NHTSA owner reports · September 18, 2026 snapshot.
Seat Belts complaints
10 reportsClear category filterMileage unknown · Oct 8, 2024
Fuel/propulsion SystemSeat Belts
Dear NHTSA, I am filing a complaint about the handling of a recall repair on my 2015 Audi A3 (VIN: [XXX] ) for the suction jet pump. The service experience has been frustrating and raises concerns about the repair’s quality. 1.First Visit - Inadequate Information: During my first visit to the service center, over an hour away,…
Read full complaint
Dear NHTSA, I am filing a complaint about the handling of a recall repair on my 2015 Audi A3 (VIN: [XXX] ) for the suction jet pump. The service experience has been frustrating and raises concerns about the repair’s quality. 1.First Visit - Inadequate Information: During my first visit to the service center, over an hour away, I was turned away because my fuel level was too high. I was never informed that my gas tank needed to be below a certain level for the repair, resulting in wasted time and travel. 2.Second Visit - Check Engine Light Still On: On my second visit, the suction jet pump was supposedly repaired, but my check engine light remained on. I had informed the service advisor that the light was related to an EVAP system malfunction, which I was told could be caused by a faulty suction jet pump. After speaking with multiple mechanics, I learned that a malfunctioning suction jet pump could cause fuel to enter the EVAP system, damaging parts like the purge valve or charcoal canister. 3.Unreasonable Charges: The service advisor insisted that the remaining EVAP issues were unrelated to the recall and wanted to charge $220 for another diagnostic and repairs, without even inspecting the car after the recall service. This seems unfair, as there’s no way to confirm without a proper check. 4.Missing Seat Belt Buckle: After the recall service, I discovered that the rear driver’s side seat belt buckle was missing. This is a major safety concern and needs to be addressed. I request NHTSA’s help in investigating the repair quality and ensuring these issues are resolved fairly. Thank you for your attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11618702
48,500 miles · Jul 8, 2021
Air BagsSeat Belts
The contact owns a 2016 Audi A3. The contact received a recall notification for NHTSA Campaign Number: 21V198000 (Air Bags) however, the dealer informed the contact that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. T…
Read full complaint
The contact owns a 2016 Audi A3. The contact received a recall notification for NHTSA Campaign Number: 21V198000 (Air Bags) however, the dealer informed the contact that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and confirmed that the remedy was not yet available. The contact stated that the air bag and the seat belt warning lights were illuminated. The approximate failure mileage was 48,500. Vin tool confirms parts not available.
NHTSA ODI #11423917
Mileage unknown · Apr 30, 2021
Air BagsSeat BeltsSeats
AUDI RECALL #69Z4, NHTSA RECALL #19V474 THE CAR WAS UNDER A PREVIOUS RECALL FOR THE SAME PROBLEM, WHICH WAS 'FIXED' BY DEALER SOMETIME IN 2019. CURRENTLY THE CAR SHOWS AIRBAG IS DEACTIVATED, THE UNBUCKLED SEATBELT WARNING LIGHTS AND SOUNDS FLASHES EVEN WHEN THE SEAT IS UNOCCUPIED. SPOKE THE AUDI OF ONTARIO,CA ON SEVERAL OCCASIO…
Read full complaint
AUDI RECALL #69Z4, NHTSA RECALL #19V474 THE CAR WAS UNDER A PREVIOUS RECALL FOR THE SAME PROBLEM, WHICH WAS 'FIXED' BY DEALER SOMETIME IN 2019. CURRENTLY THE CAR SHOWS AIRBAG IS DEACTIVATED, THE UNBUCKLED SEATBELT WARNING LIGHTS AND SOUNDS FLASHES EVEN WHEN THE SEAT IS UNOCCUPIED. SPOKE THE AUDI OF ONTARIO,CA ON SEVERAL OCCASIONS. THEY REFUSE TO FIX THE VEHICLE. SERVICE MANAGER WILL NOT RETURN PHONE CALLS. THIS IS THE SECOND TIME THIS COMPONENT HAD TO BE REPLACED, AND THE DEALER IS REFUSING TO REPAIR IT. THE PASSENGER AIRBAG OFF LIGHT STAYS ON, WHEN THE SEAT IS UNOCCUPIED, THIS HAPPENS AS SOON AS THE VEHICLE IS STARTED. THE UNFASTENED SEATBELT LIGHT, AND AIRBAG LIGHT REMAIN ON WHILE DRIVING. UNFASTENED SEATBELT SOUNDS CONTINUE FOR 2-3 MINUTES AFTER THE CAR IS STARTED, THEN GOES AWAY.
NHTSA ODI #11414669
42,000 miles · Oct 28, 2020
Air BagsElectrical SystemSeat Belts
CAR RECEIVED PODS RECALL FIX CODED 69Z4 IN JANUARY 2020. THE FIX DID NOT SOLVE THE ANNOYING AND LIFE THREATENING MALFUNCTIONION THAT LEADS TO AUDI PRESENSE FAILURE ALERT AND DEACTIVATION OF THE PASSENGER AIRBAG SYSTEM WHEN A PASSENGER IS SEATED. IT WOULD ALSO TRIGGER THE ERROR WHEN NO PASSENGER WAS SEATED, REQUIRING TO FASTEN TH…
Read full complaint
CAR RECEIVED PODS RECALL FIX CODED 69Z4 IN JANUARY 2020. THE FIX DID NOT SOLVE THE ANNOYING AND LIFE THREATENING MALFUNCTIONION THAT LEADS TO AUDI PRESENSE FAILURE ALERT AND DEACTIVATION OF THE PASSENGER AIRBAG SYSTEM WHEN A PASSENGER IS SEATED. IT WOULD ALSO TRIGGER THE ERROR WHEN NO PASSENGER WAS SEATED, REQUIRING TO FASTEN THE SEATBELT TO AN EMPTY SEAT TO GET RID OF THE SEATBELT BEEPS. CAR WAS TAKEN IN TO AUDI DEALERSHIP OCTOBER AND AFTER AN INSPECTION, THE ISSUE WAS FOUND TO BE THE SENSOR ITSELF THIS TIME. THE DIAGNOSIS REPORT DILIGENTLY RULED OUT ANY PROBLEM WITH THE CONNECTOR AND WIRING WHOSE FAULT WOULD MEAN A POTENTIAL REPAIR AND THE INSPECTION WOULD BE AT NO COST TO OWNER. HOWEVER, LIKE EVERYONE ELSE'S COMPLAINTS OWNER WAS PRESENTED WITH A 1,500 DOLLAR QUOTE FOR REPLACING THE SENSOR + $250 FEE FOR USING THEIR VAGCOM ("INSPECTION"). THE ERROR CODE WAS B12251B (MAT RESISTANCE TOO HIGH). AUDI'S INTERNAL DOCUMENTS ACCESSED THROUGH NHTSA REPORT THAT "IF FAULT, 'B12251B: SEAT OCCUPIED RECOGNITION SENSOR MAT RESISTANCE TOO HIGH' IS STORED IN THE AIRBAG CONTROL MODULE, DO NOT DIAGNOSE OR REPLACE ANY COMPONENTS FOR THIS FAULT BEFORE PERFORMING THIS REPAIR. THE 69Z4 TOPIC IS NOT THE ONLY CAUSE OF THIS FAULT. ANY DIAGNOSIS RELATED TO THIS FAULT WILL NOT BE COVERED UNDER THIS CAMPAIGN." AUDI OPENLY ADMITS THAT THE SCOPE OF THE 69Z4 RECALL AND THE SENSOR ISSUE ARE LINKED TOGETHER BY VIRTUE OF HAVING SIMILAR BEHAVIORS FOR THE CAR SYSTEMS AS WELL AS FAULT CODES. HOWEVER AUDI PERFORMS THE CHEAPER BANDAID OUT OF POCKET AND EXPECTS THE OWNER TO PAY FOR THE FAULTY PART WHICH SHOULD HAVE BEEN PART OF THE RECALL IN THE FIRST PLACE. THIS MANY COMPLAINTS ABOUT THE SAME BEHAVIOUR AND SAME PART (THAT IS TRADITIONALLY NOT YOUR USUAL WEAR&AND&TEAR PART LIKE A BATTERY) WARRANT AN INVESTIGATION OF THE MALPRACTICES OF AUDI IN DEALING WITH THIS RECALL AND ITS CUSTOMERS.
NHTSA ODI #11366863
88,000 miles · Sep 28, 2020
Air BagsSeat BeltsSeats
WHILE DRIVING THE CAR ON A CITY STREET, THE SEAT BELT WARNING LIGHT CAME ON, A WARNING CAME ON INDICATING THAT THE PASSENGER AIRBAG WAS DISCONNECTED, FOLLOWED BY AN AUDIBLE WARNING. THERE WAS AN ADULT PASSENGER IN THE PASSENGER SEAT WHO WAS PROPERLY BELTED IN. RECALL "FIX" 69Z4 HAS BEEN APPLIED TO THE VEHICLE.
NHTSA ODI #11361543
Mileage unknown · Aug 10, 2020
Electronic Stability Control (esc)Seat BeltsSteering
CAT FEELS UNSTABLE WHEN I DRIVE OVER 70 MILES ON THE FREEWAY.. ALSO SEATBELTS LOCK ROOM HARD
NHTSA ODI #11344257
58,000 miles · Jun 28, 2020
Air BagsSeat Belts
PASSENGER AIRBAG DOES NOT TURN ON. WARNING LIGHT IS DISPLAYED AND ERROR SAFETY MESSAGE IS ON SCREEN WHEN CARE IS TURNED ON AND OPERATING. ADDITIONALLY SEATBELT ALARM CONTINUES TO CHIME WHILE SEATBELT IS USED.
NHTSA ODI #11331322
80,000 miles · Apr 22, 2020
Air BagsElectrical SystemSeat Belts
AUDI RECALL CAMPAIGN 69Z4 WAS SUPPOSED TO FIX THE PASSENGER OCCUPANT DETECTION SYSTEM MALFUNCTION BY REPLACING A CONNECTOR AND HARNESS. THIS HAS NOT FIXED THE ISSUES. MANY AUDI CUSTOMERS SAYING THE SEAT BELT ALARM AND WARNING LIGHT STILL COME ON. MINE WILL NOT SHUT OFF UNTIL I PLUG THE SEAT BELT BACK IN, BUT THEN MY AIRBAGS TURN…
Read full complaint
AUDI RECALL CAMPAIGN 69Z4 WAS SUPPOSED TO FIX THE PASSENGER OCCUPANT DETECTION SYSTEM MALFUNCTION BY REPLACING A CONNECTOR AND HARNESS. THIS HAS NOT FIXED THE ISSUES. MANY AUDI CUSTOMERS SAYING THE SEAT BELT ALARM AND WARNING LIGHT STILL COME ON. MINE WILL NOT SHUT OFF UNTIL I PLUG THE SEAT BELT BACK IN, BUT THEN MY AIRBAGS TURN ON AND OFF RANDOMLY EVEN IF THERE IS AN OCCUPANT IN THE PASSENGER SEAT. THIS WAS THE CHEAP FIX. AUDI ACKNOWLEDGES THE ISSUE WITH THE ACTUAL PODS SENSOR BUT MAKES CUSTOMERS PAY $1,200 FOR THE SAFETY FIX. THIS SHOULD HAVE BEEN PART OF THE RECALL. AUDI BLAMES MINE ON THE DAMAGE TO THE REAR OF THE CAR, BUT THE PHOTOS PRE-DATE THE DAMAGE TO THE REAR BUMPER.
NHTSA ODI #11321938
36,000 miles · Mar 22, 2020
Air BagsSeat BeltsSeats
MY CAR KEEPS HAVING A SAFETY SYSTEM FAULT. THERE ARE TWO ERRORS: 1. THE "PAASENGER AIRBAG OFF" INDICATOR STAYS ON EVEN WHEN A PASSENGER IS IN THE FRONT PASSENGER SEAT 2. BUCKLE SEATBELT SIGN IS ON WHEN THERE IS NO PASSENGER I TOOK MY CAR FOR A RECALL BUT IT DID NOT FIX THE ISSUE OF THE AIRBAG BEING OFF! THIS HAS BEEN HAPPEN…
Read full complaint
MY CAR KEEPS HAVING A SAFETY SYSTEM FAULT. THERE ARE TWO ERRORS: 1. THE "PAASENGER AIRBAG OFF" INDICATOR STAYS ON EVEN WHEN A PASSENGER IS IN THE FRONT PASSENGER SEAT 2. BUCKLE SEATBELT SIGN IS ON WHEN THERE IS NO PASSENGER I TOOK MY CAR FOR A RECALL BUT IT DID NOT FIX THE ISSUE OF THE AIRBAG BEING OFF! THIS HAS BEEN HAPPENING FOR QUITE SOME TIME.
NHTSA ODI #11318915
65,000 miles · Jan 24, 2020
Air BagsSeat BeltsSeats
THERE WAS RECENTLY A PODS RECALL FOR THE WIRING HARNESS GOING TO THE OCCUPANT DETECTION SENSOR THE RECALL DID NOT FIX THE ISSUES FOR MANY PEOPLE. CAR WILL RANDOMLY THINK SOMEONE IS SETTING IN THE PASSENGER SEAT AND ACTIVATE AIRBAG AND CAUSE THE SEATBELT LIGHT TO CHIME CONSTANTLY WHILE DRIVING CAUSING THE AIR BAG TO TURN ON AND O…
Read full complaint
THERE WAS RECENTLY A PODS RECALL FOR THE WIRING HARNESS GOING TO THE OCCUPANT DETECTION SENSOR THE RECALL DID NOT FIX THE ISSUES FOR MANY PEOPLE. CAR WILL RANDOMLY THINK SOMEONE IS SETTING IN THE PASSENGER SEAT AND ACTIVATE AIRBAG AND CAUSE THE SEATBELT LIGHT TO CHIME CONSTANTLY WHILE DRIVING CAUSING THE AIR BAG TO TURN ON AND OFF. THE SENSOR IMBEDDED IN THE BOTTOM OF THE SEAT IS FAULTY.
NHTSA ODI #11301550
Official recalls
2Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Mar 22, 2021
Volkswagen Group of America, Inc. (Audi) is recalling certain 2015-2020 Audi S3 Sedan, A3 Sedan, 2016-2018 A3 Etron, 2017-2020 RS3 Sedan, and 2015-2019 A3 Cabriolet vehicles. The passenger occupant detection system (PODS) may malfunction and switch off the passenger air bag even when the seat is occupied.
Consequence & remedy
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and update the PODS control module, free of charge. Owners letters were mailed December 23, 2021. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 69BY.
Additional source detail variants (2)
Air Bags:sensor:occupant Classification:front Passenger
Volkswagen Group of America, Inc. (Audi) is recalling certain 2015-2020 Audi S3 Sedan, A3 Sedan, 2016-2018 A3 Etron, 2017-2020 RS3 Sedan, and 2015-2019 A3 Cabriolet vehicles. The passenger occupant detection system (PODS) may malfunction and switch off the passenger air bag even when the seat is occupied.
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and update the PODS control module, free of charge. Owners letters were mailed December 23, 2021. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 69BY.
Air BAGS:ON-OFF Switch Assembly
Volkswagen Group of America, Inc. (Audi) is recalling certain 2015-2020 Audi S3 Sedan, A3 Sedan, 2016-2018 A3 Etron, 2017-2020 RS3 Sedan, and 2015-2019 A3 Cabriolet vehicles. The passenger occupant detection system (PODS) may malfunction and switch off the passenger air bag even when the seat is occupied.
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the PODS sensor mat and update the PODS control module, free of charge. Owners letters were mailed December 23, 2021. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 69BY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration