THE POWER STEERING QUIT I LOST THE POWER STEERING AT APPROXIMATELY 40 MPH IT WAS MORE DIFFICULT TO STEER. WHEN IT WAS TAKEN TO THE DEALER I WAS INFORMED THEY HAD BEEN REPLACING THEM FREE OF CHARGE ON A CASE BY CASE BASIS, BUT I WAS OUT OF LUCK BECAUSE I WAS NOT THE ORIGINAL OWNER. THE GIRL I SPOKE WITH SAID SHE WOULD TALK TO HER…
Read full complaint
THE POWER STEERING QUIT I LOST THE POWER STEERING AT APPROXIMATELY 40 MPH IT WAS MORE DIFFICULT TO STEER. WHEN IT WAS TAKEN TO THE DEALER I WAS INFORMED THEY HAD BEEN REPLACING THEM FREE OF CHARGE ON A CASE BY CASE BASIS, BUT I WAS OUT OF LUCK BECAUSE I WAS NOT THE ORIGINAL OWNER. THE GIRL I SPOKE WITH SAID SHE WOULD TALK TO HER SUPERVISOR AND SEE IF THEY COULD HELP. I WAS NEVER CONTACTED BACK. IF MY WIFE HAD BEEN DRIVING THE CAR AT THE TIME THE PUMP FAILED IT DEFINITELY COULD HAVE BEEN A POSSIBLE ACCIDENT. *TR
NHTSA ODI #10683696
43,730 miles · Oct 30, 2011
Air BagsLatches/locks/linkagesSteering
1.VEHICLE UNSAFE TO DRIVE; UNABLE TO MAINTAIN STEERING OR KEEP VEHICLE ON THE ROAD SAFELY. 2.VIBRATIONS WHILE DRIVING VEHICLE 3.MANUAL GEAR BOX; SHIFTING THROUGH GEARS NOT SMOOTH, NOT ENGAGING SMOOTHLY 4.WATER LEAKING INSIDE OF VEHICLE TRUNK AND REAR SEAT AREAS. VEHICLE TRUNK AREA WAS SATURATED WITH WATER AFTER RAINING; FILL…
Read full complaint
1.VEHICLE UNSAFE TO DRIVE; UNABLE TO MAINTAIN STEERING OR KEEP VEHICLE ON THE ROAD SAFELY. 2.VIBRATIONS WHILE DRIVING VEHICLE 3.MANUAL GEAR BOX; SHIFTING THROUGH GEARS NOT SMOOTH, NOT ENGAGING SMOOTHLY 4.WATER LEAKING INSIDE OF VEHICLE TRUNK AND REAR SEAT AREAS. VEHICLE TRUNK AREA WAS SATURATED WITH WATER AFTER RAINING; FILLING WATER OVER THE BATTERY BOX AND CARPETS, SHORTING OUT ELECTRONICS. 5.OUTSIDE OF VEHICLE; PLASTIC COMPONENTS EARLY DETERIORATION; FRONT WINDSHIELD WIPER AREA BLACK PLASTIC COWL AND ANTENNA. INSIDE OF VEHICLE BLACK PLASTIC COVER FOR CONVERTIBLE TOP 6.RAIN SENSOR INOP 7.DOOR LOCKS INOP/INTERMITTENT 8.WINDOWS REGULATORS PLASTIC BROKEN. *TR
NHTSA ODI #10433599
Mileage unknown · Aug 8, 2010
SteeringSuspension
I SOMETIMES NOTICE AFTER MY 2003 BMW Z4 2.5I HAS BEEN PARKED, IT SEEMS AS IF THE TIRES AND STEERING WHEEL ARE MISALIGNED AND THE CAR DRIVES TO ONE SIDE AS IF ONE TIRE WAS FLAT. THIS ONLY HAS HAPPENED AT LOWER SPEEDS SOON AFTER I START DRIVING, AND EVENTUALLY SEEMS TO GO AWAY AFTER THE CAR HAS BEEN DRIVING FOR A COUPLE MINUTES. N…
Read full complaint
I SOMETIMES NOTICE AFTER MY 2003 BMW Z4 2.5I HAS BEEN PARKED, IT SEEMS AS IF THE TIRES AND STEERING WHEEL ARE MISALIGNED AND THE CAR DRIVES TO ONE SIDE AS IF ONE TIRE WAS FLAT. THIS ONLY HAS HAPPENED AT LOWER SPEEDS SOON AFTER I START DRIVING, AND EVENTUALLY SEEMS TO GO AWAY AFTER THE CAR HAS BEEN DRIVING FOR A COUPLE MINUTES. NOTHING HAS BEEN DONE NOW TO REMEDY THE PROBLEM BUT I PLAN ON GIVING BMW A CALL TO SEE WHAT THEY CAN DO FOR ME. THANK YOU FOR YOUR TIME. *TR
NHTSA ODI #10348004
Mileage unknown · Jan 30, 2006
StructureSuspension
THERE IS A POTENTIAL PROBLEM WITH THE FRONT SHOCK TOWER SUPPORTS AND FRONT CHASSIS ASSEMBLY ON THE BMW Z8. IT IS PRONE TO DEFORMATION OF THE SHOCK TOWERS AND FLEXING OF THE FRONT CHASSIS ASSEMBLY, LEADING TO STEERING PROBLEMS AND ALIGNMENT PROBLEMS. THIS PROBLEM HAS BEEN KNOWN BY BMW AG IN GERMANY SINCE AT LEAST NOVEMBER 200…
Read full complaint
