IllustrationEngine totaled because of oil starvation I'm guessing or maybe an oil pump failure oil starvation caused Pistons to rub inside of head cost of engine and work is more than the vehicles cost so that means car is totaled
2013 Audi A8
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all A8 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
325–50K
1250–75K
375–100K
2100–150K
0150K+
22 reports with mileage · 27 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
49 reportsThe pcv oil separator has failed and is making a whistling sound. From researching this issue it is widely known and an investigation shows it is caused in relation to a recall for the oil strainer that was done on this vehicle. I called audi dealership and they said this is not an open recall, however it seems this is exactly…
Read full complaint
The pcv oil separator has failed and is making a whistling sound. From researching this issue it is widely known and an investigation shows it is caused in relation to a recall for the oil strainer that was done on this vehicle. I called audi dealership and they said this is not an open recall, however it seems this is exactly what caused it.
Driving up an inclined road at night. Car engine started to sputter and jerk and lost power. Was able to get to the side of the road out of traffic at the top of the hill? I was able to coast down the hill to a gas station. Carl would not drive without Jerking or accelerate, add check engine, light on and flashing. With the smel…
Read full complaint
Driving up an inclined road at night. Car engine started to sputter and jerk and lost power. Was able to get to the side of the road out of traffic at the top of the hill? I was able to coast down the hill to a gas station. Carl would not drive without Jerking or accelerate, add check engine, light on and flashing. With the smell of burning from the engine, compartment waited two hours for a tow truck towed it home, the following day, I had to take off of work. I checked all the spark plugs to find multiple spark plugs completely soaked in oil, took an Uber to parts store to buy new spark plugs. At this point I had found out about the recall for the same problem. On the same engine. In all of audi's cars, except for the A8 line was excluded, do not know the reason why it's the same engine in multiple vehicles that were listed in the recall for the piston rings. My other Audi a 6 has over 200000 miles and does not have this issue. Get these low tension piston ring failures that have been recalled. On the issue with all of audi's in this year
The contact owns a 2013 Audi A8. The contact stated that while her son was driving at highway speeds, the warning lights on the instrument panel flashed as the vehicle shut off. The contact's son managed to pull over despite the failure. The vehicle was initially towed to one dealer; however, the dealer failed to service the veh…
Read full complaint
The contact owns a 2013 Audi A8. The contact stated that while her son was driving at highway speeds, the warning lights on the instrument panel flashed as the vehicle shut off. The contact's son managed to pull over despite the failure. The vehicle was initially towed to one dealer; however, the dealer failed to service the vehicle promptly. The vehicle was then towed to a dealer where it was diagnosed with a defective ECM(Electronic Control Module) that needed to be replaced. The vehicle remained in the dealer's possession for a month before the vehicle was repaired. Despite the repair, the contact was notified that the failure persisted and was then informed that a defective engine cylinder now needed to be replaced. The manufacturer was notified of the failure but offered no assistance. The vehicle remained in the dealer's possession and had yet to be repaired. The failure mileage was approximately 120,000.
Audi, A8L 2013, also has the stuck piston. Rings end oil blow by like the other Volkswagen, defected engines of the same year yesterday while driving my car ended up stalling on a road with traffic behind me going up a hill because too much oil I'd burnt in the cylinders, causing the spark plugs to become completely coated in oi…
Read full complaint
Audi, A8L 2013, also has the stuck piston. Rings end oil blow by like the other Volkswagen, defected engines of the same year yesterday while driving my car ended up stalling on a road with traffic behind me going up a hill because too much oil I'd burnt in the cylinders, causing the spark plugs to become completely coated in oil and the cars. Electronic system registered multiple misfires, multiple cylinders. Are misfired and multiple other safety epc codes, causing the vehicle to not be able to drive more than 5 miles an hour, stuttering. Which also caused the engine to almost stall, losing power steering. If this was on the highway this could have been exceptionally bad. I request the Audi AH. L and 8 series to be added to the current recall. For the A6Q5A4 A seven with the exact same problem
Brake pedal is hard when starting the vehicle. Brake pedal turns soft when engine is started. The brake pedal is so hard that it requires significant force to depress sufficiently to start the engine. This indicates loss of vacuum in brake booster when engine is off. The vehicle is equipped with a start/stop system and it seems …
Read full complaint
Brake pedal is hard when starting the vehicle. Brake pedal turns soft when engine is started. The brake pedal is so hard that it requires significant force to depress sufficiently to start the engine. This indicates loss of vacuum in brake booster when engine is off. The vehicle is equipped with a start/stop system and it seems likely that the brakes would not sufficiently hold the vehicle when the start/stop system turns off the engine.
Unknown at this moment service vist is next week. The problem is a know piston ring issues on other years of same engine with massive oil consumption 1 qt a week with minimal driving less then 100 miles. Spent 3k on pvc and coolant pump that are a known issue of totaling engine but burning oil non stop and risk or seized engine …
Read full complaint
Unknown at this moment service vist is next week. The problem is a know piston ring issues on other years of same engine with massive oil consumption 1 qt a week with minimal driving less then 100 miles. Spent 3k on pvc and coolant pump that are a known issue of totaling engine but burning oil non stop and risk or seized engine if on highway
Me and my son were traveling on a business road trip from my home in Lincoln, CA to do business at several companies and end up at a customer located in Anaheim, CA. We started on [XXX] in Roseville, CA highway Interstate [XXX] traveling towards Anaheim with stops along the way. We were coming down [XXX] on the southside of …
Read full complaint
Me and my son were traveling on a business road trip from my home in Lincoln, CA to do business at several companies and end up at a customer located in Anaheim, CA. We started on [XXX] in Roseville, CA highway Interstate [XXX] traveling towards Anaheim with stops along the way. We were coming down [XXX] on the southside of the grapevine at the speed limit of 70 MPH, when the engine began to stall, and the steering also began to lock up. We began losing control of the vehicle and engine power was failing and stalling. In addition, the stall was impacting the car battery. We had difficulty steering the car and controlling the direction of the car and getting the car to the side of the road. Once we were at the side of the road, we looked up the closest Audi dealership, fortunately we were 3.9 miles away from Audi Dealership in Van Nuys, CA. Once on the side of the road the vehicle initially would not restart the engine stalling had drained the battery. We waited on the side of the road for approx.. 40 minutes and were able to restart the car and drive with much difficulty to the Keys Audi Van Nuys dealership. We were able to barely get into the dealership parking lot when the car completely stalled, we went in and met with the service manager. We explained what had happened, and with the service teams help we pushed the vehicle into a bay to get reviewed. I have purchased eight (8) Audi’s over the past years for me and my wife. The service manager promised to review the problem. Typically, Audi service will give you a vehicle to drive but the had no vehicles available, so they told us they would take us to a rental car company and cover the cost of the vehicle except for the insurance on rental car, which we had to pickup at a rate of $ 35.00 per day. As we were on a work trip we had to hustle to our customers as we had a meeting scheduled for 2:30 PM at Manna Beverage in Anaheim, CA. We went to our meeting and then returned to the Audi Dealership in Van Nuys. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I
Me and my son were traveling on a business road trip from my home in Lincoln, CA to do business at several companies and end up at a customer located in Anaheim, CA. We started on [XXX] traveling towards Anaheim with stops along the way. We were coming down highway [XXX] on the southside of the grapevine at the speed limit of …
Read full complaint
Me and my son were traveling on a business road trip from my home in Lincoln, CA to do business at several companies and end up at a customer located in Anaheim, CA. We started on [XXX] traveling towards Anaheim with stops along the way. We were coming down highway [XXX] on the southside of the grapevine at the speed limit of 70 MPH, when the engine began to stall, and the steering also began to lock up. We began losing control of the vehicle and engine power was failing and stalling. In addition, the stall was impacting the car battery. We had difficulty steering the car and controlling the direction of the car and getting the car to the side of the road. Once we were at the side of the road, we looked up the closest Audi dealership, fortunately we were 3.9 miles away from Audi Dealership in Van Nuys, CA. Once on the side of the road the vehicle initially would not restart the engine stalling had drained the battery. We waited on the side of the road for approx.. 