← New search

2016 Volvo XC90

Owner reports · Recalls · Investigations

More warning signs than most XC90 years

Owner complaints for the 2016 Volvo XC90 are substantially higher than the model-year median of 34.

About this comparison →

When problems were reported

Mileage at the reported incident

89 reports with mileage · 108 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports10 fire reports4 injury reports

Unknown Or Other complaints

36 reports
Clear category filter
Mileage unknown · Jul 17, 2026
EngineUnknown Or Other

Piston rings inside the engine failed due to a known oil consumption issue with this model vehicle. The engine failed while the car was driving 85 mph and consequently slowed down to 15mph on the highway, leaving the owner of the car stranded alone on the highway. Volvo has a known fix for this issue and there was a class action…

Read full complaint

Piston rings inside the engine failed due to a known oil consumption issue with this model vehicle. The engine failed while the car was driving 85 mph and consequently slowed down to 15mph on the highway, leaving the owner of the car stranded alone on the highway. Volvo has a known fix for this issue and there was a class action lawsuit for it, but since it was settled, there was no recall. This is, in fact, a dangerous issue that is preventable. Additionally, the sunroof drains also leak. Water frequently leaks down the A-pillar directly onto the Central Electronic Module (CEM) causing unsafe electrical issues and potential engine failure. This was a known issue on other models, but it is also present in this model vehicle. When I tried to fix this under a warranty contract, I was denied by the certified repair shops.

NHTSA ODI #11751100

Mileage unknown · Jul 8, 2026
Unknown Or Other

The AC evaporator has a leak. I am reporting as this is a well known issue on the Volvo's, especially the 2016 XC90 which has a large amount of issues that cause issues of safety and undue amount of financial burden on owners who operate the vehicle in normal conditions. I have been told by the dealer after they repaired a anoth…

Read full complaint

The AC evaporator has a leak. I am reporting as this is a well known issue on the Volvo's, especially the 2016 XC90 which has a large amount of issues that cause issues of safety and undue amount of financial burden on owners who operate the vehicle in normal conditions. I have been told by the dealer after they repaired a another issue of the engine (8 times this vehcile has been in for repair on engine issues that are due to a block issue) the ac evaporator is well known by Volvo to be poorly designed and manufatcurered where they last under ten years. I have asked dealers and mechainc shops who see dozens a week of these repairs needed. The avergae cost I have been quote is $4000 for repair and the volvo service dealer I could told me, these keep the shop going. There is no way that this is not a issue to the public that puts a undue burden to owners, one that Volvo HQ in USA acknowledges is a issue but is not required to do anything.

NHTSA ODI #11749074

Mileage unknown · Jun 26, 2026
EngineFuel/propulsion SystemUnknown Or Other

My 2016 Volvo XC90 suddenly lost power while I was driving, requiring me to pull over and have the vehicle towed. This is a documented safety issue associated with a known piston ring defect in 2013-2016 Volvo vehicles equipped with 2.0L and 2.5L engines, which was the subject of a federal class action lawsuit ([XXX] et al. v. V…

Read full complaint

My 2016 Volvo XC90 suddenly lost power while I was driving, requiring me to pull over and have the vehicle towed. This is a documented safety issue associated with a known piston ring defect in 2013-2016 Volvo vehicles equipped with 2.0L and 2.5L engines, which was the subject of a federal class action lawsuit ([XXX] et al. v. Volvo Car USA, LLC, Case No. XXX, filed XXX. No there we NO warning lamps, messages or other symptoms of the problem prior to the failure. I purchased this vehicle as a second owner from Carvana [XXX] — one month after the class action was filed. I was never notified of the defect, the litigation, or any service campaign or extended warranty coverage associated with this VIN, through Carvana nor Volvo. Since the power loss, I have spent $11,543.75 in out-of-pocket repairs (replacement engine, labor, towing). Despite a new engine being installed, the vehicle enters limp mode within one mile of driving. A Volvo-authorized dealer has quoted an additional $19,959.65 in repairs without certifying that the work will resolve the safety issue. Volvo Customer Care has declined to assist, stating their internal service campaign has concluded. I am submitting this safety complaint because sudden, unexplained power loss in a moving vehicle is a significant safety hazard, and because second owners of affected vehicles were never properly notified of the defect. I never knew nor was this disclosed to me before purchase from Carvana nor told to me by Volvo. I was in the middle of nowhere and I was not sure what to do and being a single woman, I was unsafe and scared. What ever this issue is Volvo and the dealer in South Dakota (where it is parked right now) as I had it towed on June 5th, and they don't want to help nor fix my vehicle. I need my catering business vehicle as this is a very concerning for my loss of use for over a year now for my catering part of my business. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11746768

Mileage unknown · Feb 27, 2026
Unknown Or OtherFire

My car started smoking on the road, I parked it. It smoked, Then it caught on fire.

NHTSA ODI #11721075

Mileage unknown · Sep 3, 2025
Unknown Or Other

The rear two car doors will not open. It started months ago with the left side and now is both doors. This is dangerous if anyone in the rear of the vehicle should need to exit in a timely manner. The dealership knows this is an issue, but says they are not obligated to fix it for free because there isn’t a recall yet.

NHTSA ODI #11684873

Mileage unknown · May 27, 2025
Unknown Or OtherInjury

The back door, or liftgate, closes automatically (without me pressing the close button). This is inconsistent, as it doesn't happen all the time. Each time the car has been off, and maybe it's on some kind of timer. It's happened 3 times, at random, where each time it caught me off guard. One time it hit me on the back of the he…

Read full complaint

The back door, or liftgate, closes automatically (without me pressing the close button). This is inconsistent, as it doesn't happen all the time. Each time the car has been off, and maybe it's on some kind of timer. It's happened 3 times, at random, where each time it caught me off guard. One time it hit me on the back of the head. The next time my kids were sitting in the back and I had to yell for them to tuck their legs inside. The third time, was just last week, and I had to run out from under it. There is no beeping or warning, and I'm afraid it's only a matter of time before it causes serious injury. I've had this vehicle for about 12 months, and it's only happened 3 times, but I can't figure out what the causes it.

NHTSA ODI #11663205

Mileage unknown · Apr 29, 2024
Latches/locks/linkagesUnknown Or Other

The left rear door of my vehicle flew open while we were moving with my 10-year-old daughter sitting adjacent to the door. Fortunately, she had her seat belt on otherwise the result would have been tragic. On [XXX] my daughter got into the back of my vehicle, suddenly, her door flew open, I immediately stopped the vehicle. My …

Read full complaint

The left rear door of my vehicle flew open while we were moving with my 10-year-old daughter sitting adjacent to the door. Fortunately, she had her seat belt on otherwise the result would have been tragic. On [XXX] my daughter got into the back of my vehicle, suddenly, her door flew open, I immediately stopped the vehicle. My daughter was unable to shut the door and after many attempts I got the door to shut. When we arrived at home both rear doors would not open and my now trapped daughter exited through the front door. On [XXX], I went to Volvo in Rochester NY and explained the situation expecting the service person to be extremely concerned. Much to my surprise he said “that happens all the time” and that when it gets cold out sometimes the latches don’t respond. I anticipated that my car would go in immediately but was told “how is Thursday to bring your car in.” I dropped my car off and received a call that afternoon with “great news” that the issue was a faulty door latch, the part was in stock and came with a “lifetime warranty.” He told me the cost was $734.00 per door meaning with sales tax the cost would be over $1,500 and I would still have two doors at risk for flying open in the future. I asked how this life safety issue which has failed on countless other vehicles is not covered by the manufacturer nor has there been a recall. He said Volvo has recognized the door latch safety issue and designed a fix. When the door latch fails, this new replacement part, that the consumer pays for, solves the problem. Volvo recognized a safety problem, designed the fix, yet has chosen not to recall the vehicles that have these problems but rather waits until the door latch fails before the consumer must pay to replace it. I arrived the next day to pick up my vehicle, sat down with the service manager who was empathetic, but reiterated this is an issue that has repeatedly occurred. This needs to be addressed and not paid by consumers INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

NHTSA ODI #11585941

Mileage unknown · Mar 23, 2024
Unknown Or Other

Your site states that my vehicle does not have active recalls for my vehicle but there is a recall that the manufacturer confirmed my vehicle is actively affected by since 2019

