Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Equipment. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Air. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
4 reports
34,000 miles · Mar 5, 2007
Service Brakes, Air
THE RIGHT FRONT BRAKE LINE WAS CUT BY THE HYDRAULIC JACK FOR THE LEVELING SYSTEM. ALL THE FLUID RAN OUT WHEN THE BRAKES WERE APPLIED. NO BRAKE WARNING LIGHTS CAME ON, SO DRIVER WAS NOT AWARE OF THE PROBLEM AND DROVE FOR SEVERAL DAYS UNTIL IT WAS FOUND BY INSPECTION. APPARENTLY, THE FRONT BRAKES ARE INDEPENDENT OF THE REAR BRAKE…
Read full complaint
THE RIGHT FRONT BRAKE LINE WAS CUT BY THE HYDRAULIC JACK FOR THE LEVELING SYSTEM. ALL THE FLUID RAN OUT WHEN THE BRAKES WERE APPLIED. NO BRAKE WARNING LIGHTS CAME ON, SO DRIVER WAS NOT AWARE OF THE PROBLEM AND DROVE FOR SEVERAL DAYS UNTIL IT WAS FOUND BY INSPECTION. APPARENTLY, THE FRONT BRAKES ARE INDEPENDENT OF THE REAR BRAKES, SO THE PEDAL REMAINED NORMAL WHEN APPLIED. *JB
NHTSA ODI #10184227
Mileage unknown · Sep 15, 2006
Electrical SystemFire
I HAVE 2002 BEAVER CONTESSA MOTORHOME WITH A 330 CATAPILLAR ENGINE. RECENTLY I EXPERIENCED A PROBLEM WITH MY ALTERNATOR WHICH TURNED OUT TO BE A BURNED WIRE IN THE WIRE HARNESS. THE WIRE CONNECTED FROM THE ALTERNATOR I TERMINAL TO THE STARTER RELAY. THE FIRE BURNED SEVERAL OTHER WIRES IN THE HARNESS AND SHORTED THE RADIO AND …
Read full complaint
I HAVE 2002 BEAVER CONTESSA MOTORHOME WITH A 330 CATAPILLAR ENGINE. RECENTLY I EXPERIENCED A PROBLEM WITH MY ALTERNATOR WHICH TURNED OUT TO BE A BURNED WIRE IN THE WIRE HARNESS. THE WIRE CONNECTED FROM THE ALTERNATOR I TERMINAL TO THE STARTER RELAY. THE FIRE BURNED SEVERAL OTHER WIRES IN THE HARNESS AND SHORTED THE RADIO AND TWO GAUGES. THE WIRE COMPLETELY BURNED THROUGH BEFORE ADDITIONAL DAMAGE WAS DONE. *JB
NHTSA ODI #10168362
20,000 miles · Jul 31, 2006
Tires
DRIVING FROM BULLHEAD CITY TO PALM DESERT ... LEFT HWY 10 AND WAS ON OLD ROUTE 66 WHEN FRONT DRIVER SIDE TIRE BLEW. THE OUTSIDE TEMPERATURES WERE 100 DEGREE PLUS AND THIS HAPPENED AROUND NOON. LUCKILY NO INJURY OR CRASH. TIRE BLEW OUT SIDE PANEL AND WADDED UP MUD FLAP. COULD HAVE BEEN BAD ACCIDENT. THIS BLOW OUT WAS ON A 20…
Read full complaint
DRIVING FROM BULLHEAD CITY TO PALM DESERT ... LEFT HWY 10 AND WAS ON OLD ROUTE 66 WHEN FRONT DRIVER SIDE TIRE BLEW. THE OUTSIDE TEMPERATURES WERE 100 DEGREE PLUS AND THIS HAPPENED AROUND NOON. LUCKILY NO INJURY OR CRASH. TIRE BLEW OUT SIDE PANEL AND WADDED UP MUD FLAP. COULD HAVE BEEN BAD ACCIDENT. THIS BLOW OUT WAS ON A 2002 BEAVER PATRIOT THUNDER MOTORHOME W/455 CAT ENGINE .. TWO SLIDE OUT MODEL (GALLEY AND BEDROOM ON DRIVER SIDE). TIRE: TOYO HYPARADIAL 275/70R22.5 ...TIRES WERE DISPOSED OFF BECAUSE AT TIME COULDN'T FIND ANY RECALL INFO ON THEM...HAVE SINCE FOUND RECALLS BY COUNTRY COACH AND NATIONAL RV FOR INCIDENTS OF FRONT BLOW OUT WITH THIS TYPE TIRE DUE TO WEIGHT PROBLEM I BELIEVE. *NM
NHTSA ODI #10164037
38,000 miles · Jul 10, 2006
EquipmentStructure
DT*: THE CONTACT STATED THAT THE REAR JACK ON DRIVER SIDE DETACHED DURING AUTOMATIC LEVELING OF THE VEHICLE AND COLLIDED WITH THE DRIVE SHAFT. INSPECTORS FROM THE DEPARTMENT OF TRANSPORTATION INSPECTED THE VEHICLE, AND DETERMINED THAT THE FAILURE WAS A RESULT OF THE SEPARATION OF THE MOUNTING BRACKET DUE TO SUPERFICIAL AND SPO…
Read full complaint
DT*: THE CONTACT STATED THAT THE REAR JACK ON DRIVER SIDE DETACHED DURING AUTOMATIC LEVELING OF THE VEHICLE AND COLLIDED WITH THE DRIVE SHAFT. INSPECTORS FROM THE DEPARTMENT OF TRANSPORTATION INSPECTED THE VEHICLE, AND DETERMINED THAT THE FAILURE WAS A RESULT OF THE SEPARATION OF THE MOUNTING BRACKET DUE TO SUPERFICIAL AND SPOTTY WELDING. THE MOUNTING BRACKET WAS OBSERVED TO HAVE ROUGH EDGES RESULTING IN POOR CONTACT WITH THE CHASSIS. THE REMAINING JACKS WERE OBSERVED TO BE IN THE SAME CONDITION DUE TO THE IDENTICAL WELDING OF THE DEFECTIVE PART. UPDATED 08/14/06*JB
MONACO IS RECALLING CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
Consequence & remedy
Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
Remedy: MONACO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL BEGAN ON AUGUST 29, 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR MONACO AT 1-800-685-6545.
ON CERTAIN MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
Consequence & remedy
Consequence: IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION BEGAN SEPTEMBER 9, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-344-6332 OR WILLIAMS CONTROL AT 1-503-684-8600.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Beaver Coach Patriot Thunder Problems, Complaints & Recalls | Skip That Year
Illustration