Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
930–25K
10725–50K
9050–75K
4075–100K
22100–150K
3150K+
355 reports with mileage · 59 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 342 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports0 fire reports1 injury reports
What owners actually said
414 reports
9,800 miles · Jun 13, 2012
Steering
TL* THE CONTACT OWNS A 2003 BMW Z4. THE CONTACT STATED WHILE DRIVING 45 MPH SHE COULD FEEL THE STEERING WHEEL JERKING AND IT BECAME HARD TO CONTROL. SHE ALSO STATED IT FELT LIKE THE STEERING WHEEL EXHIBIT EXCESSIVE RESISTANCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF TH…
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW Z4. THE CONTACT STATED WHILE DRIVING 45 MPH SHE COULD FEEL THE STEERING WHEEL JERKING AND IT BECAME HARD TO CONTROL. SHE ALSO STATED IT FELT LIKE THE STEERING WHEEL EXHIBIT EXCESSIVE RESISTANCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 9,800 THE CURRENT MILEAGE IS 12,200 UPDATED 07/13/12*LJ BMW AGREED TO REPLACE THE STEERING COLUMN FREE OF CHARGE. UPDATED 07/18/12
NHTSA ODI #10461627
39,000 miles · Jun 9, 2012
Steering
OVER THE COURSE OF THE LAST YEAR, THE STEERING IN MY BMW Z-4 HAS FELT LIKE I HAVE TO FIGHT TO STAY ON THE ROAD. IT IS JERKING & PULLING THE CAR OFF CENTER MAKING IT VERY DIFFICULT TO DRIVE AND FEEL SAFE. THE STEERING WHEEL ALSO "STICKS" RATHER THAN ROTATING SMOOTHLY WHEN I TURN TO THE LEFT OR RIGHT. THIS CONDITION IS PROGRESS…
Read full complaint
OVER THE COURSE OF THE LAST YEAR, THE STEERING IN MY BMW Z-4 HAS FELT LIKE I HAVE TO FIGHT TO STAY ON THE ROAD. IT IS JERKING & PULLING THE CAR OFF CENTER MAKING IT VERY DIFFICULT TO DRIVE AND FEEL SAFE. THE STEERING WHEEL ALSO "STICKS" RATHER THAN ROTATING SMOOTHLY WHEN I TURN TO THE LEFT OR RIGHT. THIS CONDITION IS PROGRESSIVELY GETTING WORSE, I WAS DRIVING ON THE INTERSTATE LAST WEEK AT APPROX. 55 MILES/HOUR AND SEVERAL TIMES THE CAR SWERVED HARD PULLING ME INTO THE NEXT LANE OF TRAFFIC COMING VERY CLOSE TO CAUSING AN ACCIDENT. *JS
NHTSA ODI #10461102
40,000 miles · Jun 5, 2012
Steering
THE STEERING STICKS AND IS HARD TO CONTROL. THE STEERING SEEMS TO HAVE LOBES/STICKING POINTS IN THE STEERING AND STICKS AT CERTAIN POINTS AND THEN LETS GO MAKING IT HARD TO CONTROL. THE VEHICLE IS VERY HARD TO STEER AND HAS JERKY CATCHING POINTS AS YOU MOVE THE WHEEL WHILE GOING DOWN THE ROAD. *TR
NHTSA ODI #10460729
20,000 miles · May 25, 2012
Steering
I HAVE NOTICED THAT WHEN THE OUTSIDE TEMPERATURE IS OVER 90 DEGREES MY STEERING STICKS AND YOU HAVE TO JERK THE WHEEL TO GET IT TO UNSTICK. IT ESPECIALLY NOTICEABLE WHEN YOU ARE TAKING A GRADUAL CURVE AND YOU TRY TO STRAIGHTEN OUT THE CAR. I HAVE BEEN TOLD IT IS LIKELY THE ELECTRONIC POWER STEERING BUT HAVE NOT HAD IT CHECKED. I…
Read full complaint
I HAVE NOTICED THAT WHEN THE OUTSIDE TEMPERATURE IS OVER 90 DEGREES MY STEERING STICKS AND YOU HAVE TO JERK THE WHEEL TO GET IT TO UNSTICK. IT ESPECIALLY NOTICEABLE WHEN YOU ARE TAKING A GRADUAL CURVE AND YOU TRY TO STRAIGHTEN OUT THE CAR. I HAVE BEEN TOLD IT IS LIKELY THE ELECTRONIC POWER STEERING BUT HAVE NOT HAD IT CHECKED. IT IS SO DANGEROUS THAT I WILL NOT DRIVE IN HOT WEATHER UNTIL I GET IT FIXED... I JUST CAN'T AFFORD SEVERAL THOUSAND IN REPAIR BILLS. BTW, THERE ARE ONLY 23,000 MILES ON THE CAR AND I HAVE HAD IT SINCE IT WAS NEW. *TR
