NHTSA owner reports · September 18, 2026 snapshot.
Forward Collision Avoidance complaints
5 reportsClear category filter74,000 miles · Sep 10, 2026
Forward Collision AvoidanceCrashInjury
The contact owned a 2021 BMW X3. The contact stated that while driving 25 MPH, the vehicle in front suddenly stopped, and the contact moved over to the left lane and into the grass due to incoming traffic. The vehicle was 50 to 100 feet from a tree, and the vehicle crashed. The contact stated that the braking system and Forward …
Read full complaint
The contact owned a 2021 BMW X3. The contact stated that while driving 25 MPH, the vehicle in front suddenly stopped, and the contact moved over to the left lane and into the grass due to incoming traffic. The vehicle was 50 to 100 feet from a tree, and the vehicle crashed. The contact stated that the braking system and Forward Collision Avoidance failed to operate as designed. The driver's left arm was fractured. Medical attention was provided. The driver’s arm was still in a cast. The vehicle was deemed a total loss by the bank. The driver test drove a 2024 and 2025 BMW X5, and the Forward Collision Avoidance feature failed to operate as needed. The vehicle was towed. There was smoke coming from the driver’s side front of the vehicle. The air bags deployed, and there was smoke coming from the air bags. BMW customer service was contacted, but no assistance was provided. The failure mileage was 74,000.
NHTSA ODI #11763390
Mileage unknown · May 8, 2025
Forward Collision AvoidanceService BrakesVehicle Speed Control
Constant emergency braking when I’m not near another vehicle.
NHTSA ODI #11659861
Mileage unknown · Dec 30, 2024
Forward Collision AvoidanceUnknown Or Other
Upon starting the vehicle, the electronic dashboard comes on, declares “Reduced Driver Assistance” then about 15 seconds later, the entire dashboard goes dark and won’t come back on until the car has been shut down for several minutes. This sequence of events happens 95% of the time that I start the car. Upon restart, the dash…
Read full complaint
Upon starting the vehicle, the electronic dashboard comes on, declares “Reduced Driver Assistance” then about 15 seconds later, the entire dashboard goes dark and won’t come back on until the car has been shut down for several minutes. This sequence of events happens 95% of the time that I start the car. Upon restart, the dashboard will stay on about 40% of the time, the other 60% it shuts off again. While I can still see my speed in the heads up display, I have no idea how much gas I have, I can’t get any information from the dahsboard and I can’t use the cruise control. I’ve read about other owners of the 2021 BMW X3 M40i having this same issue however the dealership seems to have no idea and wants me to spend $1,000 in diagnostics to see if they can find the problem….then I would have to pay to have it fixed as well. This seems like a pretty big safety issue.
NHTSA ODI #11633069
Mileage unknown · Dec 5, 2024
Forward Collision AvoidanceUnknown Or Other
The malfunction involves the collision warning system and sudden braking functionality. The dealership inspection identified a problem with the KAFAS (camera) unit, specifically its housing being deformed from heat, which affected the functionality of the collision sensor and caused the system to malfunction intermittently. The …
Read full complaint
The malfunction involves the collision warning system and sudden braking functionality. The dealership inspection identified a problem with the KAFAS (camera) unit, specifically its housing being deformed from heat, which affected the functionality of the collision sensor and caused the system to malfunction intermittently. The component is still installed in the vehicle and available for inspection if required. The system triggered sudden braking without an actual threat, creating a serious risk of being rear-ended by vehicles behind me. This issue has occurred twice in the last month, with no warning or actual collision risk present. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the problem was confirmed by the dealership. Their inspection found that the KAFAS camera housing is deformed due to heat exposure, causing malfunction warnings and erroneous braking behavior. They stated this is not a covered warranty issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The dealership performed an inspection and provided an inspection report, but no other entities (e.g., manufacturer, police, or insurance representatives) have inspected the component or vehicle. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? Yes, the malfunction indicator light for the collision sensor appeared intermittently. The dealership’s report attributes this to the deformation of the KAFAS camera housing due to heat exposure.
NHTSA ODI #11629071
Mileage unknown · Apr 13, 2023
Forward Collision Avoidance
Traveling on 2 lane road with no cars around, bright day, 2:30pm about 40mph. Emergency braking beeped twice and immediately slammed on the brakes. Not sure what it thought it saw- tree shadows? The feature was set to medium. If another car was behind us it would have slammed into us. 5th time in 2 years. The dealer just shrugs …
Read full complaint
Traveling on 2 lane road with no cars around, bright day, 2:30pm about 40mph. Emergency braking beeped twice and immediately slammed on the brakes. Not sure what it thought it saw- tree shadows? The feature was set to medium. If another car was behind us it would have slammed into us. 5th time in 2 years. The dealer just shrugs and says to not set it to high responsiveness. This is a bad defect.
NHTSA ODI #11516916
Official recalls
10Jan 30, 2026
BMW of North America, LLC (BMW) is recalling certain 2021-2023 Toyota Supra, 2022-2023 2 Series Coupe, 2021-2024 5 Series (xDrive), 2021-2022 Z4, 2022-2024 4 Series (Gran Coupe), 2021-2024 4 Series (Convertible and xDrive Convertible), 2021-2023 4 Series (Coupe), 2021-2024 3 Series, 2021-2023 X4, 2021-2024 X3 vehicles. Please see the recall report for a complete list of all models. The engine starter may overheat and catch fire due to wear on an internal component.
Consequence & remedy
Consequence: Fire increases the risk of injury.
Remedy: Dealers will replace the engine starter, free of charge. Owner notification letters were mailed July 21, 2026. Owners may contact BMW customer service at 1-800-525-7417 or Toyota's customer service at 1-800-331-4331. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 24, 2026.
Sep 23, 2025
BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
Consequence & remedy
Consequence: A short circuit in the starter relay may increase the risk of a fire.
Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 14, 2025.
Oct 15, 2024
BMW of North America, LLC (BMW) is recalling certain 2018-2022 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3 M vehicles. The attachment for the rear cargo rail may become damaged in a rear crash and result in the cargo rail detaching.
Consequence & remedy
Consequence: Interior rear cargo rail detachment during a crash can increase the risk of injury.
Remedy: Dealers will replace the rear cargo rail attachment bolts, free of charge. Owner notification letters were mailed December 12, 2024. Owners may contact BMW customer service at 1-800-525-7417. Vehicles in this recall were previously remedied for this issue under recall number 24V-534 and will need to have the new repair completed.
Jul 17, 2024
BMW of North America, LLC (BMW) is recalling certain 2018-2023 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3 M vehicles. The attachment for the interior cargo rail may become damaged in a rear crash and result in the cargo rail detaching.
Consequence & remedy
Consequence: Interior cargo rail detachment during a rear crash can increase the risk of injury.
Remedy: Dealers will replace the rear cargo rail attachment bolts, free of charge. Owner notification letters were mailed January 2, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Mar 29, 2023
BMW of North America, LLC (BMW) is recalling certain 2019-2021 330i, 330i xDrive, M340i xDrive, 2020-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, 2021 X3 xDrive30e, X4 xDrive30i, and X4M vehicles. The seat frame may not have been welded properly to the seat rails.
Consequence & remedy
Consequence: An improperly welded seat frame may not properly restrain the occupant during a crash, increasing the risk of injury.
Remedy: Dealers will replace the seat frame and back rest, free of charge. Owner notification letters were mailed May 22, 2023. Owners may contact BMW customer service at 1-800-525-7417.
Mar 24, 2021
BMW of North America, LLC (BMW) is recalling certain 2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, and X4, and 2021 X4 xDrive30i vehicles. The inlet check valve weld may fail, allowing the filling pipe to separate from the fuel tank.
Consequence & remedy
Consequence: Fuel may leak through the failed weld, increasing the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the fuel tank, free of charge. The recall is scheduled to begin May 17, 2021. Owners were also contacted by telephone. To date, all repairs have been done. No further owner notification letters will be sent. Owners may contact BMW customer service at 1-800-525-7417.
Feb 19, 2021
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Back Over Prevention:software
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Back Over Prevention: Sensing System: Camera
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Sep 30, 2020
BMW of North America, LLC (BMW) is recalling certain 2020-2021 X3 sDrive 30i, X3 xDrive 30i, X3M 40i, X3 xDrive 30e, X4 xDrive 30i, X4M 40i, 530i, 540i, 540i xDrive, M550i xDrive, M5, 550e, 550e xDrive, and 550e iPerformance vehicles. A small portion of the rearview image may be slightly obscured. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: If the driver relies on only the rearview camera image, the reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, program the rearview camera with updated software. The recall began November 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Sep 30, 2020
BMW of North America, LLC (BMW) is recalling certain 2020-2021 530e, 530e xDrive, 530e iPerformance and X3 xDrive30e and MINI Cooper Countryman All4 SE, 2020 BMW i8, and 2021 330e, 330e xDrive, 745Le xDrive and X5 xDrive45e vehicles. Debris may have entered one or more of the hybrid battery cells during their production.
Consequence & remedy
Consequence: The debris could result in a short-circuit, increasing the risk of fire or injury.
Remedy: BMW will inspect and, if necessary, replace the battery module free of charge. The remedy is currently being developed. Until the remedy is completed, drivers are instructed to not charge their vehicles. Drivers are instructed to not drive in manual mode, sport mode, and to not use the shift paddles. Owners were notified of the safety risk October 23, 2020. The recall began November 24, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Aug 18, 2020
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence & remedy
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Electrical System:propulsion System:traction Battery
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Electrical SYSTEM:12V/24V/48V Battery
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration