DIFFERENTIAL CROWN WHEEL BEARING FAILED TWICE. FIRST FAILURE 8/21/01 @ 47200 MILES SECOND FAILURE ON 8/15/02 @ 73800 MILES. THERE WAS NO WARNING ON FIRST FAILURE OTHER THAN THE SMELL OF REAR DIFF. LUBE. SECOND FAIURE OCCURED AT FREEWAY SPEED AND ALMOST CAUSED LOSS OF CONTROL OF MOTORCYCLE. MANUFACTURER COVERED EXPENSE OF FIR…
Read full complaint
DIFFERENTIAL CROWN WHEEL BEARING FAILED TWICE. FIRST FAILURE 8/21/01 @ 47200 MILES SECOND FAILURE ON 8/15/02 @ 73800 MILES. THERE WAS NO WARNING ON FIRST FAILURE OTHER THAN THE SMELL OF REAR DIFF. LUBE. SECOND FAIURE OCCURED AT FREEWAY SPEED AND ALMOST CAUSED LOSS OF CONTROL OF MOTORCYCLE. MANUFACTURER COVERED EXPENSE OF FIRST FAILURE. WAITING FOR AN ANSWER ON SECOND FAILURE. FIRST FAILURE REPAIRED BY DEALER IN SAN DIEGO, SECOND FAILURE REPAIRED BY DEALER IN POMONA CA. SELLING DEALER WOULD NOT WORK ON BIKE AT FIRST FAILURE AND HAD TO TRAILER BIKE TO SAN DIEGO FOR REPAIRS. SECOND FAILURE OCCURED IN CALIF. AND DEALER IN POMONA WAS THE MOST CONVIENENT.*AK
VEHICLE DESCRIPTION: MOTORCYCLES. A SPRING-LOADED THERMOSTATIC ELEMENT IN THE OIL THERMOSTAT HOUSING IS HELD IN PLACE BY A COVER THAT IS RETAINED BY A SNAP RING. THE SNAP RING MAY NOT HAVE BEEN PROPERLY INSTALLED DURING PRODUCTION. DURING VEHICLE OPERATION, THE SNAP RING COULD UNSEAT, ALLOWING THE COVER TO LOOSEN OR DETACH, RESULTING IN LOSS OF THE ENTIRE OIL VOLUME.
Consequence & remedy
Consequence: ENGINE DAMAGE COULD OCCUR IF THE ENGINE IS NOT IMMEDIATELY SWITCHED OFF. IN ADDITION, OIL COULD TRAVEL ALONG THE ENGINE COVER AND ULTIMATELY CONTACT THE REAR TIRE, REDUCING ITS TRACTION AND AFFECTING THE STABILITY OF THE MOTORCYCLE, POSSIBLY RESULTING IN A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE SNAP RING INSTALLATION AND IF THE SNAP RING IS NOT FULLY SEATED, THE COMPLETE OIL PUMP INTERMEDIATE FLANGE WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE03054 · Fuel Line Leakage
Opened Dec 1, 2003 · Closed Jan 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
BMW IS CONDUCTING A RECALL (04V-028).AN INFORMATION REQUEST(IR)RESPONSE WAS NOT RECEIVED. UPON BMW'S RECEIPT OF THE IR, AND AFTER DISCUSSIONS WITH ODI, BMWDETERMINED THAT A RECALL WAS NECESSARY. ON CERTAIN MOTORCYCLES, THE O-RING CONTAINED WITHIN THE FUEL LINE QUICK-DISCONNECT COUPLING COULD BECOME DAMAGED.FURTHER, THERE IS ALSO A PROBLEM INVOLVING CRIMP-TYPE HOSE CLAMPS, WHICH CAN ALSO RESULT IN A SMALL FUEL LEAK.DEALERS WILL INSPECT, AND IF NECESSARY, ADJUST ALL CRIMP-TYPE HOSE CLAMPS.ALSO ALL FUEL LINE QUICK-DISCONNECT COUPLINGS WILL BE INSPECTED.IF A LEAK IS DETECTED, THE QUICK-DISCONNECT O-RING WILL BE REPLACED.IF DAMAGED, THE COUPLING WILL BE REPLACED.OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 2004.
2000 BMW K1200RS Problems, Complaints & Recalls | Skip That Year
Illustration