VEHICLE DESCRIPTION: SCHOOL BUSES. THESE BUSES FAIL TO MEET THE 60 PERCENT JOINT STRENGTH REQUIREMENTS OF FMVSS NO. 221, "SCHOOL BUS BODY JOINT STRENGTH."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE ROOF MAY NOT BE SUPPORTED SUFFICIENTLY, CAUSING PERSONAL INJURY TO BUS OCCUPANTS.
Remedy: OWNERS WILL BE CONTACTED AND ADVISED TO INSPECT EACH ROOF JOINT. OWNERS WILL INSTALL REPAIR RIVETS IN EACH JOINT FOUND TO HAVE INSUFFICIENT QUANTITY OF RIVETS IN EACH EXAMINED 8 INCH SECTION.
VEHICLE DESCRIPTION: SCHOOL BUSES. THE WALL SIDE ATTACHING BOLTS FOR SOME OF THE PASSENGER SEATS MAY HAVE BEEN INSTALLED TOO CLOSE TO THE EDGE OF THE SEAT LEDGE AND IN THE WRONG ATTACHING HOLE RESULTING IN WEAKENING OF THE SEAT LEDGE AT THE ATTACHMENT POINTS.
Consequence & remedy
Consequence: IN THE EVENT OF A FRONTAL CRASH, THE REAR ATTACHING BOLT OF THESE SEATS COULD PULL OUT OF THE SEAT LEDGE INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: BLUE BIRD WILL FURNISH TO DISTRIBUTORS AND OWNERS, PARTS AND INSTRUCTIONS NECESSARY TO STRENGTHEN THE PASSENGER SEAT ATTACHMENT AT THE WALL SIDE.
VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES MOUNTED ON CHASSIS EQUIPPED WITH AN OPTION FOR THREE BATTERIES. THE BATTERY CABLES MAY NOT HAVE BEEN ROUTED PROPERLY ALLOWING THE CABLE TO BE CHAFED OR PINCHED.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE POSITIVE CABLE TO SHORT OUT CREATING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL PLUG THE HOLE IN THE BACK OF THE BATTERY COMPARTMENT THAT IS LOCATED DIRECTLY BEHIND THE BATTERY HOLD DOWN CLAMP. A NEW HOLE WILL BE ADDED DIRECTLY BELOW THE REARMOST BATTERY CABLE HOLE AND THE POSITIVE CABLE WILL BE RE-ROUTED THROUGH THE NEW HOLE.
VEHICLE DESCRIPTION: SCHOOL BUSES MOUNTED ON NAVISTAR CHASSIS. THE STANDARD CROSS VIEW MIRROR ASSEMBLIES INSTALLED ON THESE BUSES DO NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 111, "REARVIEW MIRRORS."
Consequence & remedy
Consequence: THE SCHOOL BUS DRIVER MAY NOT BE ABLE TO SEE CERTAIN PORTIONS OF THE BUS, INCREASING THE RISK OF A CRASH OR PERSONAL INJURY TO PERSONS NEAR THE BUS.
Remedy: BLUE BIRD WILL FURNISH TO DISTRIBUTORS AND OWNERS, PARTS AND INSTRUCTIONS NECESSARY TO MODIFY THE CROSS VIEW MIRROR ASSEMBLIES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE07020 · Seat Track Corrosion
Opened Apr 19, 2007 · Closed Aug 6, 2007
Status: closed (inferred from source dates) · Seats
ODI OPENED THIS PE AFTER RECEIVING THREE ALLEGATIONS OF SEAT TRACK CORROSION DISCOVERED BY FLEETS WHILE PERFORMING PREVENTATIVE MAINTENANCE.SINCE OPENING THIS INVESTIGATION, ODI HAS VISITED THE FLEETS, INSPECTED SUBJECT BUSES, INTERVIEWED SHOP PERSONNEL, REVIEWED BLUE BIRD'S RESPONSE TO OUR INFORMATION REQUEST. AND CONDUCTED A JOINT EVALUATION OF A COMPLAINT VEHICLE'S CONFORMANCE TO FMVSS 571.222, SCHOOL BUS SEATING AND CRASH PROTECTION.THE TESTING WAS CONDUCTED AT THE VEHICLE RESEARCH & TEST CENTER, ANDA BLUE BIRD BODY COMPANY TEST ENGINEER WAS IN ATTENDANCE. BASED ON THESE ACTIONS,NO SAFETY RELATED DEFECT HAS BEEN IDENTIFIED AT THIS TIME AND THIS PE IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS AND WE RESERVE THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED.NEVERTHELESS, BLUE BIRD HAS DECIDED TO MAIL NON-SAFETY OWNER LETTERS TO THESUBJECT BUS OWNERS ADVISING THEM TO INSPECT THE ALUMINUM SEAT TRACKS ON A REGULAR BASIS AND TO MAKE ANY NECESSARY REPAIR/REPLACEMENT.
1999 Blue Bird Conventional Problems, Complaints & Recalls | Skip That Year
Illustration