Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
4 reports
73,678 miles · Nov 27, 2010
Fuel System, Gasoline
WHILE RIDING ON EXPRESSWAY ENGINE QUIT AND I PULLED TO THE SIDE OF THE ROAD. FUEL WAS BEING PUMPED OUT ONTO THE HOT ENGINE AND MY SHOES AND CLOTHING. ON INSPECTION FOUND A BROKEN FUEL LINE CONNECTOR ON THE HIGH PRESSURE SIDE OF THE FUEL LINE GOING FROM THE FUEL PUMP TO THE FUEL INJECTION SYSTEM ON THE MOTOR. AT A LATER DATE T…
Read full complaint
WHILE RIDING ON EXPRESSWAY ENGINE QUIT AND I PULLED TO THE SIDE OF THE ROAD. FUEL WAS BEING PUMPED OUT ONTO THE HOT ENGINE AND MY SHOES AND CLOTHING. ON INSPECTION FOUND A BROKEN FUEL LINE CONNECTOR ON THE HIGH PRESSURE SIDE OF THE FUEL LINE GOING FROM THE FUEL PUMP TO THE FUEL INJECTION SYSTEM ON THE MOTOR. AT A LATER DATE THE LOW PRESSURE SIDE OF THE SYSTEM ALSO FAILED AND AGAIN FUEL RUNS OUT ONTO THE HOT ENGINE AND ONTO CLOTHING JUST WAITING FOR A SPARK FOR IGNITION. TO ME THIS LOOKS LIKE A REALLY BAD ACCIDENT JUST WAITING FOR A PLACE TO HAPPEN. IN RESEARCHING THIS I HAVE BEEN TOLD BY TWO DEALERS THAT THIS IS NOT UNCOMMON ON THIS AND OTHER MODELS OF BMW MOTORCYCLES. THE REPAIR CONSISTS OF REPLACING THE BROKEN PLASTIC MALE PART OF THE CONNECTOR WITH A METAL PIECE THAT IS READILY AVAILABLE. IT CERTAINLY APPEARS THAT BMW IS IGNORING THIS PROBLEM PRETENDING THAT IT DOESN'T EXIST EVEN THOUGH THEY ARE AWARE OF IT.
NHTSA ODI #10368768
27,900 miles · Aug 26, 2007
Service Brakes, Hydraulic
THE MOTORCYCLE EXPERIENCED AN ABS FAULT WARNING WHILE RIDING ON HIGHWAY. NO LOSS OF CONTROL OR DAMAGE BUT THE PARTIALLY LINKED ABS BRAKES NO LONGER WORKED. THE DEALER WAS ABLE TO DIAGNOSE THE FAULT CODE AS "FAULTY HYDRAULIC PRESSURE MODULATOR PUMP" THE DEALER RESET THE ALARM CODE AND THE ABS SYSTEM OPERATED FOR ABOUT 300 MILE…
Read full complaint
THE MOTORCYCLE EXPERIENCED AN ABS FAULT WARNING WHILE RIDING ON HIGHWAY. NO LOSS OF CONTROL OR DAMAGE BUT THE PARTIALLY LINKED ABS BRAKES NO LONGER WORKED. THE DEALER WAS ABLE TO DIAGNOSE THE FAULT CODE AS "FAULTY HYDRAULIC PRESSURE MODULATOR PUMP" THE DEALER RESET THE ALARM CODE AND THE ABS SYSTEM OPERATED FOR ABOUT 300 MILES WHEN IT FAULTED. A SECOND RESET AND CODE READ REVEALED SAME FAULT WITH HYDRAULIC PRESSURE MODULATOR. *TR
NHTSA ODI #10200825
49,500 miles · May 31, 2007
Suspension
1) I HIT 2 POTHOLES IN THE ROAD, ONE RIGHT AFTER THE OTHER. 2) THE FRONT WHEEL FENDER GOT LODGED BETWEEN THE RADIATOR AND THE FAIRING. 3) TOOK BIKE TO THE DEALER WHERE THEY APPARENTLY COMPRESSED THE SHOCKS ALL THE WAY TO PULL THE FENDER OUT. NO PARTS WERE REPLACED. DEALER REPORTED ALL PARTS IN GOOD CONDITION. *TR
NHTSA ODI #10192129
Mileage unknown · Aug 18, 2002
Power Train
DIFFERENTIAL CROWN WHEEL BEARING FAILED TWICE. FIRST FAILURE 8/21/01 @ 47200 MILES SECOND FAILURE ON 8/15/02 @ 73800 MILES. THERE WAS NO WARNING ON FIRST FAILURE OTHER THAN THE SMELL OF REAR DIFF. LUBE. SECOND FAIURE OCCURED AT FREEWAY SPEED AND ALMOST CAUSED LOSS OF CONTROL OF MOTORCYCLE. MANUFACTURER COVERED EXPENSE OF FIR…
Read full complaint
DIFFERENTIAL CROWN WHEEL BEARING FAILED TWICE. FIRST FAILURE 8/21/01 @ 47200 MILES SECOND FAILURE ON 8/15/02 @ 73800 MILES. THERE WAS NO WARNING ON FIRST FAILURE OTHER THAN THE SMELL OF REAR DIFF. LUBE. SECOND FAIURE OCCURED AT FREEWAY SPEED AND ALMOST CAUSED LOSS OF CONTROL OF MOTORCYCLE. MANUFACTURER COVERED EXPENSE OF FIRST FAILURE. WAITING FOR AN ANSWER ON SECOND FAILURE. FIRST FAILURE REPAIRED BY DEALER IN SAN DIEGO, SECOND FAILURE REPAIRED BY DEALER IN POMONA CA. SELLING DEALER WOULD NOT WORK ON BIKE AT FIRST FAILURE AND HAD TO TRAILER BIKE TO SAN DIEGO FOR REPAIRS. SECOND FAILURE OCCURED IN CALIF. AND DEALER IN POMONA WAS THE MOST CONVIENENT.*AK
VEHICLE DESCRIPTION: MOTORCYCLES. A SPRING-LOADED THERMOSTATIC ELEMENT IN THE OIL THERMOSTAT HOUSING IS HELD IN PLACE BY A COVER THAT IS RETAINED BY A SNAP RING. THE SNAP RING MAY NOT HAVE BEEN PROPERLY INSTALLED DURING PRODUCTION. DURING VEHICLE OPERATION, THE SNAP RING COULD UNSEAT, ALLOWING THE COVER TO LOOSEN OR DETACH, RESULTING IN LOSS OF THE ENTIRE OIL VOLUME.
Consequence & remedy
Consequence: ENGINE DAMAGE COULD OCCUR IF THE ENGINE IS NOT IMMEDIATELY SWITCHED OFF. IN ADDITION, OIL COULD TRAVEL ALONG THE ENGINE COVER AND ULTIMATELY CONTACT THE REAR TIRE, REDUCING ITS TRACTION AND AFFECTING THE STABILITY OF THE MOTORCYCLE, POSSIBLY RESULTING IN A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE SNAP RING INSTALLATION AND IF THE SNAP RING IS NOT FULLY SEATED, THE COMPLETE OIL PUMP INTERMEDIATE FLANGE WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE03054 · Fuel Line Leakage
Opened Dec 1, 2003 · Closed Jan 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
BMW IS CONDUCTING A RECALL (04V-028).AN INFORMATION REQUEST(IR)RESPONSE WAS NOT RECEIVED. UPON BMW'S RECEIPT OF THE IR, AND AFTER DISCUSSIONS WITH ODI, BMWDETERMINED THAT A RECALL WAS NECESSARY. ON CERTAIN MOTORCYCLES, THE O-RING CONTAINED WITHIN THE FUEL LINE QUICK-DISCONNECT COUPLING COULD BECOME DAMAGED.FURTHER, THERE IS ALSO A PROBLEM INVOLVING CRIMP-TYPE HOSE CLAMPS, WHICH CAN ALSO RESULT IN A SMALL FUEL LEAK.DEALERS WILL INSPECT, AND IF NECESSARY, ADJUST ALL CRIMP-TYPE HOSE CLAMPS.ALSO ALL FUEL LINE QUICK-DISCONNECT COUPLINGS WILL BE INSPECTED.IF A LEAK IS DETECTED, THE QUICK-DISCONNECT O-RING WILL BE REPLACED.IF DAMAGED, THE COUPLING WILL BE REPLACED.OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 2004.
2000 BMW K1200RS Problems, Complaints & Recalls | Skip That Year
Illustration