NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
76 reportsClear category filter115,000 miles · Apr 25, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT WAS ALSO INFORMED THAT HER VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 05V157000 (ELECTRICAL SYSTEM). THE VEHICLE…
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT WAS ALSO INFORMED THAT HER VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 05V157000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 115,000.
NHTSA ODI #10584957
132,000 miles · Apr 18, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE CONTACT ALSO MENTIONED THAT THE FAILURE OCCURRED INTERMITTENTLY AND THAT THE INSTRUMENT PANEL FAILED. THE CONTACT ALSO HAD TO REPLACE THE BATTERY TWICE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHAN…
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE CONTACT ALSO MENTIONED THAT THE FAILURE OCCURRED INTERMITTENTLY AND THAT THE INSTRUMENT PANEL FAILED. THE CONTACT ALSO HAD TO REPLACE THE BATTERY TWICE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE IGNITION RELAY AND FUSE BOX NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED UNDER NHTSA CAMPAIGN NUMBER 05V157000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 132,000.
NHTSA ODI #10583537
96,000 miles · Jan 15, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE ANTI-LOCK BRAKING SYSTEM, HEATING SYSTEM AND THE ALL-WHEEL DRIVE DISABLE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE VEHICLE WAS ABLE TO BE RES…
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE ANTI-LOCK BRAKING SYSTEM, HEATING SYSTEM AND THE ALL-WHEEL DRIVE DISABLE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT ALSO STATED THAT WHEN REFUELING, THE FUEL INDICATOR GAGE WOULD REMAIN ON AN EMPTY READING. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSIS OR REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
NHTSA ODI #10560072
65,000 miles · Dec 10, 2013
Electrical SystemFire
ELECTRICAL FIRE STARTED CAUSING VEHICLE TO BE TOTALLED. *TR
NHTSA ODI #10555484
99,000 miles · Oct 24, 2012
Electrical System
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT THE VEHICLE WOULD STALL SPORADICALLY AND WITHOUT WARNING. OFTEN TIMES, THE VEHICLE WOULD BE RESISTANT TO RESTARTING. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V157000 (ELECTRICAL SYSTEM: IGNITION) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT THE VEHICLE WOULD STALL SPORADICALLY AND WITHOUT WARNING. OFTEN TIMES, THE VEHICLE WOULD BE RESISTANT TO RESTARTING. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V157000 (ELECTRICAL SYSTEM: IGNITION) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED. THE FAILURE AND THE CURRENT MILEAGES WERE 99,000.
NHTSA ODI #10482118
56,000 miles · Jan 24, 2012
Electrical SystemFuel System, Gasoline
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT THE INSTRUMENT PANEL GAUGES FAILED. IN ADDITION, THERE WAS A STRONG ODOR OF FUEL EMITTING FROM INSIDE THE VEHICLE. THE DEALER DIAGNOSED THAT A FUEL LINE WAS RUSTED BUT HE WAS UNABLE TO DIAGNOSE THE CAUSE OF FAILURE FOR THE INSTRUMENT GAUGES. THE MANUFACTURE…
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT THE INSTRUMENT PANEL GAUGES FAILED. IN ADDITION, THERE WAS A STRONG ODOR OF FUEL EMITTING FROM INSIDE THE VEHICLE. THE DEALER DIAGNOSED THAT A FUEL LINE WAS RUSTED BUT HE WAS UNABLE TO DIAGNOSE THE CAUSE OF FAILURE FOR THE INSTRUMENT GAUGES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 56,000 AND THE CURRENT MILEAGE WAS 70,000.
NHTSA ODI #10445060
102,000 miles · Dec 30, 2011
Electrical System
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH, THE ENGINE STALLED WITHOUT PRIOR WARNING. THE VEHICLE WAS COASTED TO A SAFE LOCATION AND THE ENGINE WAS TURNED OFF. AFTER WAITING A FEW MOMENTS, THE ENGINE RESTARTED. THE CONTACT WAS ABLE TO RESUME DRIVING. THERE WAS A RECALL RELAT…
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH, THE ENGINE STALLED WITHOUT PRIOR WARNING. THE VEHICLE WAS COASTED TO A SAFE LOCATION AND THE ENGINE WAS TURNED OFF. AFTER WAITING A FEW MOMENTS, THE ENGINE RESTARTED. THE CONTACT WAS ABLE TO RESUME DRIVING. THERE WAS A RECALL RELATED TO THE SIMILAR DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 05V157000 (ELECTRICAL SYSTEM: IGNITION). THE MANUFACTURER WAS NOTIFIED OF THE MALFUNCTION. THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.