NHTSA ODI #10459704
33,000 miles · May 8, 2012
Steering
TL* THE CONTACT OWNS A 2003 BMW Z4. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT NOTICED THAT THE STEERING WHEEL BEGAN TO STICK AND JERK TO THE SIDES ON ITS OWN. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC TEST. THERE WAS AN INVESTIGATION UNDER NHTSA ACTION NUMBER: PE10020 (STEERING:COLUMN STEERING:ELECTRIC POWER…
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW Z4. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT NOTICED THAT THE STEERING WHEEL BEGAN TO STICK AND JERK TO THE SIDES ON ITS OWN. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC TEST. THERE WAS AN INVESTIGATION UNDER NHTSA ACTION NUMBER: PE10020 (STEERING:COLUMN STEERING:ELECTRIC POWER ASSIST SYSTEM) THAT MAY BE RELATED TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.
NHTSA ODI #10457788
74,100 miles · Apr 28, 2012
SteeringCrash
ON THIS PARTICULAR OCCASION, THE ELECTRIC STEERING BINDS OR GETS STUCK WHILE IN CENTER POSITION AND MAKES IT DIFFICULT OR IMPAIRS THE ABILITY TO CHANGE LANES ON THE HIGHWAY. ON THIS OCCASION, I WAS TRAVLING AT A RELATIVELY LOW SPEED AND WAS CHANGING LANES AND BECAUSE OF THE STEERING PROBLEM I JERKED THE VEHICLE AND HIT A CAR IN…
Read full complaint
ON THIS PARTICULAR OCCASION, THE ELECTRIC STEERING BINDS OR GETS STUCK WHILE IN CENTER POSITION AND MAKES IT DIFFICULT OR IMPAIRS THE ABILITY TO CHANGE LANES ON THE HIGHWAY. ON THIS OCCASION, I WAS TRAVLING AT A RELATIVELY LOW SPEED AND WAS CHANGING LANES AND BECAUSE OF THE STEERING PROBLEM I JERKED THE VEHICLE AND HIT A CAR IN THE OTHER LANE CAUSING MINOR DAMAGE TO MY VEHICLE. THIS PROBLEM COMES AND GOES AND GETS WORST IN THE WARM TO HOT WEATHER. I HAVE CONTACTED BMW IN BOTH MASSACHUSETTS AND FLORIDA WITH NO HELP FROM DEALERS. MY VEHICLE HAS 79,000 ON IT NOW WHICH ISNT A LOT OF MILES FOR A 2003. *TR
NHTSA ODI #10456752
71,132 miles · Apr 19, 2012
Steering
THE STEERING WHEEL WILL STICK TO THE RIGHT AND LEFT IN WARM WEATHER. IT CAUSES THE HANDLING OF THE VEHICLE TO BE VERY DIFFICULT. *JS
NHTSA ODI #10455827
85,000 miles · Apr 18, 2012
Steering
BOUGHT THIS CAR IN JUNE 2011 WITH APPROXIMATELY 86000, SO IT IS VERY POSSIBLE THE PROBLEM HAD SHOWN UP PRIOR TO THIS DATE/MILEAGE. DURING VERY HOT DAYS, THE STEERING "STICKS" AND IS DIFFICULT TO START MOVEMENT, RESULTING IN JERKINESS AND SWERVING ON THE ROAD. ONCE MOTION ON THE STEERING WHEEL IS INITIATED, IT IS POSSIBLE TO CONT…
Read full complaint
BOUGHT THIS CAR IN JUNE 2011 WITH APPROXIMATELY 86000, SO IT IS VERY POSSIBLE THE PROBLEM HAD SHOWN UP PRIOR TO THIS DATE/MILEAGE. DURING VERY HOT DAYS, THE STEERING "STICKS" AND IS DIFFICULT TO START MOVEMENT, RESULTING IN JERKINESS AND SWERVING ON THE ROAD. ONCE MOTION ON THE STEERING WHEEL IS INITIATED, IT IS POSSIBLE TO CONTINUE MOVEMENT SMOOTHLY. BUT WHEN YOU STOP MOVEMENT, IT WILL STICK AGAIN. THIS MAKES IT VERY TEDIOUS AND ANNOYING AND POSSIBLY EVEN UNSAFE TO MAKE EVEN JUST THE NORMAL CONSTANT MINOR ADJUSTMENTS WHILE DRIVING STRAIGHT. OFTEN TIMES, JUMPING FROM ONE SIDE OF MY LANE TO THE OTHER, AND BACK. *JS
NHTSA ODI #10455605
74,000 miles · Apr 6, 2012
Steering
TL* THE CONTACT OWNS A 2003 BMW Z4. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL WOULD SEIZE ABNORMALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 74,000.
NHTSA ODI #10454387
52,000 miles · Apr 5, 2012
Steering
DPS FAILURE. LIGHT STAYS ON AND STEERING IS IMPOSSIBLE. DEALER SAID 3,000.00 TO REPLACE STEERING COLUMN. *TR
ON CERTAIN PASSENGER VEHICLES, INCOMPATIBLE ELECTRONIC AIR BAG SYSTEM PROCESSORS MAY HAVE BEEN INSTALLED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, AIR BAG DEPLOYMENT MAY NOT OCCUR, INCREASING THE RISK OF INJURIES TO THE DRIVER AND/OR FRONT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE AIR BAG SYSTEM PROCESSORS. THE RECALL BEGAN JUNE 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES, UNDER CERTAIN ENVIRONMENTAL CONDITIONS, A VAPOR LOCK IN THE FUEL PUMP COULD OCCUR CAUSING THE ENGINE TO STALL. IF THIS WERE TO HAPPEN, THE ENGINE WOULD NOT BE ABLE TO BE RESTARTED FOR APPROXIMATELY 15 TO 20 MINUTES.
Consequence & remedy
Consequence: IF STALLING WERE TO OCCUR, THE DRIVER WOULD BE UNABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A RESISTOR IN THE ELECTRICAL LINE POWERING THE FUEL PUMP IN ORDER TO PREVENT AN OCCURRENCE OF VAPOR LOCK. THE RECALL BEGAN MAY 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN VEHICLES EQUIPPED WITH 18" TIRES, IT IS POSSIBLE THAT THE TIRE HAS BEEN DAMAGED DURING THE MOUNTING PROCESS TO THE RIM.
Consequence & remedy
Consequence: CONSEQUENTLY, A LOSS OF TIRE PRESSURE, OR A TIRE FAILURE, COULD OCCUR. DEPENDING ON TRAFFIC CONDITIONS AND THE DRIVER'S REACTIONS, THIS COULD LEAD TO A CRASH.
Remedy: DEALERS WILL UNSEAT THE TIRE FROM ITS RIM, INSPECT FOR ANY DAMAGE, AND THEN RESEAT THE TIRE TO ITS RIM. IF INSPECTION REVEALS THAT A FRONT TIRE HAS INCURRED DAMAGE DURING THE MOUNTING PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES, THE CONNECTION OF THE SAFETY BELT BUCKLE TO THE STEEL ROPE OF THE TENSIONER DOES NOT MEET BMW SPECIFICATIONS. IN SEVERE FRONTAL CRASHES, THIS CONNECTION CAN DETACH.
Consequence & remedy
Consequence: IF THE CONNECTION DETACHES, THE PROTECTION PROVIDED BY THE SAFETY BELT IS LIKELY TO BE IMPAIRED, AND SERIOUS INJURIES TO THE DRIVER AND/OR FRONT PASSENGER COULD OCCUR THAT MIGHT OTHERWISE BE MITIGATED.
Remedy: DEALERS WILL INSPECT BOTH FRONT SAFETY BELT TENSIONER AND BUCKLE ASSEMBLIES, AND IF NECESSARY, REPLACE THESE PARTS. OWNER NOTIFICATION BEGAN MARCH 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10020 · Sticky Steering
Opened Jun 28, 2010 · Closed Jun 28, 2011
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Additional source detail variants (3)
Steering
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:column
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
2003 BMW Z4 Problems, Complaints & Recalls | Skip That Year
Illustration