NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
24 reportsClear category filter49,000 miles · Aug 24, 2026
Electrical SystemEngineEngine And Engine Cooling
The contact owns a 2021 BMW X5. The contact stated that the vehicle failed to immediately start. The vehicle started later. The engine and a yellow warning light flashed on the instrument panel. Upon research, the contact located the German Federal Motor Transport Authority (Kraftfahrt-Bundesamt), for KBA Reference Number: 16131…
Read full complaint
The contact owns a 2021 BMW X5. The contact stated that the vehicle failed to immediately start. The vehicle started later. The engine and a yellow warning light flashed on the instrument panel. Upon research, the contact located the German Federal Motor Transport Authority (Kraftfahrt-Bundesamt), for KBA Reference Number: 16131R, which was associated with the starter motor. The contact stated that the failure was associated with NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling) and 25V644000 (Electrical System). The vehicle was taken to an independent mechanic who determined that the failure was associated with the starter motor, which was replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and the contact was informed that there was no recall on the VIN associated with the failure. The failure mileage was approximately 49,000.
NHTSA ODI #11759048
Mileage unknown · Aug 12, 2026
EnginePower TrainSuspension
The front driveshaft universal joint failed causing the drive shaft to bust a hole in the engine and crack the transmission. There was no knocking noise prior to failure. It suddenly failed, disengaged and caused damage. I was told by service manager the u-bolt must have been defective to have failed without warning.
NHTSA ODI #11756576
Mileage unknown · Jun 27, 2026
Engine
I am having issues with the starter motor / battery. I have read extensively about issues with BMW X5 models having recalls during the production period of my vehicle. BMW is trying to charge $3,000 for a new starter and battery. I feel that this is a known and significant issue with BMW X5 vehicles produced during the same peri…
Read full complaint
I am having issues with the starter motor / battery. I have read extensively about issues with BMW X5 models having recalls during the production period of my vehicle. BMW is trying to charge $3,000 for a new starter and battery. I feel that this is a known and significant issue with BMW X5 vehicles produced during the same period as my vehicle and would like for this to be covered under recall.
NHTSA ODI #11746875
Mileage unknown · May 19, 2026
Engine
After the car was.parked in sun for aome time during shopping at Costco, it did not start. We had to use remote starter which worked. However, upon doing some research I found that overheated starter is a known and recalled problem with 2021 X5 and remote start could have caused fire. Dealership also confirmed it to be the s…
Read full complaint
After the car was.parked in sun for aome time during shopping at Costco, it did not start. We had to use remote starter which worked. However, upon doing some research I found that overheated starter is a known and recalled problem with 2021 X5 and remote start could have caused fire. Dealership also confirmed it to be the smae pronlem , but BMW has not listed this vin as recalled. I contacted BMW and they denied that it was same.problem, although mine is also 2021 X5 with smae.overheated starter problem.
NHTSA ODI #11738795
Mileage unknown · May 15, 2026
Electrical SystemEnginePower Train
2021 BMW X5 xDrive45e PHEV, built October 2020 by BMW AG (Germany). In-service Oct 28, 2021. Vehicle intermittently shows "Drivetrain Malfunction — you can continue driving" warning. DME scan reveals 5 fault codes, all for the conventional 12V pinion starter: 21A50A — Pinion starter: timeout occurred several times in succes…
Read full complaint
2021 BMW X5 xDrive45e PHEV, built October 2020 by BMW AG (Germany). In-service Oct 28, 2021. Vehicle intermittently shows "Drivetrain Malfunction — you can continue driving" warning. DME scan reveals 5 fault codes, all for the conventional 12V pinion starter: 21A50A — Pinion starter: timeout occurred several times in succession 21A511 — Pinion starter: timeout 21611A — Pinion starter: starting torque could not be built up; high counter torque and/or undervoltage 216119 — Pinion starter: line break in starter control (KL50/KL30) 216115 — Pinion starter: attempt to start with blocked starter detected 21A50A and 216115 are protected memory codes that cannot be cleared by standard OBD-II tools. The main 12V AGM battery was replaced and registered; codes continue to recur. This signature matches the B58 pinion starter defect addressed in NHTSA Recall 24V-576 (Aug 2024) and 25V644 (Nov 2025, physical starter replacement). The vehicle's German manufacture date falls inside the production windows of KBA recalls 15630R, 15632R, and 15633R — all covering X5 G05 for short-circuit and fire risk from starter relay corrosion or inadequate mounting. BMW AG has issued an ADAC advisory not to leave affected vehicles running unattended after starting. BMW NA Customer Relations was contacted. Initial verbal response: U.S. recalls don't apply because the xDrive45e PHEV uses a different starter than non-hybrid B58 vehicles. However, codes 216115 and 216119 only exist on vehicles equipped with a conventional pinion starter — confirming this vehicle has the same component. The subsequent written denial pivoted to warranty expiration without addressing the technical or recall-scope questions. Filing so the field record reflects this defect signature for future U.S. recall scope expansion analysis.
NHTSA ODI #11738107
Mileage unknown · Apr 30, 2026
Engine
Water pump failed while driving on highway. Completely shut down and began to smoke violently. Luckily wife was able to pull over immediately without crashing. Wife and children very disturbed. Looked up issue and 720000 BMW x5 have been recalled with same exact issue. Ours is not. Why?????
NHTSA ODI #11734883
Mileage unknown · Apr 1, 2026
Engine
The original B58 engine (B58B30M0, 2015–2017) utilized a conventional mechanically robust gerotor oil pump with predominantly metallic internal construction and demonstrated strong reliability in field operation. Beginning with the B58 Technical Update introduced for 2018 production (B58B30O1), BMW redesigned the lubrication sy…
Read full complaint
The original B58 engine (B58B30M0, 2015–2017) utilized a conventional mechanically robust gerotor oil pump with predominantly metallic internal construction and demonstrated strong reliability in field operation. Beginning with the B58 Technical Update introduced for 2018 production (B58B30O1), BMW redesigned the lubrication system by integrating the engine vacuum pump and oil pump into a combined variable-displacement assembly. This redesign introduced a thermoplastic internal adjusting ring (carrier) responsible for regulating oil pump displacement through rotor eccentricity control. This component, constructed from reinforced thermoplastics including PA66-GF materials, operates within a chemically aggressive and thermally cyclic environment involving continuous exposure to engine oil additives, fuel dilution, condensation, and repeated heat cycling. While acceptable under accelerated validation testing, real-world operating conditions increasingly demonstrate premature degradation consistent with polymer embrittlement and fracture. Observed Failure Mode Documented owner and technician reports indicate that under cold-start conditions — particularly in sub-freezing climates — elevated oil viscosity and startup load impose increased mechanical stress on the thermoplastic carrier. Fracture of this internal component allows debris intrusion into the pump mechanism, resulting in unstable oil pressure regulation. Commonly reported precursor symptoms include: • Inability to perform electronic oil level measurement via iDrive • Erratic or oscillating oil pressure behavior • Intermittent lubrication warnings or absence of warning prior to failure • Rapid progression to bearing damage and engine seizure In many cases, drivers receive insufficient warning before catastrophic lubrication loss occurs. Vehicles may become disabled without notice, including during highway operation or winter driving conditions, leaving occupants stranded in potentially dangerous environ
NHTSA ODI #11728431
44,000 miles · Jan 2, 2026
Engine
The contact owns a 2021 BMW X5. The contact stated that while driving at undisclosed speeds, unknown warning lights illuminated on several occasions. The failure had occurred while driving and while restarting the vehicle. The vehicle was taken to a dealer, where it was diagnosed, and determined that the starter had failed and n…
Read full complaint
The contact owns a 2021 BMW X5. The contact stated that while driving at undisclosed speeds, unknown warning lights illuminated on several occasions. The failure had occurred while driving and while restarting the vehicle. The vehicle was taken to a dealer, where it was diagnosed, and determined that the starter had failed and needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The approximate failure mileage was 44,000.
