NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
31 reportsClear category filterMileage unknown · Jun 6, 2026
EngineFuel/propulsion System
Driving car and suddenly all the lights on the dash light up and car goes into “limp” mode. Upon pulling over turning car off and turning back on lights are all still lit up. Plug car into obd2 scanner and car is showing code p0087 low fuel rail pressure. This is extremely dangerous as the car will randomly do this and will go i…
Read full complaint
Driving car and suddenly all the lights on the dash light up and car goes into “limp” mode. Upon pulling over turning car off and turning back on lights are all still lit up. Plug car into obd2 scanner and car is showing code p0087 low fuel rail pressure. This is extremely dangerous as the car will randomly do this and will go into limp mode which can easily cause me to get into an accident. No active recalls on this but I’m seeing this is a common issue with these Acura tlx models. Why hasn’t this issue been addressed yet Acura?! For reference I drive a 2018 Acura tlx base model 2.4 cylinder
NHTSA ODI #11742504
Mileage unknown · May 27, 2026
Engine
I bought my 2018 Acura TLX a-spec V6 in Nov. 2021, certified pre-owned from an Acura dealer. It had warranty through 100k miles. At just under 70k miles, around mid-2023 I believe, the engine seized and would not start. Warranty covered engine replacement. This was just around the time of the 3.6L V6 engine recall. I waited on t…
Read full complaint
I bought my 2018 Acura TLX a-spec V6 in Nov. 2021, certified pre-owned from an Acura dealer. It had warranty through 100k miles. At just under 70k miles, around mid-2023 I believe, the engine seized and would not start. Warranty covered engine replacement. This was just around the time of the 3.6L V6 engine recall. I waited on the recall because the engine was brand new at that point. A year or so later, deal did inspect the engine for recall, but determined it was not part of the recall. Come current to late April 2026, just before engine #2 hit 70k miles (total miles on car ~139,000), engine has seized again. Driving on freeway and car went into limp mode, thankfully close to home and made it safely. Had car towed next day to mechanic who sent a video of the knocking noise (can send video if requested; unable to upload here) and refused to work on it. He later drove the car down the block and that is when engine completely failed; no longer would turn on. Towed home, towed to dealer a week ½ later when they had opening. Dealer performed diagnostic and confirmed crankshaft seized. However, now, well past warranty coverage. I called Acura customer relations and opened a case; they will only cover "half" of the engine replacement, at a cost of $13,817 to me. My car is less than 10 years old, less than 150k miles overall and should NOT need engine #3. Will same issue happen after another 70k miles? Acura refuses to acknowledge and take care of it 100%.
NHTSA ODI #11740489
Mileage unknown · Jan 13, 2026
EngineUnknown Or Other
The vehicle experienced vibration symptoms and stalled on the road. The day before it stalled, there were rattling noises which prompted me to take the car to the dealership the next day. I had just received the letter about the recall so I knew it was likely related. The car was towed to the Acura dealership but the dealershi…
Read full complaint
The vehicle experienced vibration symptoms and stalled on the road. The day before it stalled, there were rattling noises which prompted me to take the car to the dealership the next day. I had just received the letter about the recall so I knew it was likely related. The car was towed to the Acura dealership but the dealership denied recall coverage, stating the engine number did not match the recall list. During the discovery process, it was later discovered that the engine had been swapped by the dealership in 2018 — a fact that was not disclosed to me at the time of my purchase. The installed engine still falls within the recall defect interval of 2015-2020 but they are resistant to repair. Upon initial inspection of the vehicle, the dealership found metal shavings in the oil indicating internal engine damage. The manufacture requested my oil change records suggesting that this was my fault. I presented the oil change receipts but they still refused recall coverage and the dealership requested approximately $5,000 for diagnostics, if determined my fault. If it is determined that the defect damaged the engine, they will cover the 5k. After several weeks of inspection and going through the manufacture recall process, the dealership determined the recall issue applies my car. However, due to the engine number not on the “list” they are denying my recall coverage. They are seeking $25k for service repairs. After almost 2 months of back and forth, I have been misled and misinformed. I am struggling to get my car repaired under recall.
NHTSA ODI #11710731
Mileage unknown · Jan 9, 2026
Engine
The engine has been making rattling noises when you start the vehicle from a long rest, mostly over night, since it has about 24k miles on it, when I purchased it used. I noticed it some time after I purchased it. Took it to Honda dealer in Hickory, NC, but they couldn't hear it. Later also took it to Acura dealer in Charlott…
Read full complaint
The engine has been making rattling noises when you start the vehicle from a long rest, mostly over night, since it has about 24k miles on it, when I purchased it used. I noticed it some time after I purchased it. Took it to Honda dealer in Hickory, NC, but they couldn't hear it. Later also took it to Acura dealer in Charlotte, NC. They couldn't hear it either. I recorded the sound and played it back to them.
NHTSA ODI #11709862
Mileage unknown · Sep 21, 2025
Electrical SystemEnginePower Train
Date of incident : August 31,2025 Around 9pm on August 31, I was fixing to accelerate at a green light. I pressed the gas pedal, my car went up to 40 mph and then the engine failed. This is due to a recall on the bearing rods for 2015-2020 Acura TLX. The incident occurred a month after financing the car. I don't have a warranty…
Read full complaint
Date of incident : August 31,2025 Around 9pm on August 31, I was fixing to accelerate at a green light. I pressed the gas pedal, my car went up to 40 mph and then the engine failed. This is due to a recall on the bearing rods for 2015-2020 Acura TLX. The incident occurred a month after financing the car. I don't have a warranty, so I opened up a case with the manufacturer to get help with the repair cost (which is 25,500 for a new engine block and 2 new cylinder heads). Unfortunately, Acura denied assistance. The car only has 68880 miles on it. The rod snapped and put a hole through my engine block. Shame on the manufacturer for denying assistance. I'm now stuck making payments on a car I cannot drive. Yes I have insurance, but it was not involved in an accident so I'm helpless there.
