IllustrationTRANSMISSION FAILURE WHILE DRIVING ON FREEWAY. FOURTH TIME IN 3 YEARS. EACH TIME THE TRANSMISSION WAS REPLACED. AUDI REFUSES TO ACKNOWLEDGE THE FAILURE OF THE CVT TRANSMISSION ON THAT MODEL. IT IS A DANGER TO PUBLIC SAFETY. *TR
2002 Audi A6
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Audi A6 do not stand out strongly from the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
110–25K
825–50K
1450–75K
1575–100K
12100–150K
2150K+
62 reports with mileage · 26 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports5 injury reports
Power Train complaints
10 reportsTL* THE CONTACT OWNS A 2002 AUDI A6. WHILE DRIVING APPROXIMATELY 25 MPH THE VEHICLE BEGAN TO HESITATE WHILE ACCELERATING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC. THE TECHNICIAN STATED THE TRANSMISSION CLUTCH PLATE WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 55,700.
APPARENTLY AUDI HAVE KNOWN FOR AGES THAT THE CVT CLUTCH HAS NEEDED UPGRADING ON THIS ENGINE, BUT HASN'T RECALLED THE CARS. WE OWN A 2002 AUDI A6 (3.0 ENGINE & MULTITRONIC CVT). *TR
OWN 2002 AUDI A6 3.0 LITER SEDAN. MODULE(COMPUTER) REPLACED AND COMPLAINED OF TRANSMISSION NOT WORKING PROPERLY. BROUGHT AUTO BACK TO DEALER AND AFTER CHECKING THE TRANSMISSION FOUND NOTHING WRONG. TRANSMISSION STILL NOT WORKING PROPERLY. WHEN PUT IN DRIVE AUTO DOESN'T MOVE FORWARD. HAVE TO PLAY AROUND WITH LEVER FROM REVERSE T…
Read full complaint
OWN 2002 AUDI A6 3.0 LITER SEDAN. MODULE(COMPUTER) REPLACED AND COMPLAINED OF TRANSMISSION NOT WORKING PROPERLY. BROUGHT AUTO BACK TO DEALER AND AFTER CHECKING THE TRANSMISSION FOUND NOTHING WRONG. TRANSMISSION STILL NOT WORKING PROPERLY. WHEN PUT IN DRIVE AUTO DOESN'T MOVE FORWARD. HAVE TO PLAY AROUND WITH LEVER FROM REVERSE TO DRIVE TO ENGAGE THE TRANSMISSION. WHEN IT MOVES FORWARD IT LUNGES NOT SMOOTHLY. NOT SAFE DRIVING. *TR
WATER FROM AIR CONITIONING SYSTEM LEAKED INTO PASSENGER COMPARTMENT AND FLOODED AND DISABLED TRANSMISSION CONTROL MODULE. TRANSMISSION WENT INTO "LIMP MODE,' ALLOWING VEHICLE TO ONLY OPERATE IN 4TH GEAR. *TR
I HAVE PURCHASED A 2002 AUDI A6 2.7T FROM SUNNYSIDE IN MIDDLEBURG HTS OHIO. THE CAR HAD A VIBRATION FELT IN THE STEERING WHEEL AND FLOORBOARD WITH OEM WHEELS AND TIRES. WENT BACK AND FORTH TO THIS SPECIFIC DEALER WITH NO RESULTS. OTHER AREA DEALER, FRED BAKER WAS ABLE TO ALLEVIATE THE PROBLEM, BUT I ASKED IF PURCHASING NEW WH…
Read full complaint
I HAVE PURCHASED A 2002 AUDI A6 2.7T FROM SUNNYSIDE IN MIDDLEBURG HTS OHIO. THE CAR HAD A VIBRATION FELT IN THE STEERING WHEEL AND FLOORBOARD WITH OEM WHEELS AND TIRES. WENT BACK AND FORTH TO THIS SPECIFIC DEALER WITH NO RESULTS. OTHER AREA DEALER, FRED BAKER WAS ABLE TO ALLEVIATE THE PROBLEM, BUT I ASKED IF PURCHASING NEW WHEELS AND TIRES WOULD FIX MY PROBLEM. I WAS TOLD YES, AS LONG AS I GET WHEEL AND TIRES WITH MANUFACTURER'S SPECS. PURCHASED NEW WHEELS AND TIRES WITH THE FOLLOWING SPECS: 5X112MM BOLT PATTERN, WHEEL BORE TO FIT HUB BORE OF 57.1MM WITH HUBCENTRIC RING. THE OFFSET OF THE TIRE IS 35MM (SAME AS OEM TIRE) AND THE VIBRATION BECAME WORSE. THIS IS AT HIGHWAY SPEEDS. DEALER TECH MANAGER DID NOT EVEN INSPECT THE VEHICLE, EVEN UNDER WARRANTY, JUST BLAMED THE WHEELS AND TIRES. CONTACTED THE WHEEL SELLER, EDGERACING IN FLORIDA AND WAS TOLD THEY BUILD WHEELS FOR AUDI AND VW TO SPECS AND NEVER HAD ANY PROBLEMS BEFORE. DEALER TECH MANAGER ASKED ME HOW I WANT TO PROBLEM FIXED. MANUFACTURER'S MANUAL DOES NOT SAY THAT I SHOULD NOT BE UPGRADING MY CAR'S WHEEL TO MORE THAN SPECS. MY TIRE RATIO AND OFFSET REMAINED TO MANUFACTURER'S SPECS, AND I DO NOT FEEL THAT MY CAR IS SAFE WHEN DRIVING ON THE HIGHWAY. I DO NOT HAVE THE MONETARY RESOURCES TO INSPECT THE CAR TO SEE IF IT WAS EVER INVOLVED INTO AN ACCIDENT AND NEVER REPORTED TO CARFAX. I HAVE BEEN DRIVING FOR 12 YEARS AND I CAN DIFFERENTIATE BETWEEN ROUGH DRIVING DUE TO LOWER PROFILE TIRES (PIRELLI PZERO NERO M/S 235/40/18) AND STEERING WHEEL VIBRATION AND FLOOR BOARD VIBRATION DUE TO SOME MECHANICAL PROBLEM THAT DEALER WILL EITHER NOT DISCLOSE OR ARE TRYING TO HIDE. THEY DID DROP THE SALES PRICE FROM 26,995 TO 23,250 WHEN I PURCHASED THE CAR FROM THEM. THE CAR IS STILL UNDER WARRANTY AND I HAVE CONTACTED THE AUTO MANUFACTURER IN GERMANY TO INFORM THEM OF THE POTENTIAL SAFETY ISSUE. PLEASE ADVISE ME HOW TO HANDLE THIS SITUATION, I FEEL THAT THE CAR HAS A MECHANICAL PROBLEM THAT THE DEALER IS TRYING TO HIDE. *NM
WHENEVER I ATTEMPT TO ACCELERATE IMMEDIATELY AFTER USING THE BRAKES, NOTHING HAPPENS. THE CAR'S THROTTLE APPEARS TO HAVE NO EFFECT FOR 2+ SECONDS, EVEN WHEN PRESSED ALL THE WAY TO THE FLOOR. ON SEVERAL SEPARATE OCCAISIONS, WHILE TRYING TO MERGE INTO TRAFFIC, I HAVE NEARLY BEEN HIT BY AN ONCOMING VEHICLE WHILE WAITING FOR MY CAR…
Read full complaint
WHENEVER I ATTEMPT TO ACCELERATE IMMEDIATELY AFTER USING THE BRAKES, NOTHING HAPPENS. THE CAR'S THROTTLE APPEARS TO HAVE NO EFFECT FOR 2+ SECONDS, EVEN WHEN PRESSED ALL THE WAY TO THE FLOOR. ON SEVERAL SEPARATE OCCAISIONS, WHILE TRYING TO MERGE INTO TRAFFIC, I HAVE NEARLY BEEN HIT BY AN ONCOMING VEHICLE WHILE WAITING FOR MY CAR TO UNDERSTAND THAT I INTENDED TO ACCELERATE. THIS IS NOT TURBO LAG; IT IS COMPUTER-INDUCED THROTTLE LAG. (THE ENGINE RPMS DO NOT CHANGE DURING THESE OCCURRENCES.) THIS IS A CLEAR SAFETY ISSUE THAT AUDI MUST ADDRESS. (A REPRESENTATIVE OF MY DEALERSHIP TOLD ME HE IS QUITE AWARE OF THE PROBLEM AND HAS PERSONALLY EXPERIENCED IT. BUT AUDI INFORMED HIM IT DOES NOT SEE THIS AS A PROBLEM.) *AK
THE VEHICLE JERKED HEAVILY, WHILE DRIVING.*JB
2002 AUDI A6 AVANTE WAGON AUTOMATIC TRANSMISSION - THERE IS A SIGNIFICANT"HESITATION" ON ACCELERATION SUCH THAT THE CAR DOES NOT INITIALLY RESPOND WHEN THE ACCELERATOR IS DEPRESSED BUT DOES SO SUDDENLY A SHORT TIME RESLTING IN A HESITATION. I CONSIDER THIS TO BE A SIGNIFICANT SAFETY CONCERN SINCE THE ACCELERATION OF THE CAR IS …
Read full complaint
2002 AUDI A6 AVANTE WAGON AUTOMATIC TRANSMISSION - THERE IS A SIGNIFICANT"HESITATION" ON ACCELERATION SUCH THAT THE CAR DOES NOT INITIALLY RESPOND WHEN THE ACCELERATOR IS DEPRESSED BUT DOES SO SUDDENLY A SHORT TIME RESLTING IN A HESITATION. I CONSIDER THIS TO BE A SIGNIFICANT SAFETY CONCERN SINCE THE ACCELERATION OF THE CAR IS UNPREDICTABLE. THE CAR HAS BEEN TAKEN TO TWO DEALERS TO DEAL WITH THIS PROBLEM, BOTH REPORTING THAT THIS IS NORMAL FOR THE "FLY-BY-THE-WIRE" SYSTEMS WHICH IS USED IN THE CAR AND THAT THERE IS NO ADJUSTMENT OR CORRECTION FOR THIS. I FIND IT TO BE OF CONCERN AND A SAFGETY ISSUE THAT AAUDI SHOULD DEAL WITH BEFORE THERE IS A SERIOUS ACCIDENT.
VEHICLE SHIFTS FROM AUTOMATIC MODE TO MANUAL MODE INADVERTENTLY. THE VEHICLE WAS TAKEN TO THE DEALERSHIP. PLEASE DESCRIBE DETAILS. *MR
Official recalls
411V267000 · Fuel System, Other:storage:tank Assembly
May 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
08V157000 · Fuel System, Gasoline:storage:tank Assembly
Apr 8, 2008
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
06V198000 · Electrical System
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
04V133000 · Electrical System
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.