RECALL 14401 FROM OCT. 14, 1988. THIS VEHICLE WAS FIXED UNDER WARRANTY IN 2001 UNDER THIS RECALL. IT FAILED AGAIN RECENTLY AND FUEL STARTED LEAKING. THE PARTS TO DO THE REMEDY ARE NO LONGER AVAILABLE PER MY DEALER. THE ONLY ALTERNATIVE IS TO REPLACE THE FUEL TANK AND RELATED COMPONENTS WITH A STYLE THAT BMW DEVELOPED TO SOLV…
Read full complaint
RECALL 14401 FROM OCT. 14, 1988. THIS VEHICLE WAS FIXED UNDER WARRANTY IN 2001 UNDER THIS RECALL. IT FAILED AGAIN RECENTLY AND FUEL STARTED LEAKING. THE PARTS TO DO THE REMEDY ARE NO LONGER AVAILABLE PER MY DEALER. THE ONLY ALTERNATIVE IS TO REPLACE THE FUEL TANK AND RELATED COMPONENTS WITH A STYLE THAT BMW DEVELOPED TO SOLVE THIS SAFETY ISSUE. MY DEALER CALLED BMW NA SERVICE TWICE AND WAS TOLD THERE IS NO LONGER SUPPORT FOR SOLVING THIS PROBLEM. I CALLED CUSTOMER SERVICE AND GOT THE SAME REPLY...NO CURRENT RECALL. BMW NA IS NOT WILLING TO ASSIST IN ANY WAY TO SOLVE A KNOWN SAFETY ISSUE. *TR
NHTSA ODI #10455068
Mileage unknown · Sep 19, 1998
Fuel System, Gasoline
MOTORCYCLE PARKED IN 90 DEGREE GARARE AFTER RIDE. ONE HALF HOUR LATER GAS PUDDLE 3' IN DIAMETER UNDER BIKE DRIPPING FROM TANK ONTO HOT ENGINE THEN HOT EXHAUST AND GARAGE FILLED WITH VAPORS. NO SMELL OF FUEL WHEN PARKING, SUDDEN FAILURE.
NHTSA ODI #780468
Mileage unknown · Aug 22, 1998
Fuel System, Gasoline
MASSIVE LEAKING OF GASOLINE FROM TANK APPEARS TO BE RELATED TO HOT WEATHER AND EXPANSION OF GASKET INTERFACE BETWEEN TANK BLADDER AND FUEL PUMP, REPAIR WORK ON TANK
NHTSA ODI #540232
Mileage unknown · Aug 17, 1998
Fuel System, Gasoline
MOTORCYCLE HAD THE ORIGINAL AND REPLACED GAS TANKS DEVELOP LEAKS. ABOUT ONE GALLON PER HOUR. NO ACCIDENT, BUT CLOSE. ALMOST CAUGHT FIRE.
VEHICLE DESCRIPTION: MOTORCYCLES. A SPRING-LOADED THERMOSTATIC ELEMENT IN THE OIL THERMOSTAT HOUSING IS HELD IN PLACE BY A COVER THAT IS RETAINED BY A SNAP RING. THE SNAP RING MAY NOT HAVE BEEN PROPERLY INSTALLED DURING PRODUCTION. DURING VEHICLE OPERATION, THE SNAP RING COULD UNSEAT, ALLOWING THE COVER TO LOOSEN OR DETACH, RESULTING IN LOSS OF THE ENTIRE OIL VOLUME.
Consequence & remedy
Consequence: ENGINE DAMAGE COULD OCCUR IF THE ENGINE IS NOT IMMEDIATELY SWITCHED OFF. IN ADDITION, OIL COULD TRAVEL ALONG THE ENGINE COVER AND ULTIMATELY CONTACT THE REAR TIRE, REDUCING ITS TRACTION AND AFFECTING THE STABILITY OF THE MOTORCYCLE, POSSIBLY RESULTING IN A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE SNAP RING INSTALLATION AND IF THE SNAP RING IS NOT FULLY SEATED, THE COMPLETE OIL PUMP INTERMEDIATE FLANGE WILL BE REPLACED.
