TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE STEERING WHEEL BECAME VERY STIFF AND THE POWER STEERING DEACTIVATED WARNING LAMP ILLUMINATED. THE CONTACT MENTIONED THAT AFTER RESTARTING THE VEHICLE, ALL OF THE WARNING LAMPS ILLUMINATED AND AN ELECTRONIC MALFUNCTION WARNING MESSAGE SHOWED U…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE STEERING WHEEL BECAME VERY STIFF AND THE POWER STEERING DEACTIVATED WARNING LAMP ILLUMINATED. THE CONTACT MENTIONED THAT AFTER RESTARTING THE VEHICLE, ALL OF THE WARNING LAMPS ILLUMINATED AND AN ELECTRONIC MALFUNCTION WARNING MESSAGE SHOWED UP BEFORE THE VEHICLE STALLED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE 120,000. *TR
NHTSA ODI #10510213
50,000 miles · Aug 30, 2012
Latches/locks/linkagesSteeringVehicle Speed Control
FREQUENT ELECTRONIC MALFUNCTIONS (AVERAGES 1 PER HOUR). CAR WILL ENGAGE CRUISE CONTROL WITH NO WARNING. OCCASIONALLY WILL INCREASE THE CRUISE CONTROL BY 5 MILE PER HOUR INCREMENTS. WILL RANDOMLY SPRAY & WIPE WINDOWS. FREQUENTLY UNLOCKS DOORS & WILL NOT ALLOW THEM TO BE LOCKED AGAIN UNTIL THE CAR IS STOPPED & TURNED OFF. MAK…
Read full complaint
FREQUENT ELECTRONIC MALFUNCTIONS (AVERAGES 1 PER HOUR). CAR WILL ENGAGE CRUISE CONTROL WITH NO WARNING. OCCASIONALLY WILL INCREASE THE CRUISE CONTROL BY 5 MILE PER HOUR INCREMENTS. WILL RANDOMLY SPRAY & WIPE WINDOWS. FREQUENTLY UNLOCKS DOORS & WILL NOT ALLOW THEM TO BE LOCKED AGAIN UNTIL THE CAR IS STOPPED & TURNED OFF. MAKES FREQUENT EMERGENCY CALLS (OFTEN 3-4 TIMES IN AN HOUR). MOVES & ADJUSTS STEERING WHEEL WHILE DRIVING. ACTIVATES TURN SIGNALS. ACTIVATES 4 WAY FLASHERS. ROLLS UP & DOWN WINDOWS WITH NO WARNING. SOMETIMES WILL GO OUTSIDE TO CAR TO FIND WINDOWS ROLLED DOWN WHILE CAR WAS PARKED. ACTIVATES ALARM SIREN WHILE DRIVING. AND MORE ..... *TR
NHTSA ODI #10472992
58,990 miles · Dec 12, 2010
Power TrainSteering
I HAVE 2005 545I BMW, LAST WEEK I RECEIVED RECALL ON BRAKING SYSTEM ASKED TO TAKE MY CAR TO DEALER AND GET IT FIX. TOOK THE CAR TO DEALER AND THEY REPLACED THE DEFECTED PART. THEY CHECKED EVERYTHING AND MENTION EVERYTHING IS FINE. TODAY AT APPROXIMATELY 1:30 PM I HAVE RECEIVED ACTIVE STEERING MALFUNCTION MESSAGE . I WAS DRIVING …
Read full complaint
I HAVE 2005 545I BMW, LAST WEEK I RECEIVED RECALL ON BRAKING SYSTEM ASKED TO TAKE MY CAR TO DEALER AND GET IT FIX. TOOK THE CAR TO DEALER AND THEY REPLACED THE DEFECTED PART. THEY CHECKED EVERYTHING AND MENTION EVERYTHING IS FINE. TODAY AT APPROXIMATELY 1:30 PM I HAVE RECEIVED ACTIVE STEERING MALFUNCTION MESSAGE . I WAS DRIVING THE CAR AND WHILE DRIVING MESSAGE POPPED UP. FLUID LEVEL LOOKS FINE BUT DID NOT GET IT CHECKED BY ANYONE YET. BMW NEEDS TO DO SOMETHING WITH THEIR CARS AS THEY SEEMS TO HAVE A LOT OF ISSUES. I ALSO RECENTLY REPLACED THE SMG PUMP AS WELL AS ENGINE MODULE. *TR
NHTSA ODI #10370303
51,050 miles · May 14, 2010
Air BagsElectrical SystemEquipment Adaptive/mobility
ON MAY 12TH, I WAS DRIVING MY 2005 545I BMW AT 8PM WITH MY WIFE AND TWO CHILDREN ON THE HIGHWAY. THE DISPLAY INDICATED A WINDSHIELD WIPER MALFUNCTION (WOULD NOT TURN OFF OR CONTROL SPEED OF WIPERS). AFTER A FEW MORE MILES, I NOTICED THERE WAS NO COMMUNICATION TO ANY OF THE STEERING COLUMN CONTROLS, NOR DID THE TURN SIGNALS WOR…
Read full complaint
ON MAY 12TH, I WAS DRIVING MY 2005 545I BMW AT 8PM WITH MY WIFE AND TWO CHILDREN ON THE HIGHWAY. THE DISPLAY INDICATED A WINDSHIELD WIPER MALFUNCTION (WOULD NOT TURN OFF OR CONTROL SPEED OF WIPERS). AFTER A FEW MORE MILES, I NOTICED THERE WAS NO COMMUNICATION TO ANY OF THE STEERING COLUMN CONTROLS, NOR DID THE TURN SIGNALS WORK (WOULD NOT STAY ON UNLESS HELD DOWN). ALMOST SIMULTANEOUSLY, THE AIRBAG MALFUNCTION WARNING CAME ON, SEAT BELT TENSIONERS MAY NOT FUNCTION, AND THE ACTIVE STEERING SYSTEM MALFUNCTION WARNING CAME ON, INDICATING THAT THE CAR'S STEERING WHEEL MAY NOT BE PROPERLY ALIGNED WITH THE WHEELS. THE CAR BECAME MORE DIFFICULT (MORE EFFORT) TO STEER, WITH LOSS OF SOME POWER STEERING. I WAS ABLE TO CONTROL THE CAR BACK DOWN TO 20 MPH. AFTER STOPPING AT A TRAFFIC LIGHT, THE CAR ENTERED TRANSMISSION FAILSAFE PROGRAM, LIMITING THE CAR TO GEARS R, N, 1, 2, 3 FOR THE REMAINDER OF THE TRIP HOME. THE NEXT MORNING, THE HIGH BATTERY DRAIN INDICATOR CAME ON ALSO. POWER WINDOWS AND REMOTE KEY FUNCTIONS CEASED TO WORK, ALTHOUGH I COULD STILL CONTROL THE SUNROOF. I PROMPTLY BROUGHT THE CAR INTO THE DEALERSHIP THE NEXT MORNING ON MAY 13TH. THE BMW DEALERSHIP RAN A DIAGNOSTIC AND STATES THE SZL MODULE IN THE STEERING COLUMN NEEDS TO BE REPLACED. THE CAR IS AT 51050 MILES, AND BEYOND WARRANTY COVERAGE AT 5 YEARS OLD. BMW NA WILL NOT COVER THE COSTS OF REPAIR TO THE VEHICLE TO CORRECT THIS SAFETY ISSUE, EVEN THOUGH THERE WAS A TECHNICAL SERVICE BULLETIN (SI B340506) ISSUED FOR 2006 MODELS DESCRIBING SIMILAR FAILURES IN THEIR PRODUCTS. I AM SUBMITTING THIS REPORT SO THAT THIS WOULD NOT HAPPEN TO OTHER DRIVERS AND THEIR FAMILIES WITH SIMILAR CARS. *TR
NHTSA ODI #10330465
Mileage unknown · Sep 6, 2006
Electrical SystemSteeringStructure
2005 BMW 545I STEERING MALFUNCTION LIGHT ILLUMINATED, STALLED WITHOUT WARNING, WINDSHIELD WIPERS DIDN'T WORK WHEN IT RAINED, HEADLIGHTS SHUT OFF AT NIGHT TIME, AND CHECK ENGINE WARNING LIGHT ILLUMINATED. *KB THE NAVIGATION SYSTEM WENT BLANK, THE TURN SIGNALS DID NOT WORK. THE STEERING COLUMN MOTOR WAS REPLACED. THE CONSUMER BEL…
Read full complaint
2005 BMW 545I STEERING MALFUNCTION LIGHT ILLUMINATED, STALLED WITHOUT WARNING, WINDSHIELD WIPERS DIDN'T WORK WHEN IT RAINED, HEADLIGHTS SHUT OFF AT NIGHT TIME, AND CHECK ENGINE WARNING LIGHT ILLUMINATED. *KB THE NAVIGATION SYSTEM WENT BLANK, THE TURN SIGNALS DID NOT WORK. THE STEERING COLUMN MOTOR WAS REPLACED. THE CONSUMER BELIEVED THERE WAS A SERIOUS ELECTRICAL PROBLEM WITH THE VEHICLE. THE CHECK ENGINE LIGHT ILLUMINATED BECAUSE WATER WAS FOUND IN THE LUGGAGE COMPARTMENT WHICH HAD DAMAGED THE WIRES.*JB
NHTSA ODI #10168026
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
2005 BMW 545I Problems, Complaints & Recalls | Skip That Year
Illustration