NHTSA ODI #11708344
Mileage unknown · Dec 10, 2025
EngineSuspension
In the middle of driving, multiple warning lights came on in the car and the steering became very stiff, which made it difficult to steer the car. We brought the car to the dealer service station and they identified that the crank pulley system had a failure and the vibration damper needed to be replaced. Apparently, this issu…
Read full complaint
In the middle of driving, multiple warning lights came on in the car and the steering became very stiff, which made it difficult to steer the car. We brought the car to the dealer service station and they identified that the crank pulley system had a failure and the vibration damper needed to be replaced. Apparently, this issue also resulted in the engine not properly charging the car battery, which also resulted in battery failure. This car only has about 38,000 miles on it and has been plagued by safety issues. The difficulty steering the car could have resulted in an accident on the road. This same car also had a water pump failure at approximately 35-36k miles that was separately reported to NHTSA previously.
NHTSA ODI #11704139
Mileage unknown · Dec 9, 2025
Engine
BMW 2021 X5 Engine starter failed. BMW South Miami dealership troubleshooting found the starter motor faulty and replaced it. This failure is NOT part of the current starter recall for BMW X5. (25V644000) My X5 maufactured date is June of 2021. I purchased the X5 In July of 2021. I paid $2166.35 for repairs and I am seaking a r…
Read full complaint
BMW 2021 X5 Engine starter failed. BMW South Miami dealership troubleshooting found the starter motor faulty and replaced it. This failure is NOT part of the current starter recall for BMW X5. (25V644000) My X5 maufactured date is June of 2021. I purchased the X5 In July of 2021. I paid $2166.35 for repairs and I am seaking a refund.
NHTSA ODI #11703980
Official recalls
12Apr 20, 2022
BMW of North America, LLC (BMW) is recalling certain 2022 4 Series Gran Coupe (430i, 430i xDrive, M440i xDrive); 2019-2022 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M; 2021-2022 X5 xdrive45e; 2020-2022 X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6M and 2019-2023 X7 xDrive40i, X7 xDrive50i, X7 M50i, X7 xDrive60i, X7 M60i, X7M, Alpina XB7 vehicles. The roof function control unit may be programmed incorrectly, allowing the sunroof to close without the key fob present inside the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
Consequence & remedy
Consequence: A sunroof that closes without the key fob present inside the vehicle can increase the risk of injury.
Remedy: Dealers will reprogram the roof function control unit, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact BMW customer service at 1-800-525-7417.
Mar 10, 2021
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i, X5 xDrive50i, X5 M50i, X5 xDrive45e, 2021 X7 xDrive40i, X7 M50i, and XB7 vehicles. The head restraints on the second-row outer seats may be the incorrect type for the vehicle.
Consequence & remedy
Consequence: In the event of a crash, the head restraints could detach, and increase the risk of injury.
Remedy: BMW will notify owners, and dealers will inspect the head restraints, and replace them as necessary, free of charge. The recall began May 3, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Feb 19, 2021
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Back Over Prevention:software
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Back Over Prevention: Sensing System: Camera
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Feb 18, 2021
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i and X5 xDrive40i vehicles. The right front brake disc may have been assembled with incorrect fasteners, which over time, could result in the front brake disc becoming loose.
Consequence & remedy
Consequence: A loose brake disc could affect vehicle handling and control, and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the right front brake disc and replace it if necessary, along with the unaffected left side brake disc, free of charge. There are no owner vehicles affected; therefore, owner notification is not necessary and, as such, a planned owner notification date is not entered into the recall schedule. Owners may contact BMW's customer service at 1-800-525-7417.
Additional source detail variants (2)
Service Brakes, Hydraulic:critical Fasteners
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i and X5 xDrive40i vehicles. The right front brake disc may have been assembled with incorrect fasteners, which over time, could result in the front brake disc becoming loose.
Consequence: A loose brake disc could affect vehicle handling and control, and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the right front brake disc and replace it if necessary, along with the unaffected left side brake disc, free of charge. There are no owner vehicles affected; therefore, owner notification is not necessary and, as such, a planned owner notification date is not entered into the recall schedule. Owners may contact BMW's customer service at 1-800-525-7417.
Service Brakes, Hydraulic:foundation Components:disc
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i and X5 xDrive40i vehicles. The right front brake disc may have been assembled with incorrect fasteners, which over time, could result in the front brake disc becoming loose.
Consequence: A loose brake disc could affect vehicle handling and control, and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the right front brake disc and replace it if necessary, along with the unaffected left side brake disc, free of charge. There are no owner vehicles affected; therefore, owner notification is not necessary and, as such, a planned owner notification date is not entered into the recall schedule. Owners may contact BMW's customer service at 1-800-525-7417.