VEHICLE DESCRIPTION: MOTORCYCLES. THE CYLINDER HEAD CONTAINS TWO SEALING PLUGS COVERING HOLES IN THE AREA NEAR THE SPARK PLUGS. ONE OR BOTH PLUGS MAY NOT HAVE BEEN FULLY SEATED DURING VEHICLE ASSEMBLY. EITHER OR BOTH OF THE SEALING PLUGS COULD LOOSEN OR COMPLETELY DETACH FROM THEIR MOUNTING POINT DURING VEHICLE OPERATION.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW COOLANT TO ESCAPE, TRAVEL ALONG THE ENGINE COVER, AND CONTACT THE REAR TIRE, REDUCING ITS TRACTION AND AFFECTING THE STABILITY OF THE MOTORCYCLE. IN ADDITION, THE LOSS OF COOLANT COULD LEAD TO INCREASED ENGINE OPERATING TEMPERATURE AND POSSIBLE OVERHEATING.
Remedy: DEALERS WILL REPLACE THE SEALING PLUGS WITH A STAINLESS STEEL PLUG DESIGN.
VEHICLE DESCRIPTION: MOTORCYCLES. DURING EXTENDED OPERATION IN HIGH AMBIENT TEMPERATURE CONDITIONS, THE AREA OF THE PUMP MOUNTING SURFACE OF THE FUEL TANK CAN DEFORM, FORMING A GAP BETWEEN THE TANK MOUNTING SURFACE AND THE GASKET, ALLOWING FUEL TO ESCAPE FROM THE TANK AT THAT AREA.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR RESULTING IN PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP-TO-TANK GASKET.
VEHICLE DESCRIPTION: MOTORCYCLES. THE ADJUSTING SCREW FOR THE PRESSURE POINT OF EITHER THE BRAKE OR CLUTCH LEVERS MAY NOT BE SUFFICIENTLY TIGHT, DUE TO GREASE CONTAMINATION OF THE THREADS.
Consequence & remedy
Consequence: THE SCREW(S) CAN BACK OUT OVER TIME WHILE THE VEHICLE IS BEING OPERATED CAUSING A CHANGE IN THE PRESSURE POINT OF THE MASTER CYLINDER FOR THE CLUTCH AND/OR FRONT BRAKE INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL CHECK THE ADJUSTMENT SCREWS OF THE FRONT BRAKE AND CLUTCH LEVERS FOR MOVEMENT. IF THE SCREWS ARE TIGHT, NO FURTHER ACTION WILL BE TAKEN. IF A SCREW IS FOUND TO BE LOOSE, IT WILL BE REMOVED, CLEANED AND REINSTALLED WITH NEW LOCTITE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE98047 · Fuel Tank Leak
Opened Aug 27, 1998 · Closed Oct 15, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGED THAT THE FUEL LEAKS AT THE INTERFACE BETWEEN THE FUEL TANK AND FUEL PUMP ASSEMBLY
SQ97023 · Reduced Clutch And Brake Effectiveness
Opened Nov 14, 1997 · Closed Dec 22, 1997
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
IN AUGUST 1997, BMW CONDUCTED A SAFETY RECALL TO CORRECT A CONDITION OF THREAD CONTAMINATION ON THE BRAKE AND CLUTCH LEVERS ADJUSTING SCREWS.THIS GREASE CONTAMINATION NEGATES THE EFFECTIVENESS OF LOCTITE AND THIS CAN SEGNIFICANTLY REDUCE BRAKE EFFECTIVENESS.DUE TO THIS INVESTIGATION, BMW HAS INCREASED THE POPULATION TO INCLUDE ALL THE 1988 MOTORCYCLES.NO FURTHER ACTION IS NECESARY.THIS INVESTIGATION IS CLOSED.RECALL NUMBER ASSIGNED IS 97V-134.02.
1998 BMW K1200RS Problems, Complaints & Recalls | Skip That Year
Illustration