2011 BMW 528I

I am filing a complaint regarding the recall work performed on my 2011 BMW 528i for the VANOS bolt safety recall. The recall notice stated the vehicle was unsafe to drive until repaired. I arranged towing to Jackie Cooper BMW in Edmond, Oklahoma because of this safety warning. The dealership performed the recall repair and released the vehicle back to me. Immediately after picking it up, the vehicle experienced a failure and became inoperable. The vehicle had to be towed again. This time, the dealership covered the towing cost and had the vehicle returned to my residence. Staff present at the time included a technician named Luke and the Service Drive Manager, Tayler Hawkins. Staff statements indicated that diagnostic charges would have applied if issues outside the recall were found, but no diagnostics were ultimately billed. There were also inconsistencies regarding the availability of the service manager. I am filing this complaint because the vehicle failed immediately after recall service and required towing. I am concerned that the recall work may not have been performed correctly or that the vehicle was released in a condition that was not suitable for operation. I am requesting that this incident be documented as part of the recall and safety record for this vehicle.

Again I write about 2011 bmw 528i, the vanos bolts were recalled and when bmw was fixing them they showed a video , there was belt and metal pieces in the engine oil. Whoever had this car before me did fix the belt and other issues but they said they didn't take off the bottom of the engine pan for the oil to get out .. the vanos bolt recall when I looked it up was June 1st . I had bmw fix the missing bolts 🔩 June 7th it had to be towed there and back to my house. They said they made a decision that it did not happen because of the recall . Which it stated in the recall paperwork that it can affect the engine and to not drive it ! So as of today I have a bmw that was recalled and I do believe other recalls on this car as well had everything to do with me not having a car now because the engine misfiring and stalls and brake light and sensors are all no good. Does not add up . They refused to give a new engine because the car is worth way less than a new engine.

The contact owns a 2011 BMW 528I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the vehicle stalled and lost motive power. The vehicle was towed to the residence. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 89,000. VIN tool confirms parts not available.

I have a 2011 SIX-cylinder BMW 528i. I was driving down the road and had a yellow engine light come on and my car lost all power and I coasted into a parking area and then had my vehicle towed to the BMW Service Center. They determined the problem was that the VANOS UNIT BOLTS had broken off and they repaired the vehicle charging me $6678.11. I found out about a recall for 2010-2012 5 series BMW’s and my service advisor told me that I didn’t qualify for is because the recall had expired in 2021. I called BMW North America and they referred me to NHITSA. I have a video sent to me from the service technician showing me where the bolts had sheared off. I feel that this should have been repaired by BMW at no charge to me.

SUBJECT: Recall Campaign 14V-176: N51, N52K and N52T Engine – Replace VANOS Gear Bolts, (This Service Information bulletin supersedes SI B11 07 14 dated September 2014). My 2011 BMW 528i has around 279000KM and Vanos Gear bolts are broken that Could Lead to Engine Stall and although NHTSA has issued recall campaign but BMW dealers are refusing the repair by saying that no such recall is showing against my vin [XXX]. As per online research this is a known issue in my car model and NHTSA has already issued a recall campaign#14V-176 as showing at the top of this statement. I had this issue with VANOS for almost 3 yrs as car was throwing error message once in a while and engine hesitates and bogs at lower RPM. Rough idling/ increase in engine misfires, Increase in fuel consumption. I changed several parts to troubleshoot but could not figure out the actual root cause of this problem, until recently an independent shop opened the engine to change the Engine valve cover/PCV valve, when they noticed that 2 VANOS Gear bolts are broken. That mechanic advised me to contact BMW immediately and stop driving the car as this can lead to permanent serious damage to my engine and car will stall immediately that may cause an accident or a crash. I have always taken good care of this car and hoping BMW to cover the parts/labor cost under recall campaign. I would really appreciate your help is getting this matter resolved with BMW Canada. [XXX] . [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2011 BMW 528i. The contact stated that the driver’s side headlight housing had an excessive amount of moisture inside. The vehicle failed to start. The daytime and parking light was illuminated. The vehicle was taken to an independent mechanic. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.