IllustrationTHE REAR BRAKE ROTOR ON MY 2005 BMW K1200LT MOTORCYCLE IS DEFECTIVE AND I BELIEVE IT SHOULD BE RECALLED. THE FLOATING POINTS ON THE ROTOR HAVE MELTED ALLOWING THE ROTOR TO MOVE IN ALL DIRECTIONS CAUSING THE ABS MODULATOR TO ACTIVATE ON ANY BRAKING. *TR
2005 BMW K1200 Lt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Other model years Selected year
Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 17 of 19 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports3 injury reports
Service Brakes, Hydraulic complaints
2 reportsABS BRAKE FAILURE CRASH BMW K1200S MOTORCYCLE. I HAVE RECENTLY EXPERIENCED AN ABS SERVO BRAKE FAILURE RESULTING IN A CRASH ON A K1200S. I SIMPLY LIGHTLY CARESSED THE FRONT BRAKE LEVER ON A DRY ROAD WITH THE BIKE UPRIGHT AT MODEST SPEED AND THE FRONT BRAKES IMMEDIATELY LOCKED AND FAILED TO RELEASE EVEN AFTER THE BRAKE LEVER WAS R…
Read full complaint
ABS BRAKE FAILURE CRASH BMW K1200S MOTORCYCLE. I HAVE RECENTLY EXPERIENCED AN ABS SERVO BRAKE FAILURE RESULTING IN A CRASH ON A K1200S. I SIMPLY LIGHTLY CARESSED THE FRONT BRAKE LEVER ON A DRY ROAD WITH THE BIKE UPRIGHT AT MODEST SPEED AND THE FRONT BRAKES IMMEDIATELY LOCKED AND FAILED TO RELEASE EVEN AFTER THE BRAKE LEVER WAS RELEASED. I SURVIVED, JUST, BUT WITH VERY SERIOUS INJURIES I NEED TO HAVE THE ABS BRAKE SYSTEM ON MY [WRITTEN OFF] BIKE INDEPENDENTLY TESTED SO THAT I MAY TACKLE BMW IN AN ATTEMPT TO PREVENT FURTHER INJURY/DEATH TO OTHERS AS A RESULT OF THESE IMO LETHAL BRAKES. IS ANY BODY ABLE TO ASSIST IN THIS RESPECT? DOES ANY BODY KNOW OF A RESOURCE THAT HAS LOGGED SIMILAR INCIDENCES [I.E. BRAKE FAILURES ON ABS SERVO EQUIPPED BMWS], THE DEPARTMENT OF TRANSPORT FOR EXAMPLE? ALL ASSISTANCE WOULD BE GRATEFULLY RECEIVED. *TR
Official recalls
204V438000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 9, 2004
ON CERTAIN MOTORCYCLES, AT LOWER TEMPERATURES, WIRING WITHIN THE ANTI-THEFT CONTROL UNIT MAY PRESS AGAINST THE FUEL PUMP RELAY. THE FUEL PUMP RELAY CONTACTS COULD OPEN, INTERRUPTING THE FUEL SUPPLY TO THE ENGINE, RESULTING IN STALLING.
Consequence & remedy
Consequence: IF STALLING WERE TO OCCUR, THE DRIVER WOULD BE UNABLE TO MAINTAIN SPEED OR ACCELERATE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ANTI-THEFT CONTROL UNIT. THE RECALL BEGAN OCTOBER 4, 2004. CUSTOMERS SHOULD CONTACT BMW AT 1-800-831-1117.
04V304000 · Service Brakes, Hydraulic:foundation Components:master Cylinder
Jun 23, 2004
ON CERTAIN MOTORCYCLES, AN INCORRECT SEALING RING WAS MOUNTED TO THE PISTON OF THE REAR BRAKE MASTER CYLINDER.
Consequence & remedy
Consequence: IF ONLY THE REAR BRAKE WERE APPLIED DURING RIDING, INSUFFICIENT BRAKING PRESSURE WOULD BE AVAILABLE TO SLOW THE MOTORCYCLE, WHICH COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDER. THE RECALL BEGAN JULY 16, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP12001 · M/c Final Drive Ball Bearing Failure
Opened Jan 20, 2012 · Closed Jun 20, 2013
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
The Office of Defects Investigation (ODI) received a defect petition requesting that it open an investigation into model year (MY) 1998-2009 BMW KLT series motorcycles for final drive bearing failures.The petitioner asked NHTSA to issue an order that [BMW] be required to recall the affected models for inspection ofcomponent wear and proper assembly of the [final drive] bearing.ODI has reviewed the petition, assessed relevant consumer complaints, and gathered other data in the course of investigating this issue.Based on its review, ODI does not believe that a safety-related defect trend currently exists for final drive bearing failures in the subject motorcycles.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to accomplish the agency's safety mission, the petition is denied.However, the agency will continue to monitor information related to this issue and will take further action if warranted.For detailed information, see the Federal Register notice: https://federalregister.gov/a/2013-13779.