2021 BMW X3

There is an open safety recall for the engine starter on this vehicle. I contacted the local BMW dealer on 7/10/26 to have the recall fixed they advised me that they cannot address the recall because BMW North America has not sent the parts out for them to do so. I would like this on record in case there is any future damage to my vehicle due to the recall.

Filing regarding NHTSA Recalls 25V-636 and 26V-056. My 2021 BMW X3 M40i (VIN: [XXX] , built September 2020) contains the recall-affected starter part number ending in 997 — confirmed by a BMW Level 1 certified technician — not the non-recall part number ending in 505. BMW denied coverage based solely on manufacture date, with no consideration of the actual components installed. My vehicle displays an active fire risk. On April 30, 2026, my dashboard displayed Engine cannot be started, Starter system fault. Call Roadside Assistance, and Repeat start attempt — all photographed and timestamped. Fault codes 216119, 35AE00, and 8040A9 were confirmed by diagnostic scan. BMW of Catonsville (Work Order XXX) attributed the fault to the battery and charged me $280.50. I replaced the battery with a BMW OEM unit on May 13, 2026 at a cost of $590.31. On May 21, 2026, the identical starter fault returned — conclusively disproving the battery diagnosis and confirming the starter as the root cause. BMW denied recall coverage by phone through BMW of Catonsville. No written denial was provided. I am requesting NHTSA investigate whether the recall scope incorrectly excludes vehicles built with the recall-affected starter component, compel BMW to expand coverage to include my VIN, replace my starter at no cost, and reimburse my out-of-pocket costs of $870.81. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The oil pump is exhibiting erratic oil pressure behavior, verified by certified BMW technicians. This behavior has been documented by BMW to indicate that the oil pump can fail without warning, leading to an Uncommanded Loss of Propulsion Angle. The sudden and unexpected loss of power-assisted steering and braking, when the engine stalls in active traffic, can lead to death of the occupants or other drivers that the uncommanded automobile may collide with. Additionally, the thermoplastics in the oil pump component tend to shatter during cold starts, leaving occupants stranded in cold weather, and again, potentially leading to death. BMW is aware of this safety concern but is not offering a remedy at this time.

The engine oil pump has an internal plastic housing that can fail and will cause oil pressure variations and even low pressure which can lead to engine failure. This has been documented for a while on various b58tu engines. This a very costly repair that can easily be 5000-6000 usd. Failure of the said part can also render that vehicle unable to drive.

2021 BMW X3 M40i – Starter Motor Failure Matches NHTSA 26V056000 Defect (No-Start at Stop Light + Excessive Starter Torque Fault + Fire Risk) I am filing this safety complaint regarding a sudden starter motor failure on my 2021 BMW X3 M40i. On March 31, 2026, the vehicle stalled at a stop light and displayed the message “car can be restarted in XX seconds.” After the timed period elapsed and a few restart attempts, the vehicle would not start and had to be towed to Sewell BMW Mini of Plano, Texas. The service department at the dealership diagnosed a faulty starter motor. The technician’s notes explicitly state: “checked faults for excessive torque and found starter motor faulty” and the vehicle inspection video shows the starter unraveling. They quoted $2,060.50 to replace it under reliability concerns. This failure mode - sudden no-start at idle/stop with the timed restart lockout and “excessive torque” fault - is identical to the defect in NHTSA Campaign 26V056000 announced January 2026, affecting 2021–2024 X3 models. That recall describes internal starter wear causing no-start conditions and potential overheating/fire risk. BMW has already acknowledged and is replacing the starter for free on thousands of nearly identical G01 X3s. The service manager at Sewell BMW of Plano also confirmed that prior B58-engine X3 M40i models, same engine family as mine, have had starter recalls for the same issue. Despite this clear precedent, BMW North America denied our goodwill request for coverage due to it being out of warranty and that we’re not the original owners of the vehicle. We believe this is a safety defect that BMW should remedy at no cost, consistent with federal standards and their handling of the identical issue on other X3 models. Please investigate and require BMW to provide free remedy or full reimbursement. This poses a real safety risk due to a sudden stall while driving and potential fire as demonstrated in other recalled BMW X3s within the same year.

Car spontaneously caught on fire. Total loss. Drove car home from haircut appointment 5 to 10 minutes away. Parked car as normal and went inside. Within approximately 5 minutes loud knock on door “Your car is on fire!” I came out of my home and saw my car in driveway with fire erupting from engine area onto windshield, and through hole in middle of hood. Took a few seconds of video, then ran into house for large fire extinguisher. Emptied fire extinguisher contents into hole of hood and into fire area coming out from engine area onto windshield.

My vehicle is subject to an active safety recall (NHTSA #25V-636) issued in September 2025 involving the engine starter. As of today, no remedy has been provided by the manufacturer. Due to the safety risk associated with this recall, I do not feel safe operating the vehicle and have been forced to keep it parked and unused for an extended period of time. This has caused significant financial hardship, as I am still required to make monthly loan payments, maintain insurance, and cover related expenses for a vehicle that is unsafe to drive. The issue has effectively rendered the vehicle unusable. The manufacturer has failed to provide a repair, replacement, or timeline for resolution. This situation places my safety and the safety of others at risk, as the vehicle may fail to start or function properly without warning. I am requesting immediate action, as this delay is unreasonable and creates both a safety hazard and financial burden.