NHTSA ODI #10441789
68,000 miles · Feb 25, 2011
Electrical System
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT WAS TRAVELING 60 MPH WHEN THE SPEEDOMETER DISPLAYED THAT HE WAS TRAVELING 1 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE CLUSTER BOARD WOULD NEED REPLACING. THE MANUFACTURER WAS CONTACTED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE…
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT WAS TRAVELING 60 MPH WHEN THE SPEEDOMETER DISPLAYED THAT HE WAS TRAVELING 1 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE CLUSTER BOARD WOULD NEED REPLACING. THE MANUFACTURER WAS CONTACTED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE WAS 100,000.
NHTSA ODI #10384499
100,000 miles · Jan 18, 2011
Electrical System
SPEEDOMETER ON MY 2004 BUICK RENDEZVOUS CXL SUV HAS NOT BEEN WORKING PROPERLY FOR THE LAST 6 MONTHS. SOME DAYS IT WILL BE ALOT LOWER THAN ACTUAL SPEED OF THE VEHICLE AND OTHER DAYS IT WILL BE ALOT HIGHER, LIKE SHOWING 110 MPH WHILE I'M ACTUALLY DRIVING 45 MPH. SOME DAYS IT DOES NOT REGISTER ANYTHING OTHER THAN 0 MPH. *TR
NHTSA ODI #10377059
89,000 miles · Nov 22, 2010
Electrical System
TL*THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE SPEEDOMETER DISPLAYED AN INCORRECT SPEED; IT WOULD INDICATE THAT THE VEHICLE WAS TRAVELING FASTER THAN IT ACTUALLY WAS. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000. UPDA…
Read full complaint
TL*THE CONTACT OWNS A 2004 BUICK RENDEZVOUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE SPEEDOMETER DISPLAYED AN INCORRECT SPEED; IT WOULD INDICATE THAT THE VEHICLE WAS TRAVELING FASTER THAN IT ACTUALLY WAS. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000. UPDATED 3/11/11 *CN THE CONSUMER STATED THE SPEEDOMETER REGISTERS AT 100- 105 MPH WHEN SHE WAS ACTUALLY DRIVING 45 MPH. UPDATED 03/16/11
NHTSA ODI #10367192
Official recalls
4Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
Apr 20, 2005
ON CERTAIN SPORT UTILITY VEHICLES, CONTAMINATION ON IGNITION RELAY CONTACTS CAN CAUSE HIGH RESISTANCE. THIS CAN AFFECT SIGNALS TO THE POWERTRAIN CONTROL MODULE AND, COULD CAUSE INTERMITTENT VEHICLE STALLS AT ANY TIME.
Consequence & remedy
Consequence: THE VEHICLE CANNOT BE RESTARTED IMMEDIATELY. IF THIS WERE TO OCCUR, IT COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION RELAY FREE OF CHARGE. THE RECALL BEGAN ON MAY 4, 2005. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND BUICK AT 1-866-608-8080.
Mar 29, 2004
ON CERTAIN SPORT UTILITY VEHICLES, A STRUCTURAL SUPPORT AT THE LATCH ATTACHMENT IN THE REAR LIFTGATE MAY BE INADEQUATE TO RETAIN THE LATCH TO THE LIFTGATE IN CERTAIN SEVERE VEHICLE CRASH EVENTS.
Consequence & remedy
Consequence: IF THE LIFTGATE WERE TO OPEN IN A VEHICLE CRASH, AN OCCUPANT COULD BE EJECTED FROM THE VEHICLE RESULTING IN INCREASED RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL ADD STRUCTURAL REINFORCEMENTS TO THE LIFTGATE IN THE AREA ADJOINING THE LATCH ASSEMBLY. OWNER NOTIFICATION SCHEDULE BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080. THIS IS AN EXPANSION TO A PREVIOUS RECALL (03V211).
Nov 10, 2003
ON CERTAIN PASSENGER VEHICLES, A WELD BETWEEN THE FUEL TANK INLET CHECK VALVE AND THE FUEL TANK CAN FAIL.
Consequence & remedy
Consequence: IF THESE PARTS SEPARATE, THE DRIVER MAY NOTICE AN ODOR OF FUEL, THE SERVICE ENGINE SOON OR CHECK ENGINE LIGHT MAY ILLUMINATE, AND/OR FUEL MAY LEAK ONTO THE GROUND. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE SERIAL NUMBER OF THE FUEL TANK TO SEE IF IT IS ON THE LIST OF AFFECTED TANKS. IF THE SERIAL NUMBER MATCHES, THE FUEL TANK WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07006 · Fuel Tank Leakage
Opened Apr 18, 2007 · Closed Sep 13, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (5)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
RQ06009 · Fuel Tank Leakage
Opened Dec 14, 2006 · Closed Apr 18, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Additional source detail variants (4)
Fuel System, Gasoline
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
PE04075 · Ignition Relay Failure
Opened Nov 10, 2004 · Closed Apr 28, 2005
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:module
ON NOVEMBER 10, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE THE FAILURE, MALFUNCTION, OR OTHER UNSATISFACTORY PERFORMANCE OF THE ENGINE CONTROL SYSTEM WHICH MAY RESULT IN ENGINE STALLING IN CERTAIN MODEL YEAR (MY) 2004 BUICK RENDEZVOUS (GMT250) AND PONTIAC AZTEK (GMT250) VEHICLES ALLEGEDLY CAUSED BY IGNITION RELAY FAILURE.ODI IS AWARE OF 68 NON-DUPLICATIVE COMPLAINTS AND 1092 WARRANTY CLAIMS RELATED TO THE SUBJECT ISSUE.THERE ARE NO KNOWN CRASHES RELATED TO IGNITION RELAY FAILURE ON THE SUBJECT VEHICLES.BY LETTER DATED APRIL 19, 2005, GENERAL MOTORS CORP. (GM) HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-157) TO REPLACE DEFECTIVE IGNITION RELAY MODULES IN APPROXIMATELY 34,996 SUBJECT VEHICLES BUILT BETWEEN OCTOBER 13, 2003 AND MARCH 8, 2004.THIS PERIOD OF VEHICLE PRODUCTION IS ASSOCIATED WITH ESCALATED WARRANTY CLAIMS RATES AND COMPLAINTS THAT ALLEGE ENGINE STALL DUE TO IGNITION RELAY FAILURE.GM HAS IDENTIFIED PARTS SUPPLIERS WHO USED MATERIALS CONTAINING SILICONE IN THE MANUFACTURE OF SPECIFIC COMPONENTS FOR THE IGNITION RELAY MODULE.SILICONE CONTAMINATION CAN RESULT IN SILICA DEPOSITS FORMING ON THE CONTACTS AS THE RELAY SWITCHES AND THE HEAT GENERATED BY THE RESULTANT ARC CONVERTS THE SILICONE TO SILICA.SILICA BUILD-UP ON THE CONTACTS IS PROGRESSIVE AND MAY PRODUCE A VOLTAGE DROP ACROSS THE RELAY SUFFICIENT TO CAUSE AN INTERMITTENT NO-START OR ENGINE STALL CONDITION.WARRANTY ANALYSIS INDICATES THE INCIDENCE OF NO/HARD START VERSUS ENGINE STALL TO BE EQUAL.ANALYSIS OF TOWING CLAIMS AND DETAILED SERVICE RECORDS INDICATES THAT VEHICLES MAY EXPERIENCE RESTART DIFFICULTIES AFTER A STALLING INCIDENT APPROXIMATELY 20-30 PERCENT OF THE TIME.THE USE OF SILICONE MATERIALS IN THE MANUFACTURE OF THE SUBJECT IGNITION RELAY HAS BEEN DISCONTINUED.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:ignition