NHTSA ODI #11688717
Mileage unknown · Sep 7, 2025
EngineVehicle Speed Control
While I was driving in the fwy I tried changed lanes and needed to speed so that incoming car wouldn’t hit me but my car was stalling. It has happened 3 times!!! I took it to the dealership and they said it’s the camera and that they don’t have the part on stock. I asked for a rental car meanwhile we wait for the part and they s…
Read full complaint
While I was driving in the fwy I tried changed lanes and needed to speed so that incoming car wouldn’t hit me but my car was stalling. It has happened 3 times!!! I took it to the dealership and they said it’s the camera and that they don’t have the part on stock. I asked for a rental car meanwhile we wait for the part and they said they can’t do that. I stated to them that the car is dangerous not only for me but for the public if I keep driving it like that. They said there’s nothing they can do!
NHTSA ODI #11685526
Mileage unknown · Sep 4, 2025
Engine
I am from Philadelphia PA and I was driving my car on a highway in rural WV and the engine stalled while driving. I was lucky enough that no other cars were around and I was able to veer the car off the road into a parking lot. The car would not re-start. I had to tow my vehicle to a local mechanic shop who could not help. I was…
Read full complaint
I am from Philadelphia PA and I was driving my car on a highway in rural WV and the engine stalled while driving. I was lucky enough that no other cars were around and I was able to veer the car off the road into a parking lot. The car would not re-start. I had to tow my vehicle to a local mechanic shop who could not help. I was stranded out of state on a holiday weekend with no acura in a 2 hour radius. I ended up renting a u-haul and towing the car 8 hours from WV back to a local Acura in Philadelphia. Acura replaced the engine due to the known re-call but refused to cover the cost of the tow or U-haul.
NHTSA ODI #11685154
Mileage unknown · Nov 12, 2024
Engine
I was driving home from work and I started hearing a knocking noise and I was trying to get off the highway on the next exit but I didn’t make it the engine locked up and jolted. The car went into neutral luckily I was able to coast to the side of the highway.After getting it towed to the dealership they said it was a rod bearin…
Read full complaint
I was driving home from work and I started hearing a knocking noise and I was trying to get off the highway on the next exit but I didn’t make it the engine locked up and jolted. The car went into neutral luckily I was able to coast to the side of the highway.After getting it towed to the dealership they said it was a rod bearing failure and they needed to change the engine block. I had to fight for it to be covered under warranty but finally they covered it and they changed out the engine block.
NHTSA ODI #11624645
Mileage unknown · Oct 27, 2024
EngineFuel/propulsion SystemUnknown Or Other
Hi, I’m having issues with my fuel pump / engine and I seen online there was a previous recall for this issues regarding my year make and model but when I search my vin it’s not included? Not sure why when I’m having issues related to that exact recall. I believe it can be related. I took it to Acura and they want to charge me 5…
Read full complaint
Hi, I’m having issues with my fuel pump / engine and I seen online there was a previous recall for this issues regarding my year make and model but when I search my vin it’s not included? Not sure why when I’m having issues related to that exact recall. I believe it can be related. I took it to Acura and they want to charge me 5,000 dollars for repair. I have a 2018 Acura tlx 3.5 v6 which is stated in this photo attached. Can I get some more clarification please? I’m having all issues notated on the photo. Regarding car idle, fuel issues, stalling and more. My car slid into Neutral while I was driving twice! Super scary. When I took it to Acura they diagnosed everything that was in the recall? Not sure why my vehicle isn’t included when it’s very obviously related
NHTSA ODI #11622166
Mileage unknown · May 6, 2024
Engine
My engine makes sounds and possibly there's some shifting noise when I'm not changing gears while driving on the highway. the dealer routinely checks my fluids,so the transmission fluid is fine. I even had a transmission flush after reading an article about this engine. The engine ticks like the rows are sticking. These are all …
Read full complaint
My engine makes sounds and possibly there's some shifting noise when I'm not changing gears while driving on the highway. the dealer routinely checks my fluids,so the transmission fluid is fine. I even had a transmission flush after reading an article about this engine. The engine ticks like the rows are sticking. These are all characteristics of the published letter last year recalling Hondas and my car year make and model. Please furnish me with a recall letter so I can have this engine fixed before it dies or burns out on the highway causing injury or death
NHTSA ODI #11587230
Official recalls
4May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Jan 29, 2019
Honda (American Honda Motor Co.) is recalling certain 2016-2018 Acura MDX, 2015-2019 Acura TLX and 2015-2017 Honda Accord vehicles, equipped with a 3.5L V6 engine. Particulates in fuel may adhere to the internal components of the fuel pump, reducing its performance.
Consequence & remedy
Consequence: Reduced fuel pump performance can result in an engine stall, increasing the risk of crash.
Remedy: Honda will notify owners, and dealers will update the fuel injection engine control unit (FI-ECU) software and, if necessary, replace the fuel pump, free of charge. The recall began March 25, 2019. Owners may contact customer service at 1-888-234-2138. Acura's recall number for this recall is P3W. Honda's recall number for this recall is N3X.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE25008 · Engine Failure
Opened Aug 20, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine
The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline. The subject engine failures were analyzed as part of a Recall Query (RQ24013). It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751. Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation. ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24013 · Engine Failure
Opened Nov 8, 2024 · Closed Aug 20, 2025
Status: closed (inferred from source dates) · Engine
On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation. NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.
Illustration