40 minutes and were able to restart the car and drive with much difficulty to the Keys Audi Van Nuys dealership. We were able to barely get into the dealership parking lot when the car completely stalled, we went in and met with the service manager. We explained what had happened, and with the service teams help we pushed the vehicle into a bay to get reviewed. I have purchased eight (8) Audi’s over the past years for me and my wife. The service manager promised to review the problem. Typically, Audi service will give you a vehicle to drive but the had no vehicles available, so they told us they would take us to a rental car company and cover the cost of the vehicle except for the insurance on rental car, which we had to pickup at a rate of $ 35.00 per day. As we were on a work trip we had to hustle to our customers as we had a meeting scheduled for 2:30 PM at Manna Beverage in Anaheim, CA. We went to our meeting and then returned to the Audi Dealership in Van Nuys. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(
The contact owns a 2013 Audi A8. The contact received notification of NHTSA Campaign Number: 22V178000 (Engine and Engine Cooling) however, the contact had scheduled three separate appointments with a dealer and was cancelled after each scheduled appointment. The contact stated that the manufacturer had exceeded a reasonable amo…
Read full complaint
The contact owns a 2013 Audi A8. The contact received notification of NHTSA Campaign Number: 22V178000 (Engine and Engine Cooling) however, the contact had scheduled three separate appointments with a dealer and was cancelled after each scheduled appointment. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Official recalls
622V178000 · Engine And Engine Cooling:engine:gasoline:turbo/supercharger
Mar 23, 2022
Volkswagen Group of America, Inc. (Audi) is recalling certain 2013-2017 A8, S6 Sedan, S7, S8, and 2014-2017 RS7 vehicles. The turbocharger oil supply strainer can become blocked, causing wear to the bearings due to lack of lubrication.
Consequence & remedy
Consequence: Worn bearings can cause the turbine wheel to contact the turbocharger housing or cause the shaft to break, causing an engine stall and increasing the risk of a crash.
Remedy: Dealers will replace the oil strainer and perform an oil change, free of charge. Owner notification letters were mailed August 4, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 21H7.
20V397000 · Structure:body:hood
Jul 7, 2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2018 Audi S8 and A8 vehicles. The seal around the engine compartment may come loose and contact hot engine components.
Consequence & remedy
Consequence: If the seal contacts hot engine components, there could be an increased risk of a fire.
Remedy: Audi will notify owners, and dealers will install a retaining plate to prevent the engine compartment seal from loosening. The recall began September 4, 2020. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 51G6.
19V057000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Jan 28, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2016 Audi A8 and S8 vehicles. The fuel supply line for the high pressure fuel pump may become porous and leak fuel.
Consequence & remedy
Consequence: Leaking fuel, in the presence of an ignition source, increases the risk of fire.
Remedy: Audi has notified owners, and dealers will install a fuel pressure damper, free of charge. The recall began February 21, 2019. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BM.
18V430000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Jun 25, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2015 Audi S8 and A8 vehicles. The fuel supply line for the high pressure fuel pump may become porous over time, resulting in a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Audi will notify owners, and dealers will replace the fuel line, free of charge. The recall began July 20, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20AV.
16V619000 · Engine And Engine Cooling:engine
Aug 24, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2013 Audi A8 vehicles manufactured May 15, 2010, to May 14, 2012. The affected vehicles have a coolant valve that may leak, allowing coolant to enter the engine control module causing a loss of power or the engine to stall.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Audi will notify owners, and dealers will replace the coolant valve and inspect for coolant that has leaked through the electrical connector, free of charge. The recall is expected to begin October 19, 2016. Owners may contact Audi customer service at 1-800-253-2834.
13V448000 · Visibility:sun/moon Roof Assembly
Sep 23, 2013
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2013-2014 Audi A8 and S8 vehicles equipped with a standard sunroof, manufactured March 12, 2013, through July 15, 2013. These vehicles are equipped with a standard sunroof glass panel that may shatter.
Consequence & remedy
Consequence: Should the sunroof's glass break while the vehicle is in use, the falling glass could injure the driver or passengers. It could also distract the driver, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the sunroof glass panel, free of charge. The recall began on October 21, 2013. Owners may contact Audi of America at 1-800-822-2834. Volkwagen's number for this campaign is 60B6/1L.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA22001 · Engine Stall - Turbo Failure
Opened Apr 4, 2022 · Closed May 26, 2023
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:oil/lubrication:filter/screen
On March 29, 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE 21-009) after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7 equipped with the 4.0L, twin-turbocharged engine. Complainants reported the vehicles would stall with no warning while driving at highway or city traffic speeds. Several of the complainants alleged an inability to restart. The complaints alleged the major contributing factor to the engine stalling was the failure of the turbochargers. The complaints cited the turbocharger failure was a result of oil starvation due to a clogged oil strainer in the turbocharger oil supply line.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making servicing the component difficult. The oil strainer removes particles and carbon deposits from the oil before lubricating the turbochargers. Over time, if the debris is not removed from the oil strainer, it becomes clogged and prevents oil from flowing to the turbochargers. This causes the turbine bushings to run dry and overheat resulting in turbine shaft failure due to thermal stress.On April 04, 2022, PE21-009 was upgraded to an Engineering Analysis (EA22-001) to further assess the scope, frequency, and potential safety related consequences of the alleged defect. Volkswagen filed recall 22V-178 to replace the 30?m mesh oil strainer with a 90?m mesh oil strainer in the subject vehicles. VW introduced the larger mesh oil strainer into production in March of 2017 effecting the 2017-2018MY vehicles.ODI reviewed information from VW for vehicles that had the larger mesh installed in production. The data received showed, since the new oil strainer size of 90?m went into production for the 2017-2018MY, there has not been any reported incidents of turbocharger failures due to oil starvation or other failures that could be related to the larger screen mesh. In view of the recall being conducted by VW and lack of any detrimental side effect to the turbocharger caused by the larger mesh, ODI is closing this Engineering Analysis (EA). The agency reserves the right to take additional action if warranted by future circumstances.11502847,11506565,11494663,11488813,11486393,11480926,11479882,11476289,11466761 11464663,11463254,11460580,11460496,11458973,11458804,11457556,11454753,11452668 11452589,11452584,11452383,11452175,11452111,11451724,11451724,11450995,11450988 11449661,11447092,11443657,11442867,11440536,11440052,11439959,11438691,11436461 11435619,11433925,11433733,11432336,11431661,11431421,11429704,11429584,11428128 11426929,11424203,11423603,11423337,11422431,11421084,11420626,11420342,11419693 11418884,11418437,11418433,11418135,11417635,11417351,11416095,11414578,11414235 11414064,11413359,11413285,11413214,11407510,11407450,11406897,11406821,11406637 11406460,11406416,11406291,11406287,11406277,11406273,11406263,11406256,11406251 11406229,11406222,11406208,11406204,11406197,11406182,11406015,11404665,11404426 11404348,11403823,11403430,11403268,11402684,11399435,11397821,11396241,11394763 11391037
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
On March 29, 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE 21-009) after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7 equipped with the 4.0L, twin-turbocharged engine. Complainants reported the vehicles would stall with no warning while driving at highway or city traffic speeds. Several of the complainants alleged an inability to restart. The complaints alleged the major contributing factor to the engine stalling was the failure of the turbochargers. The complaints cited the turbocharger failure was a result of oil starvation due to a clogged oil strainer in the turbocharger oil supply line.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making servicing the component difficult. The oil strainer removes particles and carbon deposits from the oil before lubricating the turbochargers. Over time, if the debris is not removed from the oil strainer, it becomes clogged and prevents oil from flowing to the turbochargers. This causes the turbine bushings to run dry and overheat resulting in turbine shaft failure due to thermal stress.On April 04, 2022, PE21-009 was upgraded to an Engineering Analysis (EA22-001) to further assess the scope, frequency, and potential safety related consequences of the alleged defect. Volkswagen filed recall 22V-178 to replace the 30?m mesh oil strainer with a 90?m mesh oil strainer in the subject vehicles. VW introduced the larger mesh oil strainer into production in March of 2017 effecting the 2017-2018MY vehicles.ODI reviewed information from VW for vehicles that had the larger mesh installed in production. The data received showed, since the new oil strainer size of 90?m went into production for the 2017-2018MY, there has not been any reported incidents of turbocharger failures due to oil starvation or other failures that could be related to the larger screen mesh. In view of the recall being conducted by VW and lack of any detrimental side effect to the turbocharger caused by the larger mesh, ODI is closing this Engineering Analysis (EA). The agency reserves the right to take additional action if warranted by future circumstances.11502847,11506565,11494663,11488813,11486393,11480926,11479882,11476289,11466761 11464663,11463254,11460580,11460496,11458973,11458804,11457556,11454753,11452668 11452589,11452584,11452383,11452175,11452111,11451724,11451724,11450995,11450988 11449661,11447092,11443657,11442867,11440536,11440052,11439959,11438691,11436461 11435619,11433925,11433733,11432336,11431661,11431421,11429704,11429584,11428128 11426929,11424203,11423603,11423337,11422431,11421084,11420626,11420342,11419693 11418884,11418437,11418433,11418135,11417635,11417351,11416095,11414578,11414235 11414064,11413359,11413285,11413214,11407510,11407450,11406897,11406821,11406637 11406460,11406416,11406291,11406287,11406277,11406273,11406263,11406256,11406251 11406229,11406222,11406208,11406204,11406197,11406182,11406015,11404665,11404426 11404348,11403823,11403430,11403268,11402684,11399435,11397821,11396241,11394763 11391037
Engine And Engine Cooling:engine:oil/lubrication:filter/screen
On March 29, 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE 21-009) after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7 equipped with the 4.0L, twin-turbocharged engine. Complainants reported the vehicles would stall with no warning while driving at highway or city traffic speeds. Several of the complainants alleged an inability to restart. The complaints alleged the major contributing factor to the engine stalling was the failure of the turbochargers. The complaints cited the turbocharger failure was a result of oil starvation due to a clogged oil strainer in the turbocharger oil supply line.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making servicing the component difficult. The oil strainer removes particles and carbon deposits from the oil before lubricating the turbochargers. Over time, if the debris is not removed from the oil strainer, it becomes clogged and prevents oil from flowing to the turbochargers. This causes the turbine bushings to run dry and overheat resulting in turbine shaft failure due to thermal stress.On April 04, 2022, PE21-009 was upgraded to an Engineering Analysis (EA22-001) to further assess the scope, frequency, and potential safety related consequences of the alleged defect. Volkswagen filed recall 22V-178 to replace the 30?m mesh oil strainer with a 90?m mesh oil strainer in the subject vehicles. VW introduced the larger mesh oil strainer into production in March of 2017 effecting the 2017-2018MY vehicles.ODI reviewed information from VW for vehicles that had the larger mesh installed in production. The data received showed, since the new oil strainer size of 90?m went into production for the 2017-2018MY, there has not been any reported incidents of turbocharger failures due to oil starvation or other failures that could be related to the larger screen mesh. In view of the recall being conducted by VW and lack of any detrimental side effect to the turbocharger caused by the larger mesh, ODI is closing this Engineering Analysis (EA). The agency reserves the right to take additional action if warranted by future circumstances.11502847,11506565,11494663,11488813,11486393,11480926,11479882,11476289,11466761 11464663,11463254,11460580,11460496,11458973,11458804,11457556,11454753,11452668 11452589,11452584,11452383,11452175,11452111,11451724,11451724,11450995,11450988 11449661,11447092,11443657,11442867,11440536,11440052,11439959,11438691,11436461 11435619,11433925,11433733,11432336,11431661,11431421,11429704,11429584,11428128 11426929,11424203,11423603,11423337,11422431,11421084,11420626,11420342,11419693 11418884,11418437,11418433,11418135,11417635,11417351,11416095,11414578,11414235 11414064,11413359,11413285,11413214,11407510,11407450,11406897,11406821,11406637 11406460,11406416,11406291,11406287,11406277,11406273,11406263,11406256,11406251 11406229,11406222,11406208,11406204,11406197,11406182,11406015,11404665,11404426 11404348,11403823,11403430,11403268,11402684,11399435,11397821,11396241,11394763 11391037
PE21009 · Engine Stall - Turbo Failure
Opened Mar 29, 2021 · Closed May 27, 2022
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:oil/lubrication:filter/screen
On March 29, 2021, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 21-009 after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7. The subject vehicles are equipped with 4.0L, twin-turbocharged engine. Complainants reported that the vehicles stall suddenly with no warning while driving on the highway or in city traffic. Several of the complainants alleged an inability to restart. The complaints allege the major contributing factor to the engine stalling is the failure of the turbochargers. The complaints further allege the turbocharger failure is a result of oil starvation due to a clogged oil strainer.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making regular service difficult. The oil strainer removes dirty particles and carbon deposits from the oil before flowing to lubricate the Turbochargers. Overtime if the debris are not removed from the oil strainer, it clogs the strainer and prevents free flow of oil to the turbochargers and makes the turbine bushings to run dry and overheat which causes the turbine shaft to break due to thermal stress. In VW's response to ODI's Information Request letter, VW provided approximately 611 warranty claims with unique VINs, 70 Field Reports and 45 Consumer complaints. These reports allege engine stalling due to turbocharger failure similar to the NHTSA reports described above. To date, NHTSA has received approximately 98 allegations of stall due to turbocharger failures. The total of 824 reports shown in the table above eliminates duplicate reports received by both ODI and the manufacturer.This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA) to further assess the scope, frequency, and potential safety related consequences of the alleged defect of engine stalling due to turbocharger failureThe ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers:11452589, 11452584, 11452383, 11450995, 11450988, 11449661, 11447092, 11442867 11440536, 11440052, 11439959, 11438691, 11436461, 11435619, 11431661, 11429704 11429584, 11426929, 11424203, 11423603, 11423337, 11421084, 11420626, 11420342 11418884, 11418437, 11418433, 11417635, 11417351, 11416095, 11414235, 11413359 11413214, 11413285, 11413133, 11407510, 11407450, 11407289, 11406821, 11406416 11406291, 11406277, 11406273, 11406256, 11406251, 11406229, 11406222, 11406204 11406197, 11406182, 11404665, 11404426, 11404348, 11403430, 11403268, 11399435 11397821, 11396241, 11394763, 11391037, 11388662, 11387166, 11377446, 11363283 11354107, 11344193, 11342497, 11342360, 11340302, 11325065, 11324163, 11322168, 11321144, 11318477, 11306754, 11279429, 11268109, 11256706, 11252723, 11246579 11234853, 11234714, 11231582, 11231013, 11230589, 11229484, 11222281, 11218822 11218749, 11217604, 11209168, 11209142, 11197149, 11191243, 11175842, 11170776 11164032, 11152418.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
On March 29, 2021, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 21-009 after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7. The subject vehicles are equipped with 4.0L, twin-turbocharged engine. Complainants reported that the vehicles stall suddenly with no warning while driving on the highway or in city traffic. Several of the complainants alleged an inability to restart. The complaints allege the major contributing factor to the engine stalling is the failure of the turbochargers. The complaints further allege the turbocharger failure is a result of oil starvation due to a clogged oil strainer.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making regular service difficult. The oil strainer removes dirty particles and carbon deposits from the oil before flowing to lubricate the Turbochargers. Overtime if the debris are not removed from the oil strainer, it clogs the strainer and prevents free flow of oil to the turbochargers and makes the turbine bushings to run dry and overheat which causes the turbine shaft to break due to thermal stress. In VW's response to ODI's Information Request letter, VW provided approximately 611 warranty claims with unique VINs, 70 Field Reports and 45 Consumer complaints. These reports allege engine stalling due to turbocharger failure similar to the NHTSA reports described above. To date, NHTSA has received approximately 98 allegations of stall due to turbocharger failures. The total of 824 reports shown in the table above eliminates duplicate reports received by both ODI and the manufacturer.This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA) to further assess the scope, frequency, and potential safety related consequences of the alleged defect of engine stalling due to turbocharger failureThe ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers:11452589, 11452584, 11452383, 11450995, 11450988, 11449661, 11447092, 11442867 11440536, 11440052, 11439959, 11438691, 11436461, 11435619, 11431661, 11429704 11429584, 11426929, 11424203, 11423603, 11423337, 11421084, 11420626, 11420342 11418884, 11418437, 11418433, 11417635, 11417351, 11416095, 11414235, 11413359 11413214, 11413285, 11413133, 11407510, 11407450, 11407289, 11406821, 11406416 11406291, 11406277, 11406273, 11406256, 11406251, 11406229, 11406222, 11406204 11406197, 11406182, 11404665, 11404426, 11404348, 11403430, 11403268, 11399435 11397821, 11396241, 11394763, 11391037, 11388662, 11387166, 11377446, 11363283 11354107, 11344193, 11342497, 11342360, 11340302, 11325065, 11324163, 11322168, 11321144, 11318477, 11306754, 11279429, 11268109, 11256706, 11252723, 11246579 11234853, 11234714, 11231582, 11231013, 11230589, 11229484, 11222281, 11218822 11218749, 11217604, 11209168, 11209142, 11197149, 11191243, 11175842, 11170776 11164032, 11152418.
Engine And Engine Cooling:engine:oil/lubrication:filter/screen
On March 29, 2021, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 21-009 after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7. The subject vehicles are equipped with 4.0L, twin-turbocharged engine. Complainants reported that the vehicles stall suddenly with no warning while driving on the highway or in city traffic. Several of the complainants alleged an inability to restart. The complaints allege the major contributing factor to the engine stalling is the failure of the turbochargers. The complaints further allege the turbocharger failure is a result of oil starvation due to a clogged oil strainer.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making regular service difficult. The oil strainer removes dirty particles and carbon deposits from the oil before flowing to lubricate the Turbochargers. Overtime if the debris are not removed from the oil strainer, it clogs the strainer and prevents free flow of oil to the turbochargers and makes the turbine bushings to run dry and overheat which causes the turbine shaft to break due to thermal stress. In VW's response to ODI's Information Request letter, VW provided approximately 611 warranty claims with unique VINs, 70 Field Reports and 45 Consumer complaints. These reports allege engine stalling due to turbocharger failure similar to the NHTSA reports described above. To date, NHTSA has received approximately 98 allegations of stall due to turbocharger failures. The total of 824 reports shown in the table above eliminates duplicate reports received by both ODI and the manufacturer.This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA) to further assess the scope, frequency, and potential safety related consequences of the alleged defect of engine stalling due to turbocharger failureThe ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers:11452589, 11452584, 11452383, 11450995, 11450988, 11449661, 11447092, 11442867 11440536, 11440052, 11439959, 11438691, 11436461, 11435619, 11431661, 11429704 11429584, 11426929, 11424203, 11423603, 11423337, 11421084, 11420626, 11420342 11418884, 11418437, 11418433, 11417635, 11417351, 11416095, 11414235, 11413359 11413214, 11413285, 11413133, 11407510, 11407450, 11407289, 11406821, 11406416 11406291, 11406277, 11406273, 11406256, 11406251, 11406229, 11406222, 11406204 11406197, 11406182, 11404665, 11404426, 11404348, 11403430, 11403268, 11399435 11397821, 11396241, 11394763, 11391037, 11388662, 11387166, 11377446, 11363283 11354107, 11344193, 11342497, 11342360, 11340302, 11325065, 11324163, 11322168, 11321144, 11318477, 11306754, 11279429, 11268109, 11256706, 11252723, 11246579 11234853, 11234714, 11231582, 11231013, 11230589, 11229484, 11222281, 11218822 11218749, 11217604, 11209168, 11209142, 11197149, 11191243, 11175842, 11170776 11164032, 11152418.