ON NOVEMBER 10, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE THE FAILURE, MALFUNCTION, OR OTHER UNSATISFACTORY PERFORMANCE OF THE ENGINE CONTROL SYSTEM WHICH MAY RESULT IN ENGINE STALLING IN CERTAIN MODEL YEAR (MY) 2004 BUICK RENDEZVOUS (GMT250) AND PONTIAC AZTEK (GMT250) VEHICLES ALLEGEDLY CAUSED BY IGNITION RELAY FAILURE.ODI IS AWARE OF 68 NON-DUPLICATIVE COMPLAINTS AND 1092 WARRANTY CLAIMS RELATED TO THE SUBJECT ISSUE.THERE ARE NO KNOWN CRASHES RELATED TO IGNITION RELAY FAILURE ON THE SUBJECT VEHICLES.BY LETTER DATED APRIL 19, 2005, GENERAL MOTORS CORP. (GM) HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-157) TO REPLACE DEFECTIVE IGNITION RELAY MODULES IN APPROXIMATELY 34,996 SUBJECT VEHICLES BUILT BETWEEN OCTOBER 13, 2003 AND MARCH 8, 2004.THIS PERIOD OF VEHICLE PRODUCTION IS ASSOCIATED WITH ESCALATED WARRANTY CLAIMS RATES AND COMPLAINTS THAT ALLEGE ENGINE STALL DUE TO IGNITION RELAY FAILURE.GM HAS IDENTIFIED PARTS SUPPLIERS WHO USED MATERIALS CONTAINING SILICONE IN THE MANUFACTURE OF SPECIFIC COMPONENTS FOR THE IGNITION RELAY MODULE.SILICONE CONTAMINATION CAN RESULT IN SILICA DEPOSITS FORMING ON THE CONTACTS AS THE RELAY SWITCHES AND THE HEAT GENERATED BY THE RESULTANT ARC CONVERTS THE SILICONE TO SILICA.SILICA BUILD-UP ON THE CONTACTS IS PROGRESSIVE AND MAY PRODUCE A VOLTAGE DROP ACROSS THE RELAY SUFFICIENT TO CAUSE AN INTERMITTENT NO-START OR ENGINE STALL CONDITION.WARRANTY ANALYSIS INDICATES THE INCIDENCE OF NO/HARD START VERSUS ENGINE STALL TO BE EQUAL.ANALYSIS OF TOWING CLAIMS AND DETAILED SERVICE RECORDS INDICATES THAT VEHICLES MAY EXPERIENCE RESTART DIFFICULTIES AFTER A STALLING INCIDENT APPROXIMATELY 20-30 PERCENT OF THE TIME.THE USE OF SILICONE MATERIALS IN THE MANUFACTURE OF THE SUBJECT IGNITION RELAY HAS BEEN DISCONTINUED.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:ignition:module
ON NOVEMBER 10, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE THE FAILURE, MALFUNCTION, OR OTHER UNSATISFACTORY PERFORMANCE OF THE ENGINE CONTROL SYSTEM WHICH MAY RESULT IN ENGINE STALLING IN CERTAIN MODEL YEAR (MY) 2004 BUICK RENDEZVOUS (GMT250) AND PONTIAC AZTEK (GMT250) VEHICLES ALLEGEDLY CAUSED BY IGNITION RELAY FAILURE.ODI IS AWARE OF 68 NON-DUPLICATIVE COMPLAINTS AND 1092 WARRANTY CLAIMS RELATED TO THE SUBJECT ISSUE.THERE ARE NO KNOWN CRASHES RELATED TO IGNITION RELAY FAILURE ON THE SUBJECT VEHICLES.BY LETTER DATED APRIL 19, 2005, GENERAL MOTORS CORP. (GM) HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-157) TO REPLACE DEFECTIVE IGNITION RELAY MODULES IN APPROXIMATELY 34,996 SUBJECT VEHICLES BUILT BETWEEN OCTOBER 13, 2003 AND MARCH 8, 2004.THIS PERIOD OF VEHICLE PRODUCTION IS ASSOCIATED WITH ESCALATED WARRANTY CLAIMS RATES AND COMPLAINTS THAT ALLEGE ENGINE STALL DUE TO IGNITION RELAY FAILURE.GM HAS IDENTIFIED PARTS SUPPLIERS WHO USED MATERIALS CONTAINING SILICONE IN THE MANUFACTURE OF SPECIFIC COMPONENTS FOR THE IGNITION RELAY MODULE.SILICONE CONTAMINATION CAN RESULT IN SILICA DEPOSITS FORMING ON THE CONTACTS AS THE RELAY SWITCHES AND THE HEAT GENERATED BY THE RESULTANT ARC CONVERTS THE SILICONE TO SILICA.SILICA BUILD-UP ON THE CONTACTS IS PROGRESSIVE AND MAY PRODUCE A VOLTAGE DROP ACROSS THE RELAY SUFFICIENT TO CAUSE AN INTERMITTENT NO-START OR ENGINE STALL CONDITION.WARRANTY ANALYSIS INDICATES THE INCIDENCE OF NO/HARD START VERSUS ENGINE STALL TO BE EQUAL.ANALYSIS OF TOWING CLAIMS AND DETAILED SERVICE RECORDS INDICATES THAT VEHICLES MAY EXPERIENCE RESTART DIFFICULTIES AFTER A STALLING INCIDENT APPROXIMATELY 20-30 PERCENT OF THE TIME.THE USE OF SILICONE MATERIALS IN THE MANUFACTURE OF THE SUBJECT IGNITION RELAY HAS BEEN DISCONTINUED.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration