SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2002 Audi A6

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2002 Audi A6 do not stand out strongly from the model-year median of 35.

About this comparison →
88Owner complaints

Model-year median: 35

4Recall campaigns

View recall details →

1Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
217
1999148
2000113
200188
200266
200335
200491
2005
Compare all A6 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Electrical System
15Engine And Engine Cooling
15Fuel System, Gasoline
10Power Train
10Service Brakes, Hydraulic
10
All reported categories
Air Bags
7Vehicle Speed Control
7Engine
5Fuel/propulsion System
5Structure
4Visibility
4Equipment
3Seat Belts
3Exterior Lighting
2Suspension
2Tires
2Unknown Or Other
2Child Seat
1Electronic Stability Control (esc)
1Service Brakes, Air
1Steering
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

62 reports with mileage · 26 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine And Engine Cooling. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports3 fire reports5 injury reports

Structure complaints

4 reports
Clear category filter
92,764 miles · Sep 13, 2010
Structure

TL* THE CONTACT OWNS A 2002 AUDI A6. THE VEHICLE WAS RECENTLY PURCHASED USED AND TAKEN TO A LOCAL REPAIR FACILITY FOR ROUTINE MAINTENANCE. THE MECHANIC ADVISED THE CONTACT THAT THE VEHICLE WAS PREVIOUSLY INVOLVED IN A CRASH AND THAT THE REAR CROSS MEMBER WAS FRACTURED AND HAD BEEN RE-WELDED IN FOUR DIFFERENT LOCATIONS. THE MECHA…

Read full complaint

TL* THE CONTACT OWNS A 2002 AUDI A6. THE VEHICLE WAS RECENTLY PURCHASED USED AND TAKEN TO A LOCAL REPAIR FACILITY FOR ROUTINE MAINTENANCE. THE MECHANIC ADVISED THE CONTACT THAT THE VEHICLE WAS PREVIOUSLY INVOLVED IN A CRASH AND THAT THE REAR CROSS MEMBER WAS FRACTURED AND HAD BEEN RE-WELDED IN FOUR DIFFERENT LOCATIONS. THE MECHANIC ALSO ADVISED THAT ONE OF THE FRACTURES WAS ONLY PARTIALLY WELDED AND THE VEHICLE WAS NOT SAFE TO DRIVE. THE MECHANIC STATED THAT IF THE WELD WAS TO FRACTURE AGAIN, IT WOULD POTENTIALLY CAUSE A CRASH AND THE CONTACT WOULD NOT BE ABLE TO MAINTAIN CONTROL OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED AND LEFT WITH THE DEALER. THE FAILURE AND CURRENT MILEAGE WAS 92,764.

NHTSA ODI #10355231

Mileage unknown · Jun 18, 2009
StructureUnknown Or Other

2002 AUDI A6 HAS A PROBLEM WITH INTERIOR FLOODING DUE TO RAINY WEATHER AND IT CAUSES THE TRANSMISSION MODULE TO SHORT OUT. *NJ THE CONSUMER STATED DURING HEAVY RAIN, THE WATER FROM THE WINDSHIELD RUNOFF DOES NOT DRAIN FAST ENOUGH THROUGH THE DRAIN HOLE, WHICH IS LOCATED UNDER THE BATTERY. THE DRAIN IS WELL HIDDEN AND CAN NOT …

Read full complaint

2002 AUDI A6 HAS A PROBLEM WITH INTERIOR FLOODING DUE TO RAINY WEATHER AND IT CAUSES THE TRANSMISSION MODULE TO SHORT OUT. *NJ THE CONSUMER STATED DURING HEAVY RAIN, THE WATER FROM THE WINDSHIELD RUNOFF DOES NOT DRAIN FAST ENOUGH THROUGH THE DRAIN HOLE, WHICH IS LOCATED UNDER THE BATTERY. THE DRAIN IS WELL HIDDEN AND CAN NOT BE INSPECTED VISUALLY OR CLEANED EASILY. THE WATER BACKS UP INTO THE PASSENGER COMPARTMENT THROUGH THE FRESH AIR INTAKE. THE TRANSMISSION MODULE WHICH IS LOCATED DIRECTLY UNDER THE PASSENGERS FEET HAD TO BE REPLACED TWICE, BECAUSE OF THE FLOODING PROBLEM. THE MECHANIC STATED HE TOOK OUT THE RUBBER GROMMET FROM THE DRAIN THEREFORE MAKING THE DRAIN OPENING MUCH LARGER TO ALLEVIATE ANY FUTURE PROBLEM. *JB

NHTSA ODI #10274514

62,000 miles · Mar 15, 2008
Electrical SystemStructure

DRIVING FROM NJ TO UPSTATE NY FOR SKI TRIP TO HUNTER MOUNTAIN. HEAVY RAIN DURING DRIVE UP ON FRIDAY EVENING, RAIN ALL DAY SATURDAY. GOT IN THE CAR TO GO SKIING ON SUNDAY MORNING AND NOTICED SEVERAL INCHES OF WATER IN REAR PASSENGER FOOTWELL. I WAS ABLE TO BALE OUT SOME OF THE WATER BUT INTERIOR CARPETING WAS SOAKED. WHILE GO…

Read full complaint

DRIVING FROM NJ TO UPSTATE NY FOR SKI TRIP TO HUNTER MOUNTAIN. HEAVY RAIN DURING DRIVE UP ON FRIDAY EVENING, RAIN ALL DAY SATURDAY. GOT IN THE CAR TO GO SKIING ON SUNDAY MORNING AND NOTICED SEVERAL INCHES OF WATER IN REAR PASSENGER FOOTWELL. I WAS ABLE TO BALE OUT SOME OF THE WATER BUT INTERIOR CARPETING WAS SOAKED. WHILE GOING TO HUNTER, WATER WAS SLOSHING BETWEEN PASSENGER FOOTWELL AND REAR. AFTER DROPPING OFF THE SKIERS I DECIDED TO HEAD HOME ON THE NY STATE THRUWAY. AFTER APPROX 50 MILES - DIGITAL DASH DISPLAY DISAPPEARED, CAR STARTED TO JERK AROUND AND BUCK. SPEED WAS DROPPED DOWN TO 20 MPH, I WAS ABLE TO MAKE IT TO A REST STOP. ANYWAY - REMAINDER OF SKI PARTY PICKED ME UP AND I HAD THE CAR TOWED BACK TO NJ - $700. MECHANIC STATES THAT TCU UNIT WAS UNDER WATER. RAIN WATER APPARENTLY CAME IN THROUGH THE POLLEN FILTER HOUSING AND FLOODED THE CAR. TOTAL DAMAGE TO THE CAR $2300. THERE ARE A NUMBER OF COMPLAINTS THROUGHOUT THE INTERNET AND VARIOUS FORUMS DETAILING THIS EXACT PROBLEM. I BELIEVE THIS IS A DESIGN FLAW AND AUDI SHOULD BE HELD RESPONSIBLE FOR THIS PROBLEM. I'D LIKE TO GET REIMBURSED FOR MY COST. INDIVIDUALS WITH THIS PROBLEM SHOULD CONTACT AUDI CUSTOMER SERVICE AT 800-822-2834. *TR

NHTSA ODI #10221267

55,000 miles · Aug 27, 2006
EquipmentStructure

ON AROUND MAY 28TH 2006- UPON RETURN FROM WORK THAT EVENING, THE FLOOR OF MY CAR WAS FLOODED- I WAS IN TOTAL SHOCK. I WAS ABOUT TO GO ON VACATION, I DRIED ALL THE FLOOR AND AIRED IT OUT ETC. UPON MY RETURN FROM VACATION, IT WAS WORSE THAN EVER- THE FLOOR WAS AGAIN SOAKED, IT IN TURN HAD DAMAGED THE COMPUTER SYSTEM IN MY CAR AND…

Read full complaint

ON AROUND MAY 28TH 2006- UPON RETURN FROM WORK THAT EVENING, THE FLOOR OF MY CAR WAS FLOODED- I WAS IN TOTAL SHOCK. I WAS ABOUT TO GO ON VACATION, I DRIED ALL THE FLOOR AND AIRED IT OUT ETC. UPON MY RETURN FROM VACATION, IT WAS WORSE THAN EVER- THE FLOOR WAS AGAIN SOAKED, IT IN TURN HAD DAMAGED THE COMPUTER SYSTEM IN MY CAR AND THAT IN TURN HAD CAUSED THE BATTERY TO DRAIN. I HAD IT TOWED TO MY MECHANICS SHOP- THE FOLLOWING HAPPENED, THE ENGINE SEIZED AS A RESULT OF ALL THE WATER THAT MADE ITS WAY INTO THE CAR, AND COMPUTER SYSTEM TOTALLY DESTROYED. THEY DRAINED AT LEAST 15 GALLONS OF WATER FROM THE CAR. THIS IS INCREDIBLE AND UNBELIEVABLE. THE MECHANIC SAID THE CAR WAS CLOGGED AND EVEN HE HAD A HARD TIME ACCESSING, AND I AS OWNER HAD NO WAY OF FINDING OUT. I BOUGHT THE CAR IN 05, IT IS AN A6 3.0 YEAR 2002. WITH AROUND 54 THOUSAND MILES UP, AND I HAD ONLY PUT 1000 MILES UP ON THE CAR. THE WARRANTY - EXTENDED, SAID IN TURN THE CAR IS NOT COVERED DUE TO MOTOR DAMAGE, AND A NEW ENGINE WOULD COST $8700 NOT TO MENTION THE MECHANIC FEES. UPON FURTHER INVESTIGATION ONLINE, I SEE THAT THERE ARE SEVERAL REPORTS OF THIS PROBLEM WITH THIS YEAR AUDI AND OTHER YEARS AND VW PASSATS ALSO. I PAID NEARLY $26000 FOR THIS CAR AND FEEL I HAVE BEEN SCAMED BY AUDI, MAJOR AUTOMOTIVE WHO SOLD ME THE CAR AND THE GM PROTECTION PLAN WHO PROVIDES THE EXTENDED WARRANTY, - THE SALES PERSON ADVISED IT WAS BUMPER TO BUMPER COVERAGE- I NOW FIND OUT THAT I HAVE TO PAY FOR MY NEW ENGINE?? I FEEL ALL PARTIES SHOULD BE HELD RESPONSIBLE AND WANT TO KNOW IF ANYONES IS FILING A CLASS ACTION LAW OR DOING ANYTHING ABOUT THIS, WHERE IS THE PROTECTION FOR THE CONSUMER, PLEASE HELP ME, I AM NOT RICH, I SPENT ALL MY SAVINGS FOR THIS CAR, I AM CURRENTLY PAYING INSURANCE AND ALSO CAR PAYMENTS ON THIS CAR, I CANT AFFORD A NEW ENGINE, EVEN IF I COULD IS THE SAME PROBLEM GOING TO ARISE AGAIN. PLEASE HELP ME. THANK YOU, E. MORRISSEY (THERE IS NOT A SELECTION FOR AUDI UNDER VEHICLE. *JB

NHTSA ODI #10166643

Official recalls

4

11V267000 · Fuel System, Other:storage:tank Assembly

May 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.

Consequence & remedy

Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.

Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.

08V157000 · Fuel System, Gasoline:storage:tank Assembly

Apr 8, 2008

VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.

Consequence & remedy

Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.

Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.

06V198000 · Electrical System

Jun 5, 2006

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.

Consequence & remedy

Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.

Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.

04V133000 · Electrical System

Mar 18, 2004

ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.

Consequence & remedy

Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.

Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE08008 · Fuel Tank Leak

Opened Jan 31, 2008 · Closed May 30, 2008

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices

VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.

Additional source detail variants (4)

Fuel System, Gasoline:storage:tank Assembly

VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.

Fuel System, Gasoline:storage:tank Assembly

VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.

Fuel System, Other:storage:tank Assembly:pressure Relief Devices

VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.

Fuel System, Other:storage:tank Assembly:pressure Relief Devices

VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.