2005 BMW 545I E60 FAULT IN PASSENGER RESTRAINT SYSTEM: THIS MODEL BMW HAS EXPERIENCED A FAULT IN THE PASSENGER RESTRAINT SYSTEM AND IS NOT LISTED IN THE PAST RECALL WHICH CAN LEAD TO DANGEROUS SITUATIONS IF AN ACCIDENT OCCURS AND THE RESTRAINT SYSTEM MALFUNCTIONS. THE PROBLEM IS IN THE MAT OF THE PASSENGER SEAT AND UPON A PAS…
Read full complaint
2005 BMW 545I E60 FAULT IN PASSENGER RESTRAINT SYSTEM: THIS MODEL BMW HAS EXPERIENCED A FAULT IN THE PASSENGER RESTRAINT SYSTEM AND IS NOT LISTED IN THE PAST RECALL WHICH CAN LEAD TO DANGEROUS SITUATIONS IF AN ACCIDENT OCCURS AND THE RESTRAINT SYSTEM MALFUNCTIONS. THE PROBLEM IS IN THE MAT OF THE PASSENGER SEAT AND UPON A PASSENGER GETTING INTO MY CAR ABOUT A YEAR AGO, I RECEIVED THE ERROR MESSAGE. I SPOKE WITH VARYING BMW DEALERSHIPS (IN DIFFERENT STATES) AND RECEIVED MIXED INFORMATION FROM THE RECALL WASN'T APPROVED YET TO THE CURRENT VERSION OF NO RECALL AND I WOULD HAVE TO PAY THE FULL REPAIR COSTS. SPEAKING WITH BMW OF USA, THERE WAS APPARENTLY AN EXTENDED WARRANTY ISSUED FOR THIS PROBLEM, BUT THE DEALERSHIP NEVER MENTIONED THIS POSSIBILITY TO ME WHEN SPEAKING WITH THEM. AS OF NOW, THE EXTENDED WARRANTY IS EXPIRED SO SHOULD THIS ISSUE OCCUR ON YOUR CAR TODAY - YOU ARE RESPONSIBLE FOR THE FULL COST OF THE REPAIR WHICH IS IN EXCESS OF $1000 AND ADDITIONAL DIAGNOSTIC FEES. THERE IS A VAST AMOUNT OF INFORMATION ON THE POOR QUALITY OF THE PASSENGER SEAT MAT USED BY BMW IN THESE MODELS LEADING TO THIS MALFUNCTION. CAN SOMEONE PLEASE EXPLAIN WHY THE E60 BMW MODELS WERE NOT COVERED IN THE RECALL WHEN THEY ARE EXPERIENCING THE SAME EXACT ISSUE AS OTHER MODELS THAT WERE COVERED? THIS CAN GET SOMEONE SERIOUSLY HURT AND BMW IS PLACING THIS RESPONSIBILITY BACK ON THE CONSUMER WHEN THEY ARE AT FAULT. THIS ISSUE CLEARLY SPANS MANY MORE BMW MODELS THAT WERE LISTED IN THE RECALL AND CONSUMERS ARE BEING FORCED TO PAY THE BILL FOR POOR DECISIONS ON BMW'S PART. IT WOULD BE NICE TO SEE MORE ACTION AND ATTENTION PLACED ON THIS ISSUE BY THE NHTSA. RELATED INSTANCES OF THE SAME ISSUE: NHTSA CAMPAIGN NUMBER: 15V205000 NHTSA CAMPAIGN NUMBER: 13V564000
NHTSA ODI #10779344
147,950 miles · Sep 30, 2015
Air Bags
FRONT OCCUPANCY SEAT SENSOR MAT. THIS IS UNDER CAMPAIGN ID 08V384000. MY MAKE AND MODEL PLUS YEAR IS INCLUDED IN THIS. A CALL TO BMW STATES THAT MY CAR IS NOT IN THIS RECALL.
NHTSA ODI #10778844
86,400 miles · Feb 2, 2015
Air Bags
I TURNED ON MY CAR AND A NOTIFICATION APPEARED ON THE IDRIVE THAT THERE WAS A PASSENGER RESTRAINT SYSTEM FAILURE. I READ THAT THERE WAS A RECALL ON THIS AND CALLED MY LOCAL BMW DEALERSHIP TO GIVE THEM MY VIN TO SEE IF MY VEHICLE WOULD BE ON THE RECALL. I FOUND OUT THAT IT WAS NOT. I DON'T KNOW WHAT FITS THE CRITERIA FOR THE R…
Read full complaint
I TURNED ON MY CAR AND A NOTIFICATION APPEARED ON THE IDRIVE THAT THERE WAS A PASSENGER RESTRAINT SYSTEM FAILURE. I READ THAT THERE WAS A RECALL ON THIS AND CALLED MY LOCAL BMW DEALERSHIP TO GIVE THEM MY VIN TO SEE IF MY VEHICLE WOULD BE ON THE RECALL. I FOUND OUT THAT IT WAS NOT. I DON'T KNOW WHAT FITS THE CRITERIA FOR THE RECALL AND IF THIS WOULD BE CONSIDERED NORMAL WEAR AND MAINTENANCE OF THE VEHICLE. *TR
NHTSA ODI #10680728
135,000 miles · Jan 14, 2015
Air BagsSeat Belts
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT UPON ENTERING THE VEHICLE, THE AIR BAG AND SEAT BELT WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE PASSENGER SEAT CENTRAL MAT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTAC…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT UPON ENTERING THE VEHICLE, THE AIR BAG AND SEAT BELT WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE PASSENGER SEAT CENTRAL MAT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER 08V384000 (AIR BAGS) HOWEVER, THE VIN NUMBER WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10672585
110,000 miles · Oct 9, 2014
Air Bags
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE AIR BAG SENSOR ILLUMINATED INDICATING THAT THE AIR BAG WAS OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS NOT ABLE TO DIAGNOSE THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED YET. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MIL…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT THE AIR BAG SENSOR ILLUMINATED INDICATING THAT THE AIR BAG WAS OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS NOT ABLE TO DIAGNOSE THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED YET. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
NHTSA ODI #10643690
112,000 miles · Jun 24, 2014
Air Bags
AS SOON AS I STARTED THE CAR, THE PASSENGER SEAT BELT RESTRAINT AND AIRBAG LIGHT SHOWED UP AS A MALFUNCTION. AFTER DOING SOME RESEARCH I NOTICE THAT BMW HAD A RECALL ON A SEAT MAT SENSOR ON 200,000 5 SERIES. I ALSO DID SOME RESEARCH AND NOTICE THAT THERE IS A GREAT AMOUNT OF PEOPLE WITH THIS SAME PROBLEM. THIS IS A MAJOR CONCERN…
Read full complaint
AS SOON AS I STARTED THE CAR, THE PASSENGER SEAT BELT RESTRAINT AND AIRBAG LIGHT SHOWED UP AS A MALFUNCTION. AFTER DOING SOME RESEARCH I NOTICE THAT BMW HAD A RECALL ON A SEAT MAT SENSOR ON 200,000 5 SERIES. I ALSO DID SOME RESEARCH AND NOTICE THAT THERE IS A GREAT AMOUNT OF PEOPLE WITH THIS SAME PROBLEM. THIS IS A MAJOR CONCERN BECAUSE THE SEAT MAT SENSOR IS BAD THE PASSENGER AIRBAG WILL NOT DEPLOY IF I GET INTO A CAR ACCIDENT. *TR
NHTSA ODI #10605623
104,000 miles · May 16, 2014
Air BagsSeat Belts
I BOUGHT MY 2005 BMW 545I AFTER A WEEK MY SEATBELT AND AND AIRBAG LIGHTS WILL NOT GO OUT, EVEN WITH SEATBELT LOCKED IN, IS THERE A RECALL SO I CAN GET THIS FIX AND FEEL SAFE WHEN DRIVING MY CAR. *TR
NHTSA ODI #10592042
Mileage unknown · May 14, 2014
Air Bags
TL*THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN RECALL NUMBER: 13V564000 (AIR BAGS) BUT WAS ADVISED BY THE DEALER THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT RECEIVED THE NOTICE SEVERAL MONTHS AGO. THE MANUFACTURER WAS ALSO CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE…
Read full complaint
TL*THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN RECALL NUMBER: 13V564000 (AIR BAGS) BUT WAS ADVISED BY THE DEALER THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT RECEIVED THE NOTICE SEVERAL MONTHS AGO. THE MANUFACTURER WAS ALSO CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE RECALL REPAIR WOULD BE PERFORMED. THERE WERE NO FAILURES AT THIS TIME.
NHTSA ODI #10588289
Mileage unknown · Jan 13, 2014
Air Bags
PASSENGER SIDE AIRBAG FAULT LIGHT STAYS ON. DEALER SAID PROBLEM WASN'T UNDER WARRANTY. INFORMATION I FOUND ON THE INTERNET AND BMW SITES SAY IT IS UNDER WARRANTY. I AM AFRAID IF I'M IN AN ACCIDENT, MY PASSENGER COULD BE SERIOUSLY INJURED, OR KILLED. *TR
NHTSA ODI #10559738
75,000 miles · Jan 13, 2014
Air Bags
TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE PULLING INTO HIS DRIVEWAY AT UNKNOWN SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
NHTSA ODI #10559698
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
2005 BMW 545I Problems, Complaints & Recalls | Skip That Year
Illustration