Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 11 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
What owners actually said
11 reports
133,000 miles · Mar 5, 2014
EngineFuel System, Gasoline
THE GAS TANK STARTED TO MAKE POPPING NOISES AND THUMPING SOUNDS. THEN WHEN I REALIZED SOMETHING IS WRONG WHEN THE GAS GAUGE STARTED READING 1/4 TANK WHEN IT WAS EMPTY, STRANGELY WHEN I WAS FILLING UP WITH GAS THE CAP WAS HARD TO REMOVE AND AS SOON AS I REMOVED THE CAP AIR WAS RUSHING IN. I RAN OUT OF GAS ON THE INTERSTATE WITHOU…
Read full complaint
THE GAS TANK STARTED TO MAKE POPPING NOISES AND THUMPING SOUNDS. THEN WHEN I REALIZED SOMETHING IS WRONG WHEN THE GAS GAUGE STARTED READING 1/4 TANK WHEN IT WAS EMPTY, STRANGELY WHEN I WAS FILLING UP WITH GAS THE CAP WAS HARD TO REMOVE AND AS SOON AS I REMOVED THE CAP AIR WAS RUSHING IN. I RAN OUT OF GAS ON THE INTERSTATE WITHOUT ANY WARNING MANAGED TO GET THE CAR ON THE SHOULDER. LATER ON THE WAY TO WORK I STARTED SMELLING A STRONG GAS ODOR I ASSUMED IT WAS THE CARS SURROUNDING ME. WHEN I WENT ON MY LUNCH BREAK MY COWORKERS INFORMED ME THAT THERE WAS A LARGE PUDDLE OF GAS UNDER MY CAR, WHEN I GOT BACK TO WORK I STARTED TO INVESTIGATE WHAT HAPPENED AND MY TANK WAS IMPLODED AND DEVELOPED LEAKS AROUND THE SEAMS. I FIND THIS A MAJOR CONCERN SINCE THIS IS RIGHT NEXT TO A HOT EXHAUST SYSTEM AND MAY CAUSE A FIRE DUE TO POOR GAS TANK VENTILATION. I'M LUCKY THAT MY CAR DIDN'T CATCH ON FIRE DUE TO THE AMOUNT OF GAS I LOST AND NOTICED LEAKING ON THE SEAMS THAT ARE EXTREMELY CLOSE TO THE EXHAUST. *TR
NHTSA ODI #10567419
179,000 miles · Jul 24, 2008
Vehicle Speed Control
ANYTIME YOU ARE ACCELERATING THE THROTTLE CABLE WILL EITHER GET STUCK OR IF YOU LET OFF THE GAS PEDAL ITS WILL CONTINUE TO ACCELERATE. THIS CAN BE VERY DANGEROUS ESPECIALLY UPON ENTERING THE HIGHWAY. THIS OCCURRED PRETTY REGULARLY UNTIL WE HAD THE THROTTLE CABLE REPLACED. *TR
NHTSA ODI #10235678
203,000 miles · May 14, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 1996 BMW 740IL. WHILE PARKING THE VEHICLE, THE CONTACT ATTEMPTED TO SHUT OFF THE ENGINE AND EXIT THE VEHICLE. AS SHE TURNED THE KEY AND REMOVED IT FROM THE IGNITION, THE ENGINE REMAINED RUNNING AND WOULD NOT SHUT OFF. SHE HAD TO REMOVE THE ENGINE FUSES FROM UNDER THE HOOD AND DISCONNECT THE BATTERY IN OR…
Read full complaint
TL*THE CONTACT OWNS A 1996 BMW 740IL. WHILE PARKING THE VEHICLE, THE CONTACT ATTEMPTED TO SHUT OFF THE ENGINE AND EXIT THE VEHICLE. AS SHE TURNED THE KEY AND REMOVED IT FROM THE IGNITION, THE ENGINE REMAINED RUNNING AND WOULD NOT SHUT OFF. SHE HAD TO REMOVE THE ENGINE FUSES FROM UNDER THE HOOD AND DISCONNECT THE BATTERY IN ORDER TO SHUT OFF THE ENGINE. AFTERWARDS, THE VEHICLE FAILED TO RESTART AND WAS TOWED TO A MECHANIC. THE MECHANIC INSTALLED A NEW CYLINDER AND HOUSING. THREE WEEKS AFTER THE REPAIRS, THE FAILURE RECURRED AND THE VEHICLE WAS TOWED BACK TO THE DEALER, WHO IS NOT TAKING ANY RESPONSIBILITY FOR THE DEFECT. THE VEHICLE IS CURRENTLY STILL AT THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 203,000.
NHTSA ODI #10227742
86,312 miles · Mar 30, 2005
Vehicle Speed Control
VEHICLE IS EXPERIENCING SUDDEN ACCELERATION. AS SOON AS THE VEHICLE IS STARTED, THE RPM'S WILL REV UP TO 3500 RPMS PREVENTING THE DRIVER FROM PUTTING THE VEHICLE IN GEAR WITHOUT A POSSIBLE CRASH. DRIVER WOULD APPLY THE BRAKES BUT THE VEHICLE WILL CONTINUE TO SURGE. PROVIDE FURTHER DETAIL. DEFECTIVE PARTS REPLACED. CAR WENT BY…
Read full complaint
VEHICLE IS EXPERIENCING SUDDEN ACCELERATION. AS SOON AS THE VEHICLE IS STARTED, THE RPM'S WILL REV UP TO 3500 RPMS PREVENTING THE DRIVER FROM PUTTING THE VEHICLE IN GEAR WITHOUT A POSSIBLE CRASH. DRIVER WOULD APPLY THE BRAKES BUT THE VEHICLE WILL CONTINUE TO SURGE. PROVIDE FURTHER DETAIL. DEFECTIVE PARTS REPLACED. CAR WENT BY ITSELF TO 90 MPH ON THE INTERSTATE. REPLACED FRONT THROTTLE BODY GASKET AND IDLE SPEED REGULATOR. *BF *NM
NHTSA ODI #10113491
Mileage unknown · Apr 29, 2002
Engine And Engine CoolingInjury
THIS PROBLEM W/ RADIATOR IS VERY COMMON W/ THIS VEHICLE AND MANUFACTURER REFUSES ANY RESPONSIBILITY. *AK
NHTSA ODI #761327
Mileage unknown · Oct 10, 2001
Fuel System, Gasoline
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #753063
Mileage unknown · Aug 22, 2001
Fuel System, Gasoline
GAS TANK IMPLODED SUCKING ITSELF IN AND CAUSING GAS TO LEAK AND SPILL. TANK WAS REPLACED IN SEPTEMBER OF 2000. HOWEVER, PROBLEM HAS BEEN ONGOING SINCE THEN. ALSO, THERE ARE POPPING NOISES COMING FROM TANK AREA, WHICH MEANS THAT GAS IN TANK IS NOT PROPERLY VENTING,CAUSING A BUILD UP. TECHNICIANS HAVE HEARD THE NOISE, BUT AR…
Read full complaint
GAS TANK IMPLODED SUCKING ITSELF IN AND CAUSING GAS TO LEAK AND SPILL. TANK WAS REPLACED IN SEPTEMBER OF 2000. HOWEVER, PROBLEM HAS BEEN ONGOING SINCE THEN. ALSO, THERE ARE POPPING NOISES COMING FROM TANK AREA, WHICH MEANS THAT GAS IN TANK IS NOT PROPERLY VENTING,CAUSING A BUILD UP. TECHNICIANS HAVE HEARD THE NOISE, BUT ARE UNABLE TO RECTIFY IT WHEN IT'S NOT DOING IT.*AK
NHTSA ODI #894920
Mileage unknown · Dec 19, 2000
Latches/locks/linkages
HOOD CAME CRASHING UP AGAINST WINDSHIELD WHILE DRIVING ON FREEEWAY. THIS COULD HAVE CAUSED A CRASH DEALER FOUND THAT THE SAFETY HOLD DOWN PIN ON THE LEFT SIDE HOOD LOCK WAS MISSING, DEALER REPLACED THE HOOD LOCK ASSEMBLY. *AK *SLC
NHTSA ODI #876728
Mileage unknown · Dec 19, 2000
Latches/locks/linkages
HOOD CAME SMASHING INTO WINDSHIELD FRAME, BLOCKING VISIBILITY OF HIGHWAY. *AK
NHTSA ODI #737999
Mileage unknown · Mar 16, 2000
Service Brakes, Hydraulic
BRAKE WARNING LIGHT SWITCH FAILED, ALLOWING THE SWITCH TO REMAIN IN THE BRAKE LIGHT OFF POSITION OR IN THE BRAKE LIGHT ON POSITION. ALSO, WHEN TURNING VEHICLE OFF, THE WARNING BRAKE LIGHT COMES ON. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.
Consequence & remedy
Consequence: THE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1996 BMW 740IL Problems, Complaints & Recalls | Skip That Year
Illustration