THERE IS A POTENTIAL PROBLEM WITH THE FRONT SHOCK TOWER SUPPORTS AND FRONT CHASSIS ASSEMBLY ON THE BMW Z8. IT IS PRONE TO DEFORMATION OF THE SHOCK TOWERS AND FLEXING OF THE FRONT CHASSIS ASSEMBLY, LEADING TO STEERING PROBLEMS AND ALIGNMENT PROBLEMS. THIS PROBLEM HAS BEEN KNOWN BY BMW AG IN GERMANY SINCE AT LEAST NOVEMBER 2005, BUT AS OF TODAY, THERE HAS BEEN NO OFFICIAL RESPONSE FROM BMW AG OR BMW IN THE USA TO THE OWNERS OF THIS VEHICLE. THE PROBLEM IS THAT THE FRAME / CHASSIS OF THE BMW Z8 IS MADE OF ALUMINUM, AND AS SUCH, CAN UNDERGO A GREATER DEGREE OF FATIGUE. FAILURE SHOULD THERE BE A DEFECT IN THE DESIGN, MATERIALS OR BOTH. THIS DEFECT COULD LEAD OR HAS ALREADY LEAD TO THE FRONT STRUT / SHOCK TOWER ASSEMBLY DEFORMING AT ITS ATTACHMENT POINTS, AND WILL OR COULD LEAD TO A FAILURE OF THE ATTACHMENT, CAUSING A SERIOUS OR FATAL ACCIDENT. THUS FAR, BMW HAS NOT RESPONDED TO COMPLAINTS. THIS WAS A LIMITED PRODUCTION LUXURY SPORTS CAR OF WHICH 5,550 WERE PRODUCED AND ABOUT 2,550 WERE SOLD HERE IN THE USA. BASED ON PRELIMINARY DATA FROM OUR ON-LINE CLUB MEMBERSHIP IT APPEARED THAT AT LEAST 1 IN 3 VEHICLES WERE AFFECTED BY THIS DEFECT. WHAT WE DO NOT KNOW IS WHETHER THE VEHICLE IS OR IS NOT SAFE TO DRIVE? BMW IS SILENT AS FAR AS THEIR CUSTOMERS ARE CONSIDERED, AND WE NEED HELP TO INVESTIGATE THIS POTENTIAL SAFETY CONCERN.*AK
ON CERTAIN PASSENGER VEHICLES, INCOMPATIBLE ELECTRONIC AIR BAG SYSTEM PROCESSORS MAY HAVE BEEN INSTALLED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, AIR BAG DEPLOYMENT MAY NOT OCCUR, INCREASING THE RISK OF INJURIES TO THE DRIVER AND/OR FRONT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE AIR BAG SYSTEM PROCESSORS. THE RECALL BEGAN JUNE 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES, UNDER CERTAIN ENVIRONMENTAL CONDITIONS, A VAPOR LOCK IN THE FUEL PUMP COULD OCCUR CAUSING THE ENGINE TO STALL. IF THIS WERE TO HAPPEN, THE ENGINE WOULD NOT BE ABLE TO BE RESTARTED FOR APPROXIMATELY 15 TO 20 MINUTES.
Consequence & remedy
Consequence: IF STALLING WERE TO OCCUR, THE DRIVER WOULD BE UNABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A RESISTOR IN THE ELECTRICAL LINE POWERING THE FUEL PUMP IN ORDER TO PREVENT AN OCCURRENCE OF VAPOR LOCK. THE RECALL BEGAN MAY 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN VEHICLES EQUIPPED WITH 18" TIRES, IT IS POSSIBLE THAT THE TIRE HAS BEEN DAMAGED DURING THE MOUNTING PROCESS TO THE RIM.
Consequence & remedy
Consequence: CONSEQUENTLY, A LOSS OF TIRE PRESSURE, OR A TIRE FAILURE, COULD OCCUR. DEPENDING ON TRAFFIC CONDITIONS AND THE DRIVER'S REACTIONS, THIS COULD LEAD TO A CRASH.
Remedy: DEALERS WILL UNSEAT THE TIRE FROM ITS RIM, INSPECT FOR ANY DAMAGE, AND THEN RESEAT THE TIRE TO ITS RIM. IF INSPECTION REVEALS THAT A FRONT TIRE HAS INCURRED DAMAGE DURING THE MOUNTING PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES, THE CONNECTION OF THE SAFETY BELT BUCKLE TO THE STEEL ROPE OF THE TENSIONER DOES NOT MEET BMW SPECIFICATIONS. IN SEVERE FRONTAL CRASHES, THIS CONNECTION CAN DETACH.
Consequence & remedy
Consequence: IF THE CONNECTION DETACHES, THE PROTECTION PROVIDED BY THE SAFETY BELT IS LIKELY TO BE IMPAIRED, AND SERIOUS INJURIES TO THE DRIVER AND/OR FRONT PASSENGER COULD OCCUR THAT MIGHT OTHERWISE BE MITIGATED.
Remedy: DEALERS WILL INSPECT BOTH FRONT SAFETY BELT TENSIONER AND BUCKLE ASSEMBLIES, AND IF NECESSARY, REPLACE THESE PARTS. OWNER NOTIFICATION BEGAN MARCH 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10020 · Sticky Steering
Opened Jun 28, 2010 · Closed Jun 28, 2011
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Additional source detail variants (3)
Steering
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:column
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
2003 BMW Z4 Problems, Complaints & Recalls | Skip That Year
Illustration