2020 Buick Enclave

Front exhaust pipe separated from its mounting bracket causing a consistent rattle. This condition is exactly as described in "N222385510 - Special Coverage Front Exhaust Pipe", released in May 2023. Exhaust components in this vehicle are materially the same as the covered 2021 vehicles and thus this vehicle should be similarly covered. Issue has been confirmed by a dealer and is available for further inspection.

I am submitting a complaint regarding premature exhaust system failure on my 2020 Buick Enclave involving the front exhaust pipe/exhaust manifold/catalytic converter assembly. The issue appears very similar to the conditions described in GM Special Coverage programs N212356540 and N242445280 involving exhaust pipe and bracket failures on related GM crossover platforms. The mounting brackets/support brackets on the front exhaust pipe appear to fail or separate, which places excessive stress on the flex section of the exhaust system. This movement and stress can cause the flex pipe/manifold area to crack and may ultimately damage the catalytic converter assembly itself. My vehicle developed: Exhaust leak Loud ticking/exhaust noise Rich/lean oxygen sensor fault conditions Exhaust fumes entering or potentially entering the cabin Passenger dizziness while riding in the vehicle Concern for carbon monoxide exposure The repair facility documented that the exhaust leak should be repaired as soon as possible because exhaust fumes may enter the vehicle cabin. The estimated repair cost is approximately $1,700 for replacement of the integrated catalytic converter/exhaust manifold assembly. This appears to be more than ordinary wear and tear. The failure pattern is consistent with bracket/support failure causing abnormal stress and cracking in the exhaust system upstream near emissions components. Because these failures can allow exhaust gases and possible carbon monoxide exposure into the passenger compartment, I believe this issue represents a significant safety concern and warrants investigation for 2020 Buick Enclave vehicles and related GM crossover platforms.

Why enclave Burns about 1 to 2 quarts of oil in between oil changes so I'm constantly having to check the oil level and put more oil in it which come really close to being out of oil and causing the engine to seize Buick says this is normal and I don't think it is I have never had a car that uses oil like this new or used in addition to that the transmission is locked up twice since we have owned it and can't get it out of park can't drive it can't use it. Had to have it towed . The first time that the transmission gave issues it didn't lock up in park it locked up in drive and we couldn't put it in park I was able to get it to the dealer to get worked on it was still under warranty at that time the second time it wouldn't go out of park and could not move it it was stuck wherever we happen to be at and it would not move when they loaded it on the tow truck to tow it down to the dealer the wheels were locked up cuz it was in park and we couldn't it had to just be drug onto the truck.

I am submitting this formal complaint regarding serious mechanical and safety issues with my 2020 Buick Enclave. These issues have created ongoing financial hardship, significant safety concerns, and an urgent need for investigation and resolution. Over the past several months, my vehicle has repeatedly displayed low‑oil notifications, sometimes occurring within one month of receiving a full oil change. During a recent visit to my mechanic for yet another low‑oil alert, he recalled that I had previously brought the vehicle in for the same issue. After conducting a more thorough inspection, he informed me that there was a failure within the engine/transmission assembly. He showed me the area where oil was seeping from the engine. I also inspected the oil filter and oil plug, both of which showed no signs of leakage. Following this diagnosis, I brought the vehicle to Royal Buick GMC. Their service department performed a SAVI Dongle test and a GM‑Certified Multi‑Point Inspection. The service technician informed me that the vehicle requires a complete engine replacement including the following: replacement of the engine, repair of a rear main seal failure, resealing of the oil pan, and replacement of the lower control arm. It is my belief that these issues are consistent with reported problems. In addition to the oil‑related failures, I have experienced sudden acceleration and jerking while driving. These incidents are alarming and pose a serious risk to my safety and the safety of others on the road. I am deeply concerned that this defect could lead to an accident through no fault of my own. This vehicle is my only means of transportation for work and for caring for my family. The cost and severity of the required repairs are catastrophic, and I believe the manufacturer should be held responsible for addressing these defects. I respectfully request that the NHTSA investigate these issues and assist in ensuring that GM/Buick replaces the engine for its safe operation.

The vehicle developed an exhaust leak caused by both weld points on the front exhaust pipe breaking. A dealership inspected the vehicle and confirmed that the exhaust welds had failed, creating a hole in the exhaust pipe and triggering a P0420 catalyst efficiency code. The failure occurred at approximately 31,500 miles. The exhaust leak caused increased exhaust noise and emissions warning codes. The dealership recommended replacement of the front exhaust pipe assembly. This appears similar to known failures on the Buick Enclave and Chevrolet Traverse platform where the front exhaust pipe mounting bracket separates from the pipe due to weld failure. GM has issued special coverage adjustments for similar exhaust pipe bracket weld failures on other model years of these vehicles. The failure occurred at relatively low mileage and appears to be a structural weld defect in the exhaust system.

Dear NHTSA Safety Team, I am submitting a formal safety complaint regarding my 2020 Buick Enclave (VIN: [XXX] ). My vehicle has experienced repeated engine shutdowns while driving, creating a serious safety hazard. Vehicle & Incident Details: * Make/Model/Year: 2020 Buick Enclave * VIN: [XXX] * Mileage: ~116,834 miles (purchased at ~62,000 miles, used) * Purchase Date: [Insert Month/Year] * Dealer: Kyle Durrence Claxton Dealership Repair History: * First repair attempt: TPMS system * Second repair attempt: Connector assembly block * Total out-of-pocket spent: $4,000+ * Despite these repairs, the vehicle continues to shut off unexpectedly while driving. Safety Impact: * Engine shuts off while the vehicle is in motion, creating a risk of collision. * Vehicle is my only mode of transportation. * Dealership has not provided a loaner vehicle. Additional Concerns: * I have discovered forged signatures on my original finance/loan paperwork from the dealership, which I previously reported to the dealership General Manager without response. Requested Action: I request that NHTSA record this safety issue, investigate the repeated engine shutdowns, and consider whether this defect warrants a recall or further manufacturer action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I came to a stop in the left turn lane at an intersection with a red light with the car in drive and my foot engaged on the brake to wait for the light to turn green. The car suddenly and completely died and all power was shut down. I was not able to engage the hazards. It was dark outside and I was afraid cars behind me would hit me. It was an incredibly dangerous situation with no warning. I exited the vehicle and got to the side of the road. The police arrived and were able to push the car to the side of the road as well. I opened the hood and checked the negative battery terminal and upon pulling the lever, the power came back on. We have an appointment at a GM dealership on Monday to fix the issue to ensure we are not put at risk again.

The front exhaust pipe bracket has broken. Upon investigation, this is an ongoing issue for 2018-2019, and 2021-2023 Chevy Traverse and Buick Enclave models, but NOT 2020. All of the models use the exhaust system and same bracket, and it should be included as a special coverage. In fact, the attached picture of my vehicle will show that it is an identical break to those pictures used in the previous bulletins. Any help is appreciated. Reference: N252503850, N242445280, N222385510, N212356540, and photo attached.