Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Visibility. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seats. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports1 injury reports
What owners actually said
4 reports
Mileage unknown · Mar 13, 2001
Engine And Engine Cooling
1 YEAR AGO MOTOR WENT INTO CONSUMER'S VEHICLE. IT SPLIT RADIATOR IN THE SEAM. CONSUMER TOOK RECALL 98V178000/ MANUFACTURER'S RECALL 98V178 INTO DEALER TO HAVE REPAIRS DONE. BECAUSE OF DAMAGES IT COULDN'T BE TAKEN CARE OFF. *AK THE FAILURE OF THE COOLANT SYSTEM CAUSED DAMAGE TO THE ENGINE AND RADIATOR. THIS PROBLEM NEED…
Read full complaint
1 YEAR AGO MOTOR WENT INTO CONSUMER'S VEHICLE. IT SPLIT RADIATOR IN THE SEAM. CONSUMER TOOK RECALL 98V178000/ MANUFACTURER'S RECALL 98V178 INTO DEALER TO HAVE REPAIRS DONE. BECAUSE OF DAMAGES IT COULDN'T BE TAKEN CARE OFF. *AK THE FAILURE OF THE COOLANT SYSTEM CAUSED DAMAGE TO THE ENGINE AND RADIATOR. THIS PROBLEM NEEDS TO BE CORRECTED BY THE MANUFACTURER. *YH
NHTSA ODI #882836
Mileage unknown · Jul 17, 2000
Seats
BACK END OF THE DRIVER'S SIDE SEAT WILL NOT STAY IN PLACE. PINS THAT ACTUATE THE BACK OF THE SEAT BROKE AND ALLOWED THE SEAT TO TWIST. IF THE VEHICLE IS STOPPED WITH FORCE THE SEAT MAY BREAK AND SLAMM CONSUMER AGAINST DASHBOARD. CONSUMER IS HAVING DIFFICULTY IN HAVING THE SEAT REPLACED DUE TO OTHER DEALERS ARE HAVING THE SAM…
Read full complaint
BACK END OF THE DRIVER'S SIDE SEAT WILL NOT STAY IN PLACE. PINS THAT ACTUATE THE BACK OF THE SEAT BROKE AND ALLOWED THE SEAT TO TWIST. IF THE VEHICLE IS STOPPED WITH FORCE THE SEAT MAY BREAK AND SLAMM CONSUMER AGAINST DASHBOARD. CONSUMER IS HAVING DIFFICULTY IN HAVING THE SEAT REPLACED DUE TO OTHER DEALERS ARE HAVING THE SAME PROBLEMS OF THE PINS BREAKING FROM THE BACK OF THE SEAT.*AK
NHTSA ODI #865542
Mileage unknown · Jan 12, 2000
Visibility
VEHICLE PARKED IN GARAGE. NOTICED LEAKAGE ON FLOOR OF GARAGE. CONTACTED DEALER & TOOK VEHICLE IN OCT. WAS INFORMED BY MECHANIC THE HEATER CORE HAD CORRODED & WAS WEAKENED. THE PROBLEM WAS WELL KNOWN & THE HEATER CORE NEEDED REPLACING. *AK
NHTSA ODI #854935
Mileage unknown · Feb 1, 1999
VisibilityInjury
HEATER CORE EXPLODED FILLING THE CAR WITH SUFFOCATING STEAM, VAPORS, AND HOT LIQUID ANTIFREEZE WHICH SATURATED BOTH PANT LEGS OF 3 YEAR OLD SCALDING BOTH HIS LEGS CAUSING SECOND AND THIRD DEGREE BURNS TO BOTH THIGHS, LEGS AND RIGHT FOOT.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1989 BMW 525I Problems, Complaints & Recalls | Skip That Year
Illustration