IllustrationPASSENGER RESTRAINT SYSTEM FAULT. RECEIVED WARNING MESSAGE WHEN PASSENGER SITS IN FRONT SEAT. LIGHT STAYS ON MOST OF TIME.
2006 BMW 3 Series
Owner reports · Recalls · Investigations
More warning signs than most 3 Series years
Owner complaints for the 2006 BMW 3 Series are substantially higher than the model-year median of 23.
About this comparison →How this year compares
Owner complaints by model year
Compare all 3 Series years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
250–25K
2125–50K
5250–75K
3475–100K
32100–150K
4150K+
168 reports with mileage · 34 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 101 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Latches/locks/linkages. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports1 fire reports5 injury reports
Seats complaints
12 reportsTAKATA RECALL- MY AIRBAG IN THE STEERING WHEEL HAS BEEN REPLACED. THE PASSENGER SEAT MAT SENSOR HAS HAD TO BE REPLACED 2X(1X UNDER WARRANTY) 1X I HAD TO PAY OUT OF POCKET AND NOW A 3RD TIME (OUT OF POCKET) IT HAS BROKEN AGAIN. I BELIEVE THIS IS A FAULTY PART AND SHOULD BE COVERED UNDER WARRANTY. THE VEHICLE WAS STATIONARY E…
Read full complaint
TAKATA RECALL- MY AIRBAG IN THE STEERING WHEEL HAS BEEN REPLACED. THE PASSENGER SEAT MAT SENSOR HAS HAD TO BE REPLACED 2X(1X UNDER WARRANTY) 1X I HAD TO PAY OUT OF POCKET AND NOW A 3RD TIME (OUT OF POCKET) IT HAS BROKEN AGAIN. I BELIEVE THIS IS A FAULTY PART AND SHOULD BE COVERED UNDER WARRANTY. THE VEHICLE WAS STATIONARY EACH TIME THIS HAS BROKEN.
GETTING A HARD WARNING FOR "PASSENGER RESTRAINT SYSTEM MALFUNCTION". APPARENTLY THIS HAS SOMETHING TO DO WITH A SENSOR IN THE PASSENGER SEAT GOING BAD. THIS CAN CAUSE INJURY OR FATALITY AS THE PASSENGER AIRBAG WILL NOT DEPLOY CORRECTLY. THERE HAS BEEN A RECALL FOR THIS BUT MY VIN WAS NOT INCLUDED.
RESTRAINT MALFUNCTION FOR FRONT PASSENGER CODE 93C3. MY VIN IS NOT A PART OF THE RECALL BUT THE PARTICULAR MODEL HAS RECALL FOR THE SAME ISSUE. THE CODE IS FOR THE AIRBAG WHICH WOULD NOT DEPLOY IN THE CASE OF AN ACCIDENT IF A PASSENGER IS SITTING IN THE FRONT SEAT OR NOT.
FRONT SEAT PASSENGER OCCUPANT PROTECTION MAT FAILED. AIR BAG WILL NOT DEPLOY. AIR BAG FAULTS WERE SHOWN ON THE DASHBOARD AND INFORMATION CENTER. RECALL CAMPAIGN - 08V384000 WAS ISSUED BUT MY VEHICLE IS NOT COVERED. RECALL CAMPAIGN SHOULD BE EXTENDED TO OTHER MODELS IN THIS YEAR.
FAULTY FRONT PASSENGER SEAT SENSOR MAT ALWAYS BREAKS
THE AIRBAG AND SEATBELT LIGHTS CAME ON MY CAR WHEN A PASSENGER WAS IN THE FRONT SEAT AND WE WENT OVER A DIP IN THE ROAD.
I RECEIVED A RECALL NOTICE FROM BMW IN JANUARY 2014 (RECALL CAMPAIGN NUMBER 13V-564: FRONT PASSENGER AIR BAG SEAT OCCUPANCY SENSOR MAT). THE RECALL NOTICE STATES THAT IN THE CURRENT CONDITION, THE VEHICLE IS UNSAFE TO DRIVE WITH A PASSENGER IN THE FRONT PASSENGER SEAT. THE RECALL NOTICE STATES THAT THE PARTS NEEDED TO PERFORM …
Read full complaint
I RECEIVED A RECALL NOTICE FROM BMW IN JANUARY 2014 (RECALL CAMPAIGN NUMBER 13V-564: FRONT PASSENGER AIR BAG SEAT OCCUPANCY SENSOR MAT). THE RECALL NOTICE STATES THAT IN THE CURRENT CONDITION, THE VEHICLE IS UNSAFE TO DRIVE WITH A PASSENGER IN THE FRONT PASSENGER SEAT. THE RECALL NOTICE STATES THAT THE PARTS NEEDED TO PERFORM THE REPAIR ARE SCHEDULED TO BE AVAILABLE IN MARCH 2014. IT IS NOW MAY 6, 2014 AND BMW CUSTOMER RELATIONS HAS INDICATED THAT THE PARTS ARE STILL NOT AVAILABLE AND THEY ARE UNABLE TO PROVIDE AN ESTIMATE ON WHEN THEY WILL BE. IT HAS NOW BEEN NEARLY 5 MONTHS SINCE RECEIVING THE ORIGINAL RECALL NOTICE. DURING THIS TIME I ESSENTIALLY HAVE A VEHICLE THAT IS UNSAFE TO DRIVE WITH A PASSENGER IN THE FRONT PASSENGER SEAT. BMW DOES NOT APPEAR TO BE TAKING THIS ISSUE SERIOUSLY AND PROVIDING A PROMPT RESOLUTION TO THIS PROBLEM. I HAVE PLACED REPEATED CALLS INTO BMW CUSTOMER RELATIONS AND CONTINUE TO BE INFORMED THAT NOTHING CAN BE DONE UNTIL THE REQUIRED PARTS ARE MADE AVAILABLE. ANY ASSISTANCE YOU CAN PROVIDE IS GREATLY APPRECIATED. *TR
PASSENGER SAT IN THE FRONT PASSENGER SEAT. WARNING LIGHT APPEARED ON DASHBOARD INDICATING THE AIRBAG HAS BEEN TURNED OFF. THIS ISSUE IS SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 08V384000. HOWEVER, ALTHOUGH SAME MODEL AND YEAR, MY VEHICLE IS NOT COVERED UNDER THIS CAMPAIGN. *TR
WHEN A PASSENGER SITS IN THE FRONT PASSENGER SEAT THE AIRBAG FAILURE LIGHT ILLUMINATES, THE SEAT BELT LIGHT ILLUMINATES AND REMAINS LIT, AND THE PASSENGER AIRBAG OFF LIGHT ILLUMINATES. THIS IS APPARENTLY DUE TO MICRO-CRACKING IN THE PASSENGER SEAT OCCUPANCY DETECTION MAT, HOWEVER BMW ONLY INCLUDES A SMALL PERCENTAGE OF AFFECTED…
Read full complaint
WHEN A PASSENGER SITS IN THE FRONT PASSENGER SEAT THE AIRBAG FAILURE LIGHT ILLUMINATES, THE SEAT BELT LIGHT ILLUMINATES AND REMAINS LIT, AND THE PASSENGER AIRBAG OFF LIGHT ILLUMINATES. THIS IS APPARENTLY DUE TO MICRO-CRACKING IN THE PASSENGER SEAT OCCUPANCY DETECTION MAT, HOWEVER BMW ONLY INCLUDES A SMALL PERCENTAGE OF AFFECTED CARS IN THE 2008 RECALL. BMW NA REFUSES TO FIX THIS SAFETY DEFECT FOR ALL 2006 BUILD YEAR 330I MODELS WITH SPORT SEATS. THE SAME SEATS WHICH ARE AFFECTED BY THE IDENTICAL ISSUE FOR 2005 BUILD YEAR. IT SEEMS GIVEN THE NUMBER OF CARS AFFECTED BY THE SAME ISSUE THAT THE DEFECT WAS NOT CORRECTED FOR THE 2006 BUILD YEAR. THIS COULD RESULT IN THE PASSENGER AIRBAG NOT DEPLOYING IN A COLLISION WHICH IS EXTREMELY DANGEROUS. *TR
Official recalls
322V119000 · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
Mar 2, 2022
BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.
08V384000 · Air Bags:frontal
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
06V400000 · Suspension:front:control Arm
Oct 18, 2006
ON CERTAIN VEHICLES, ONE OF THE SUSPENSION CONTROL ARM AND SWIVEL BEARING CONNECTION BOLTS WAS NOT TIGHTENED CORRECTLY. THE BOLTED CONNECTION COULD LOOSEN.
Consequence & remedy
Consequence: THE BOLTED CONNECTION COULD BREAK WHICH COULD IMPAIR VEHICLE HANDLING AND CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE BOLTED CONNECTION AND, IF NECESSARY, ADJUST THE CONNECTION. IN SOME CASES, IT MAY BE NECESSARY TO REPLACE THE SUSPENSION CONTROL ARM AND THE SWIVEL BEARING. THE RECALL BEGAN ON NOVEMBER 21, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.