Feb 10, 2021
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence & remedy
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:hydraulic
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Service Brakes, Hydraulic
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Jan 29, 2021
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i, X5 xDrive40i, X5M, X5 xDrive45e, X6 sDrive40i, X6 xDrive40i, X7 xDrive40i, X7 M50i vehicles. The steering column shaft's universal joint connection may not have been tightened to specifications, and can become loose.
Consequence & remedy
Consequence: A loose steering column shaft universal joint connection can affect vehicle handling and control, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect and, depending upon the inspection, either the bolt will be replaced and tightened to specifications, or the steering column shaft, universal joint, and bolt will be replaced and tightened to specifications, free of charge. The recall began March 30, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Dec 9, 2020
BMW of North America, LLC (BMW) is recalling certain 2021 M340i xDrive, M440i xDrive Coupe, 530i, 530i xDrive, 540i, 540i xDrive, 740Li, 740Li xDrive, 840i Gran Coupe, 840i xDrive Gran Coupe, X5 sDrive40i, X5 xDrive40i, X6 sDrive40i, X6 xDrive40i, and X7 xDrive40i vehicles. The connection between the 48-Volt battery and the starter-generator may not have been assembled properly, which can cause increased electrical resistance at the connections.
Consequence & remedy
Consequence: Increased electrical resistance can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect the connection between the 48-Volt battery and the starter-generator assembly, replacing it if necessary, free of charge. The recall is expected to begin April 12, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Nov 4, 2020
BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive40i, xDrive40i, X5 M50i, X5M, X7 xDrive40i, X7 M50i, X6 xDrive40i, X6 M50i and X6M vehicles and 2021 X5 xDrive45e vehicles. The weld between the front axle support and the right front control arm bearing bracket may separate.
Consequence & remedy
Consequence: If the weld between the front axle support and the right front control arm bearing bracket separates, vehicle handling and control may be affected, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front axle support, free of charge. The recall began December 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Sep 30, 2020
BMW of North America, LLC (BMW) is recalling certain 2020-2021 530e, 530e xDrive, 530e iPerformance and X3 xDrive30e and MINI Cooper Countryman All4 SE, 2020 BMW i8, and 2021 330e, 330e xDrive, 745Le xDrive and X5 xDrive45e vehicles. Debris may have entered one or more of the hybrid battery cells during their production.
Consequence & remedy
Consequence: The debris could result in a short-circuit, increasing the risk of fire or injury.
Remedy: BMW will inspect and, if necessary, replace the battery module free of charge. The remedy is currently being developed. Until the remedy is completed, drivers are instructed to not charge their vehicles. Drivers are instructed to not drive in manual mode, sport mode, and to not use the shift paddles. Owners were notified of the safety risk October 23, 2020. The recall began November 24, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Sep 1, 2020
BMW of North America, LLC (BMW) is recalling certain 2020-2021 X5 sDrive40i, xDrive40i, xDrive50i, X5 M50i, X5M, X6 sDrive40i, xDrive40i, X6 M50i, X6M, X7 M50i and 2021 X5 xDrive45e vehicles. The headlamps may allow a blue light to illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Oncoming drivers may be confused by the blue light of approaching vehicles, which could potentially increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the headlamps and, if necessary, replace them, free of charge. The recall began October 30, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Aug 18, 2020
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence & remedy
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Electrical System:propulsion System:traction Battery
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Electrical SYSTEM:12V/24V/48V Battery
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Aug 14, 2020
BMW of North America, LLC (BMW) is recalling certain 2021 X6 (sDrive40i, xDrive40i and M50i) and X5 (sDrive40i, xDrive40i and M50i) vehicles equipped with certain Pirelli tires. The tires may have a damaged inner layer, possibly resulting in a rapid loss of pressure while the vehicle is moving.
Consequence & remedy
Consequence: A rapid loss of tire pressure while the vehicle is moving can affect vehicle handling and control, increasing the risk of a crash.
Remedy: BMW has notified all of the affected owners, and dealers will replace the defective tires, free of charge. BMW has contacted owners by telephone and those owners have had their cars remedied. Owner notification letters will not be sent. Owners may contact BMW customer service at 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration