NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
9 reportsClear category filter50,000 miles · Sep 23, 2019
Air BagsEngine
CAR ENGINE STOPPED WORKING WHILE IN MOVING DOWN THE ROAD. THE CAR WOULD NOT ACCELERATE ABOVE 10 MILES PER HOUR. CHECK ENGINE LIGHT CAME ON WITHOUT WARNING AS THE CAR STOPPED FUNCTIONING. PASSENGER AIR BAG WAS DISENGAGED AND INDICATED IT WOULD NOT DEPLOY EVEN THOUGH A PASSENGER WAS SITTING IN THE SEAT. SEVERE INJURY COULD HAV…
Read full complaint
CAR ENGINE STOPPED WORKING WHILE IN MOVING DOWN THE ROAD. THE CAR WOULD NOT ACCELERATE ABOVE 10 MILES PER HOUR. CHECK ENGINE LIGHT CAME ON WITHOUT WARNING AS THE CAR STOPPED FUNCTIONING. PASSENGER AIR BAG WAS DISENGAGED AND INDICATED IT WOULD NOT DEPLOY EVEN THOUGH A PASSENGER WAS SITTING IN THE SEAT. SEVERE INJURY COULD HAVE OCCURRED IF THE CAR HAD BEEN REAR ENDED WHEN THE CAR STOPPED WORKING. CAR HAD BEEN IN FOR MAINTENANCE AT ALL PREDESIGNATED MANUFACTURER'S SUGGESTED MILEAGE POINTS WITHOUT INDICATION OF ANY ISSUES. *JS
NHTSA ODI #11257580
32,000 miles · Jun 8, 2019
EnginePower TrainUnknown Or Other
EXCESSIVE OIL CONSUMPTION CAR HAS 2,300 MILES LEFT TO THE 10K OIL SERVICE CHECK CHANGE AND SHOWING LOW OIL. THIS IS NOT NORMAL AUDI IS TRYING TO SAY TO JUST TOP OFF THE OIL, YET EXCESSIVE OIL CONSUMPTION WILL CAUSE THE CAR TO NEED ENGINE REPLACEMENT EARLIER THAN IT SHOULD AT ABOUT 70-80-100K MILES AT BEST. THERE ARE MANY COMPL…
Read full complaint
EXCESSIVE OIL CONSUMPTION CAR HAS 2,300 MILES LEFT TO THE 10K OIL SERVICE CHECK CHANGE AND SHOWING LOW OIL. THIS IS NOT NORMAL AUDI IS TRYING TO SAY TO JUST TOP OFF THE OIL, YET EXCESSIVE OIL CONSUMPTION WILL CAUSE THE CAR TO NEED ENGINE REPLACEMENT EARLIER THAN IT SHOULD AT ABOUT 70-80-100K MILES AT BEST. THERE ARE MANY COMPLAINTS AND A CLASS ACTION THAT INVOLVED THIS ISSUE BUT THEY REFUSE TO DO MORE THAN CHANGE OIL AND CHECK FOR LEAKS WHEN THEY KNOW IT IS DUE TO DEFECTIVE PARTS AND I AM UNDER A CERTIFIED WARRANTY UNTIL OCTOBER 2019
NHTSA ODI #11218667
42,000 miles · Dec 14, 2018
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2015 AUDI A3. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AUDI NORTH PARK (210-960-6000, LOCATED AT 15670 I-35, SELMA, TX 78154) WHERE THE TECHNICIAN DIAGN…
Read full complaint
TL* THE CONTACT OWNS A 2015 AUDI A3. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AUDI NORTH PARK (210-960-6000, LOCATED AT 15670 I-35, SELMA, TX 78154) WHERE THE TECHNICIAN DIAGNOSED AND REPLACED THE FUEL PUMP. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 42,000.
NHTSA ODI #11161367
43,670 miles · Apr 6, 2018
Engine
LOST COMPRESSION AT ONLY 43,670 MILES TO FOURTH CYLINDER. ENGINE WAS REBUILT BY AUDI DEALER. FOUND PIECES OF OIL CONTROL RING FROM A PISTON IN OIL PAN, AIR LEAKING THROUGH INTAKE, SEATING SURFACE FOR INTAKE VALVE NUMBER 2 ON CYLINDER 4 WAS BURNT AND UNABLE TO SEAT PROPERLY DUE TO SPRING ON THAT VALVE BEING WEAKER THAN OTHERS.
NHTSA ODI #11083567
45,000 miles · Jun 7, 2017
Electrical SystemEngineFuel/propulsion System
CHECK ENGINE/ EPC- BOTH LIGHTS HAVE SIGNALED A DOZEN TIMES. THE FIRST FEW TIMES THE DEALERSHIP CALLED THEM "MISFIRES". EVENTUALLY THE CAR "SYMPTOMS" STARTED TO PROGRESS: WHEN CAR IS IDLING, CAR STARTS TO ACT LIKE IT IS ABOUT TO STALL. THEN IT PROGRESSED TO HARD/JERKY SHIFTS INTO 1ST OR 2ND GEAR. NOW EVEN AT HIGHER SPEEDS …
Read full complaint
CHECK ENGINE/ EPC- BOTH LIGHTS HAVE SIGNALED A DOZEN TIMES. THE FIRST FEW TIMES THE DEALERSHIP CALLED THEM "MISFIRES". EVENTUALLY THE CAR "SYMPTOMS" STARTED TO PROGRESS: WHEN CAR IS IDLING, CAR STARTS TO ACT LIKE IT IS ABOUT TO STALL. THEN IT PROGRESSED TO HARD/JERKY SHIFTS INTO 1ST OR 2ND GEAR. NOW EVEN AT HIGHER SPEEDS IT STARTS ACTING UP- GIVING THE FEELING THAT THE CAR MAY STALL. THIS IS A DAILY ISSUE. TWICE NOW CAR HAS FAILED TO ACCELERATE WHILE ENTERING HIGHWAY. THE WORST SITUATION OCCURRED WHEN CAR WAS BUCKING AND REFUSING TO GO INTO 2ND GEAR. I HAD TO PULL OVER, ON THE ON-RAMP, TURN OFF CAR AND RESTART. DASH LIGHTS FADE LIGHT/DARK CONSTANTLY. ORIGINALLY I THOUGHT IT WAS AN AUTOMATIC FEATURE, GOING FROM DAY TO NIGHT TIME LIGHTS. LIKE EVERYTHING ELSE IT HAS INCREASED W/ FREQUENCY & CANNOT BE CONNECTED TO CHANGE DAY/NIGHT LIGHT SETTING CHANGE. KEY FOB DIED WHILE I WAS DRIVING ON HIGHWAY, CAR STALLED ON HIGHWAY. I RESTARTED CAR USING EMERGENCY PROCEDURE (ALIGNING KEY FOB NEXT TO KEY SYMBOL ON DRIVE SHAFT)- THIS IS MEANT TO KEEP CAR RUNNING EVEN W/ DEAD KEY BATTERY. CAR SHUT OFF MULTIPLE TIMES WAITING FOR TOW TRUCK- WHO THEN LOADED MY CAR WHILE RUNNING BECAUSE IT STALLED ON HIM TOO. DID I MENTION THE 4 DAYS PRIOR MY CAR HAD BEEN AT THE DEALERSHIP - SO EITHER WARNING SIGN DIDN'T CORRECTLY NOTIFY OR THEY JUST IGNORED IT. FIXED IGNITION COIL, SPARK PLUGS CURRENT DEALERSHIP DIAGNOSTIC: FAULT TO BAD INJECTOR SOMEHOW NONE OF THE RECALLS THAT APPLY TO 2015 A3S APPLY TO MY VEHICLE. EVEN THOUGH MOST OF THE DECRIPTIONS APPLY TO CAR ISSUES.
NHTSA ODI #10993707
Mileage unknown · Jun 1, 2017
Engine
2015 AUDI A3. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE COMPARTMENT FIRE. *LD THE CONSUMER STATED THE ENGINE COMPARTMENT CAUGHT FIRE. THE VEHICLE SAT IN AN OPEN AIR SITE WITHOUT A HOOD OR WINDOWS, EXPOSED TO THE WINTER ELEMENTS. 13 DAYS LATER IT WAS INSPECTED BY THE MANUFACTURER, WHO DETERMINED THE FAILURE TO BE DUE TO ROD…
Read full complaint
2015 AUDI A3. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE COMPARTMENT FIRE. *LD THE CONSUMER STATED THE ENGINE COMPARTMENT CAUGHT FIRE. THE VEHICLE SAT IN AN OPEN AIR SITE WITHOUT A HOOD OR WINDOWS, EXPOSED TO THE WINTER ELEMENTS. 13 DAYS LATER IT WAS INSPECTED BY THE MANUFACTURER, WHO DETERMINED THE FAILURE TO BE DUE TO RODENT NESTING ACTIVITY. *JS
NHTSA ODI #10985349
42,000 miles · Feb 12, 2017
Engine
VEHICLE WAS IN MOTION ON HIGHWAY TRAVELING AT 65 MPH. ENGINE CEASED WITHOUT WARNING. ABSOLUTELY NO POWER OR ENGINE NOISE WHEN ACCELERATING. VEHICLE WENT FROM 65 TO 0 MPH IN SECONDS. NO STEERING CONTROL AS WELL!! COULD HAVE BEEN KILLED. HEAD OF SERVICE AT AUDI DEALERSHIP SAYS THAT IT HAPPENS ALL THE TIME & AUDI IS DOING ABSOLUTEL…
Read full complaint
VEHICLE WAS IN MOTION ON HIGHWAY TRAVELING AT 65 MPH. ENGINE CEASED WITHOUT WARNING. ABSOLUTELY NO POWER OR ENGINE NOISE WHEN ACCELERATING. VEHICLE WENT FROM 65 TO 0 MPH IN SECONDS. NO STEERING CONTROL AS WELL!! COULD HAVE BEEN KILLED. HEAD OF SERVICE AT AUDI DEALERSHIP SAYS THAT IT HAPPENS ALL THE TIME & AUDI IS DOING ABSOLUTELY NOTHING. SAID DO NOT TAKE CAR BACK...THEY'RE PLAYING "RUSSIAN ROULETTE" WITH YOUR LIFE AND WON'T DO ANYTHING UNTIL SOMEONE GETS KILLED.....UPDATED 06/21/17 *BF *CN
NHTSA ODI #10954092
10,700 miles · Jan 7, 2016
EngineService Brakes
AT 5 MONTHS - ENGINE ALMOST OVERHEATED. CAR TOWED TO DEALER WHERE THEY FOUND THE FAN AND COMPUTER MODULE FAILED AND HAD TO BE REPLACED. AT 7 MONTHS (CURRENT ISSUE) - WARNING LIGHT CAME ON AND ADVISED THAT BRAKES FAILED. DEALER FOUND THAT THE MASTER BRAKE CYLINDER FAILED. INTERNAL CAMERA SHOWED SEALS FAILED AND WERE LEAKING. THI…
Read full complaint
AT 5 MONTHS - ENGINE ALMOST OVERHEATED. CAR TOWED TO DEALER WHERE THEY FOUND THE FAN AND COMPUTER MODULE FAILED AND HAD TO BE REPLACED. AT 7 MONTHS (CURRENT ISSUE) - WARNING LIGHT CAME ON AND ADVISED THAT BRAKES FAILED. DEALER FOUND THAT THE MASTER BRAKE CYLINDER FAILED. INTERNAL CAMERA SHOWED SEALS FAILED AND WERE LEAKING. THIS CAR IS TOO NEW FOR SUCH A MAJOR PART TO FAIL THIS WAY.
NHTSA ODI #10818824
2,689 miles · Oct 13, 2014
Engine
I BOUGHT A BRAND NEW 2.0 AUDI A3 FROM THE DEALER THIS MAY. I GOT A LOW OIL WARNING WITH ONLY 2700 MILES ON THE CAR, AND THE OIL IS DARK AND DIRTY COMPARE TO THE LONER CAR I GOT. IT HAS BEEN THREE TIMES I BROUGHT MY CAR BACK TO THE SERVICE DEPARTMENT IN THE DEALER, BUT THEY NEVER SOLVED THE PROBLEM. FIRST TIME, THEY TOPED …
Read full complaint
I BOUGHT A BRAND NEW 2.0 AUDI A3 FROM THE DEALER THIS MAY. I GOT A LOW OIL WARNING WITH ONLY 2700 MILES ON THE CAR, AND THE OIL IS DARK AND DIRTY COMPARE TO THE LONER CAR I GOT. IT HAS BEEN THREE TIMES I BROUGHT MY CAR BACK TO THE SERVICE DEPARTMENT IN THE DEALER, BUT THEY NEVER SOLVED THE PROBLEM. FIRST TIME, THEY TOPED UP THE OIL. AFTER TWO WEEKS, THE OIL WAS LOW AGAIN, SO I BROUGHT IT BACK. THIS TIME, THEY CHANGED A NEW OIL TANK CAP FOR ME, BUT TWO WEEKS LATER, THE OIL WAS LOW. I DROVE IT BACK TO THE SERVICE, THIS TIME ACTUALLY THE AUDI COMPANY TOLD ME THAT IS BECAUSE MY CAR IS STILL IN BREAK-IN PERIOD AND JUST TOPPED UP THE OIL AGAIN. BUT AS AN ENGINEER, I KNOW IT CANNOT BE 2 QT PER 1000 MILES. *TR
NHTSA ODI #10644326
Official recalls
5Jun 19, 2019
Volkswagen Group of America, Inc. (Audi) is recalling certain 2015-2016 Audi S3 Sedan, 2015-2019 A3 Sedan and A3 Cabriolet, 2016-2018 A3 e-tron, and 2017-2019 RS3 vehicles. An improper electrical contact may cause the Passenger Occupant Detection System (PODS) to falsely detect a malfunction and deactivate the passenger air bag.
Consequence & remedy
Consequence: A deactivated passenger air bag increases the risk of injury during a crash.
Remedy: Audi will notify owners, and dealers will replace the connector and reroute the cable, free of charge. The recall began September 12, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Audi's number for this recall is 69Z4.
Apr 26, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015 Audi A3 1.8T FWD S tronic and 2.0T Quattro S tronic vehicles. The safety certification label has an incorrect vehicle production date. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: In the event of a vehicle safety recall, an incorrect production date may prevent owners from determining if the recall affects them, increasing their risk of injury or a crash.
Remedy: Audi will notify owners, and dealers will install an overlay label containing the correct vehicle production date, free of charge. The recall June 23, 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 51F5.
Sep 7, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence & remedy
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Additional source detail variants (2)
Fuel System, Gasoline
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Engine And Engine Cooling:exhaust System:emission Control
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Consequence: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
Dec 8, 2015
Volkswagen Group of America, LLC (Volkswagen) is recalling certain model year 2015 Audi A3 Cabriolet vehicles manufactured June 5, 2014, to April 1, 2015. The affected vehicles have a driver or front passenger seat whose cover may be incorrectly stitched, preventing the side air bag from properly deploying in the event of a crash.
Consequence & remedy
Consequence: Improper side air bag deployment may increase the risk of injury in the event of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's and/or front passenger's seatback cover, free of charge. Owners were mailed interim notices on February 4, 2016. The recall began on February 29, 2016 . Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 74C9.
Additional source detail variants (2)
Seats
Volkswagen Group of America, LLC (Volkswagen) is recalling certain model year 2015 Audi A3 Cabriolet vehicles manufactured June 5, 2014, to April 1, 2015. The affected vehicles have a driver or front passenger seat whose cover may be incorrectly stitched, preventing the side air bag from properly deploying in the event of a crash.
Consequence: Improper side air bag deployment may increase the risk of injury in the event of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's and/or front passenger's seatback cover, free of charge. Owners were mailed interim notices on February 4, 2016. The recall began on February 29, 2016 . Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 74C9.
Air Bags:side/window
Volkswagen Group of America, LLC (Volkswagen) is recalling certain model year 2015 Audi A3 Cabriolet vehicles manufactured June 5, 2014, to April 1, 2015. The affected vehicles have a driver or front passenger seat whose cover may be incorrectly stitched, preventing the side air bag from properly deploying in the event of a crash.
Consequence: Improper side air bag deployment may increase the risk of injury in the event of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's and/or front passenger's seatback cover, free of charge. Owners were mailed interim notices on February 4, 2016. The recall began on February 29, 2016 . Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 74C9.
Apr 17, 2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015 Volkswagen Golf, and GTI manufactured on February 17, 2014, to May 22, 2014, and Audi A3 manufactured on February 16, 2013, to April 23, 2014. Improper nickel plating of components within the fuel pump may result in the fuel pump failing.
Consequence & remedy
Consequence: If the fuel pump fails, the vehicle will not start, or if the engine is running, it will stop and the vehicle will stall, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the vehicles and replace any affected fuel pumps, free of charge. The recall began on June 16, 2015. Owners may contact Volkswagen at 1-800-893-5298 or Audi at 1-800-253-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration