WELD BETWEEN THE FUEL TANK INLET CHECK VALVE AND THE FUEL TANK CAN FAIL.
Consequence & remedy
Consequence: IF THESE PARTS SEPARATE, THE DRIVER MAY NOTICE AN ODOR OF FUEL, THE SERVICE ENGINE SOON OR CHECK ENGINE LIGHT MAY ILLUMINATE, AND/OR FUEL MAY LEAK ONTO THE GROUND. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE SERIAL NUMBER OF THE FUEL TANK TO SEE IF IT IS ON THE LIST OF AFFECTED TANKS. IF THE SERIAL NUMBER MATCHES, THE FUEL TANK WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA07006 · Fuel Tank Leakage
Opened Apr 18, 2007 · Closed Sep 13, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (5)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
RQ06009 · Fuel Tank Leakage
Opened Dec 14, 2006 · Closed Apr 18, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Additional source detail variants (4)
Fuel System, Gasoline
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
ON NOVEMBER 10, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE THE FAILURE, MALFUNCTION, OR OTHER UNSATISFACTORY PERFORMANCE OF THE ENGINE CONTROL SYSTEM WHICH MAY RESULT IN ENGINE STALLING IN CERTAIN MODEL YEAR (MY) 2004 BUICK RENDEZVOUS (GMT250) AND PONTIAC AZTEK (GMT250) VEHICLES ALLEGEDLY CAUSED BY IGNITION RELAY FAILURE.ODI IS AWARE OF 68 NON-DUPLICATIVE COMPLAINTS AND 1092 WARRANTY CLAIMS RELATED TO THE SUBJECT ISSUE.THERE ARE NO KNOWN CRASHES RELATED TO IGNITION RELAY FAILURE ON THE SUBJECT VEHICLES.BY LETTER DATED APRIL 19, 2005, GENERAL MOTORS CORP. (GM) HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-157) TO REPLACE DEFECTIVE IGNITION RELAY MODULES IN APPROXIMATELY 34,996 SUBJECT VEHICLES BUILT BETWEEN OCTOBER 13, 2003 AND MARCH 8, 2004.THIS PERIOD OF VEHICLE PRODUCTION IS ASSOCIATED WITH ESCALATED WARRANTY CLAIMS RATES AND COMPLAINTS THAT ALLEGE ENGINE STALL DUE TO IGNITION RELAY FAILURE.GM HAS IDENTIFIED PARTS SUPPLIERS WHO USED MATERIALS CONTAINING SILICONE IN THE MANUFACTURE OF SPECIFIC COMPONENTS FOR THE IGNITION RELAY MODULE.SILICONE CONTAMINATION CAN RESULT IN SILICA DEPOSITS FORMING ON THE CONTACTS AS THE RELAY SWITCHES AND THE HEAT GENERATED BY THE RESULTANT ARC CONVERTS THE SILICONE TO SILICA.SILICA BUILD-UP ON THE CONTACTS IS PROGRESSIVE AND MAY PRODUCE A VOLTAGE DROP ACROSS THE RELAY SUFFICIENT TO CAUSE AN INTERMITTENT NO-START OR ENGINE STALL CONDITION.WARRANTY ANALYSIS INDICATES THE INCIDENCE OF NO/HARD START VERSUS ENGINE STALL TO BE EQUAL.ANALYSIS OF TOWING CLAIMS AND DETAILED SERVICE RECORDS INDICATES THAT VEHICLES MAY EXPERIENCE RESTART DIFFICULTIES AFTER A STALLING INCIDENT APPROXIMATELY 20-30 PERCENT OF THE TIME.THE USE OF SILICONE MATERIALS IN THE MANUFACTURE OF THE SUBJECT IGNITION RELAY HAS BEEN DISCONTINUED.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:ignition
ON NOVEMBER 10, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE THE FAILURE, MALFUNCTION, OR OTHER UNSATISFACTORY PERFORMANCE OF THE ENGINE CONTROL SYSTEM WHICH MAY RESULT IN ENGINE STALLING IN CERTAIN MODEL YEAR (MY) 2004 BUICK RENDEZVOUS (GMT250) AND PONTIAC AZTEK (GMT250) VEHICLES ALLEGEDLY CAUSED BY IGNITION RELAY FAILURE.ODI IS AWARE OF 68 NON-DUPLICATIVE COMPLAINTS AND 1092 WARRANTY CLAIMS RELATED TO THE SUBJECT ISSUE.THERE ARE NO KNOWN CRASHES RELATED TO IGNITION RELAY FAILURE ON THE SUBJECT VEHICLES.BY LETTER DATED APRIL 19, 2005, GENERAL MOTORS CORP. (GM) HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-157) TO REPLACE DEFECTIVE IGNITION RELAY MODULES IN APPROXIMATELY 34,996 SUBJECT VEHICLES BUILT BETWEEN OCTOBER 13, 2003 AND MARCH 8, 2004.THIS PERIOD OF VEHICLE PRODUCTION IS ASSOCIATED WITH ESCALATED WARRANTY CLAIMS RATES AND COMPLAINTS THAT ALLEGE ENGINE STALL DUE TO IGNITION RELAY FAILURE.GM HAS IDENTIFIED PARTS SUPPLIERS WHO USED MATERIALS CONTAINING SILICONE IN THE MANUFACTURE OF SPECIFIC COMPONENTS FOR THE IGNITION RELAY MODULE.SILICONE CONTAMINATION CAN RESULT IN SILICA DEPOSITS FORMING ON THE CONTACTS AS THE RELAY SWITCHES AND THE HEAT GENERATED BY THE RESULTANT ARC CONVERTS THE SILICONE TO SILICA.SILICA BUILD-UP ON THE CONTACTS IS PROGRESSIVE AND MAY PRODUCE A VOLTAGE DROP ACROSS THE RELAY SUFFICIENT TO CAUSE AN INTERMITTENT NO-START OR ENGINE STALL CONDITION.WARRANTY ANALYSIS INDICATES THE INCIDENCE OF NO/HARD START VERSUS ENGINE STALL TO BE EQUAL.ANALYSIS OF TOWING CLAIMS AND DETAILED SERVICE RECORDS INDICATES THAT VEHICLES MAY EXPERIENCE RESTART DIFFICULTIES AFTER A STALLING INCIDENT APPROXIMATELY 20-30 PERCENT OF THE TIME.THE USE OF SILICONE MATERIALS IN THE MANUFACTURE OF THE SUBJECT IGNITION RELAY HAS BEEN DISCONTINUED.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:ignition:module
ON NOVEMBER 10, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE THE FAILURE, MALFUNCTION, OR OTHER UNSATISFACTORY PERFORMANCE OF THE ENGINE CONTROL SYSTEM WHICH MAY RESULT IN ENGINE STALLING IN CERTAIN MODEL YEAR (MY) 2004 BUICK RENDEZVOUS (GMT250) AND PONTIAC AZTEK (GMT250) VEHICLES ALLEGEDLY CAUSED BY IGNITION RELAY FAILURE.ODI IS AWARE OF 68 NON-DUPLICATIVE COMPLAINTS AND 1092 WARRANTY CLAIMS RELATED TO THE SUBJECT ISSUE.THERE ARE NO KNOWN CRASHES RELATED TO IGNITION RELAY FAILURE ON THE SUBJECT VEHICLES.BY LETTER DATED APRIL 19, 2005, GENERAL MOTORS CORP. (GM) HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-157) TO REPLACE DEFECTIVE IGNITION RELAY MODULES IN APPROXIMATELY 34,996 SUBJECT VEHICLES BUILT BETWEEN OCTOBER 13, 2003 AND MARCH 8, 2004.THIS PERIOD OF VEHICLE PRODUCTION IS ASSOCIATED WITH ESCALATED WARRANTY CLAIMS RATES AND COMPLAINTS THAT ALLEGE ENGINE STALL DUE TO IGNITION RELAY FAILURE.GM HAS IDENTIFIED PARTS SUPPLIERS WHO USED MATERIALS CONTAINING SILICONE IN THE MANUFACTURE OF SPECIFIC COMPONENTS FOR THE IGNITION RELAY MODULE.SILICONE CONTAMINATION CAN RESULT IN SILICA DEPOSITS FORMING ON THE CONTACTS AS THE RELAY SWITCHES AND THE HEAT GENERATED BY THE RESULTANT ARC CONVERTS THE SILICONE TO SILICA.SILICA BUILD-UP ON THE CONTACTS IS PROGRESSIVE AND MAY PRODUCE A VOLTAGE DROP ACROSS THE RELAY SUFFICIENT TO CAUSE AN INTERMITTENT NO-START OR ENGINE STALL CONDITION.WARRANTY ANALYSIS INDICATES THE INCIDENCE OF NO/HARD START VERSUS ENGINE STALL TO BE EQUAL.ANALYSIS OF TOWING CLAIMS AND DETAILED SERVICE RECORDS INDICATES THAT VEHICLES MAY EXPERIENCE RESTART DIFFICULTIES AFTER A STALLING INCIDENT APPROXIMATELY 20-30 PERCENT OF THE TIME.THE USE OF SILICONE MATERIALS IN THE MANUFACTURE OF THE SUBJECT IGNITION RELAY HAS BEEN DISCONTINUED.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
2004 Buick Rendezvous Problems, Complaints & Recalls | Skip That Year
Illustration