WHEEL BEARING ON CHAINRING SIDE OF REAR HUB WORE OUT PREMATURELY AT 9,000 MILES. OTHER BEARINGS ON FRONT AND REAR HUBS WERE FUNCTIONING WELL. HAD I NOT CHECKED THIS BEARING, AFTER READING ABOUT MULTIPLE SUCH INCIDENTS, CATASTROPHIC FAILURE COULD HAVE OCCURRED WHILE TRAVELING AT FREEWAY SPEED LEADING TO PERSONAL INJURY AND POTENT…
Read full complaint
WHEEL BEARING ON CHAINRING SIDE OF REAR HUB WORE OUT PREMATURELY AT 9,000 MILES. OTHER BEARINGS ON FRONT AND REAR HUBS WERE FUNCTIONING WELL. HAD I NOT CHECKED THIS BEARING, AFTER READING ABOUT MULTIPLE SUCH INCIDENTS, CATASTROPHIC FAILURE COULD HAVE OCCURRED WHILE TRAVELING AT FREEWAY SPEED LEADING TO PERSONAL INJURY AND POTENTIALLY INJURY TO OTHERS. *TR
NHTSA ODI #10330369
6,356 miles · Oct 25, 2009
Wheels
I HAD THE REAR WHEEL BEARINGS ON MY 2009 BMW F800GS MOTORCYCLE CHECKED DURING ITS ROUTINE 6,000 MILE SERVICE. THE BEARINGS ON MY BIKE SHOWED EVIDENCE OF ACCELERATED WEAR. THEY WERE REPLACED BY THE BMW SHOP, UNDER WARRANTY. ONE WOULD EXPECT SUCH BEARINGS TO LAST A _MINIMUM_ OF 50,000 MILES, AND SO FAILURE WITH SO LITTLE MILEAGE W…
Read full complaint
I HAD THE REAR WHEEL BEARINGS ON MY 2009 BMW F800GS MOTORCYCLE CHECKED DURING ITS ROUTINE 6,000 MILE SERVICE. THE BEARINGS ON MY BIKE SHOWED EVIDENCE OF ACCELERATED WEAR. THEY WERE REPLACED BY THE BMW SHOP, UNDER WARRANTY. ONE WOULD EXPECT SUCH BEARINGS TO LAST A _MINIMUM_ OF 50,000 MILES, AND SO FAILURE WITH SO LITTLE MILEAGE WAS UTTERLY UNEXPECTED. ON A MOTORCYCLE, REAR WHEEL BEARING FAILURE AT SPEED COULD LEAD TO LOSS OF CONTROL OF THE VEHICLE, RESULTING IN INJURY OR DEATH TO THE OPERATOR. *TR
NHTSA ODI #10289703
11,000 miles · Oct 22, 2009
Wheels
REAR WHEEL BEARING DETERIORATION AT 12,000 MILES ON A BMW F800GS. RIDING UNDER NORMAL CIRCUMSTANCES. CHECK THE BEARING AFTER READING AN INTERNET POST ABOUT SEVERAL OTHER PEOPLE WITH THE SAME MAKE AND MODEL HAVING BEARING FAILURES. THE BEARING FELT PITTED AND GRITTY. I TOOK IT TO THE DEAL AND THEY REPLACED THEM UNDER WARRANTY WIT…
Read full complaint
REAR WHEEL BEARING DETERIORATION AT 12,000 MILES ON A BMW F800GS. RIDING UNDER NORMAL CIRCUMSTANCES. CHECK THE BEARING AFTER READING AN INTERNET POST ABOUT SEVERAL OTHER PEOPLE WITH THE SAME MAKE AND MODEL HAVING BEARING FAILURES. THE BEARING FELT PITTED AND GRITTY. I TOOK IT TO THE DEAL AND THEY REPLACED THEM UNDER WARRANTY WITH FACTORY PARTS. UNCHECKED THIS WOULD HAVE MOST LIKELY LEAD TO A CATASTROPHIC FAILURE WITH POSSIBLE INJURY OR DEATH. *TR
BMW IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 F650 GS AND F 800 GS MOTORCYCLES MANUFACTURED FROM SEPTEMBER 27, 2007 THROUGH MARCH 30, 2009. THE DRIVE CHAINS MAY NOT HAVE BEEN PRODUCED TO SPECIFICATION. AS A RESULT, OVER TIME THE DRIVE CHAIN COULD BREAK.
Consequence & remedy
Consequence: IF THE BROKEN CHAIN BECOMES TRAPPED BETWEEN THE REAR WHEEL AND THE FRAME, THE REAR WHEEL COULD LOCK UP, POSSIBLY RESULTING IN A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE DRIVE CHAIN AND SPROCKETS ON THE AFFECTED MOTORCYCLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 30, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
BMW IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 F650 GS AND F800 GS MOTORCYCLES MANUFACTURED BETWEEN JANUARY 2008 AND DECEMBER 2009. DURING ENGINE OPERATION, A VACUUM IS CREATED IN ORDER TO DRAW FRESH AIR INTO THE CANISTER. THIS AIR THEN MIXES WITH THE FUEL VAPORS CAPTURED BY THE CANISTER, AND IS SUBSEQUENTLY COMBUSTED. DUE TO THE ROUTING OF THE VENTILATION HOSE, WATER NEAR THE END OF THE HOSE COULD BE DRAWN INTO THE CHARCOAL CANISTER.
Consequence & remedy
Consequence: WATER COULD FLOW INTO THE CANISTER CAUSING A STALLING CONDITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND ADD AN ADDITIONAL HOSE AND ROUTE IT SUCH THAT THE PRESENT DEFECT IS PREVENTED. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 13, 2010. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
BMW IS RECALLING 754 MY 2009 F800 GS VEHICLES. THE AXLE SHAFT WALL THICKNESS MAY NOT HAVE BEEN MANUFACTURED ACCORDING TO SPECIFICATIONS.
Consequence & remedy
Consequence: IF THE WALL THICKNESS WAS NOT SUFFICIENT, THE AXLE SHAFT COULD DEFORM AND COULD BREAK INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT WHEEL QUICK-RELEASE AXLE AND REPLACE IT WITH AN IMPROVED AXLE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2009. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2009 BMW F 800 Gs Problems, Complaints & Recalls | Skip That Year
Illustration