NHTSA ODI #11579067

Mileage unknown · Mar 1, 2024
Unknown Or Other

It started with the right rear passenger door not opening from the inside or outside of the car. At first you could lock the doors from the inside and then open the door, but now the door will not open at all. My left rear passenger door has started to do the same thing this week. It will only open about 50% of the time. The doo…

Read full complaint

It started with the right rear passenger door not opening from the inside or outside of the car. At first you could lock the doors from the inside and then open the door, but now the door will not open at all. My left rear passenger door has started to do the same thing this week. It will only open about 50% of the time. The door handles are in good order, and this is not related to an accident. This is an extremely dangerous situation for my kids! If we were in a car accident or if there was a fire in the car they would not be able to escape. I have attempted to contact customer service, but have not been able to get a hold of them.

NHTSA ODI #11574803

Mileage unknown · Feb 21, 2024
Unknown Or Other

The rear door locking system has failed. Both doors will not open from the interior or exterior. I have read thousands of complaints about this particular problem with this make and model of Volvo. The locking system on a car should never fail. HUGE safety concern.

NHTSA ODI #11573081

Official recalls

8

23V827000 · Seat Belts:critical Fasteners

Dec 7, 2023

Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.

Consequence & remedy

Consequence: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.

Remedy: Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.

21V273000 · Electrical System:software

Apr 21, 2021

Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.

Consequence & remedy

Consequence: The rear passenger may become trapped by the front seat without the ability to cancel the seat's movement, increasing the risk of injury.

Remedy: Volvo Car will notify owners, and dealers will update the rear seat control display software, free of charge. Owner notification letters were mailed July 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10093.

19V308000 · Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Apr 17, 2019

Volvo Cars of N.A., LLC (Volvo Cars) is recalling certain 2016 XC90 vehicles. Exposure to heat and humidity may cause the engine coolant bleeder hose to crack, resulting in a coolant leak.

Consequence & remedy

Consequence: If the coolant leak goes unnoticed, coolant may accumulate in the catalytic converter heat shield insulation and catch fire when the vehicle is stationary, increasing the risk of injury.

Remedy: Volvo Cars will notify owners, and dealers will replace the engine side coolant bleeder hose, free of charge. The recall began June 12, 2019. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29936.

16V798000 · Seat Belts:front:buckle Assembly

Nov 2, 2016

Volvo Car USA LLC (Volvo) is recalling certain model year 2016-2017 XC90, S90, XC60, V60 Cross Country, V60, S60 Cross Country, S60, and S60 Inscription vehicles manufactured February 16, 2015, to August 22, 2016. On the affected vehicles, the front passenger seat belt buckle attaching stud may loosen, allowing the buckle to separate from the seat belt bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages" and number 209, "Seat Belt Assemblies."

Consequence & remedy

Consequence: If the seat belt buckle separates from the bracket, the front seat passenger may not be adequately restrained in the event of a crash, increasing their risk of injury in the event of a crash.

Remedy: Volvo will notify owners, and dealers will inspect the front passenger seat belt buckle stud, replacing the seat belt buckle as needed, free of charge. The recall began January 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89708.

16V690000 · Air Bags; Equipment:appliance:air Conditioner

Sep 26, 2016

Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.

Consequence & remedy

Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.

Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.

Additional source detail variants (2)

Equipment:appliance:air Conditioner

Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.

Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.

Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.

Air Bags

Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.

Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.

Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.

16V268000 · Visibility:sun/moon Roof Assembly

May 4, 2016

Volvo Car USA LLC (Volvo) is recalling certain model year 2016 XC90 vehicles manufactured January 27, 2015, to April 23, 2016. The sunroofs on the affected vehicles have a switch on the overhead console that may not be adequately recessed to prevent the switch from being unintentionally pressed. When pressed, the sunroof may fully close. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 118, "Power-Operated Window, Partition, and Roof Panel Systems."

Consequence & remedy

Consequence: If the switch is unintentionally pressed and the sunroof panel closes, there is an increased risk of occupant injury.

Remedy: Volvo will notify owners, and dealers will perform a software upgrade that disables the auto-close function, free of charge. The recall began June 24, 2016. Owners may contact Volvo customer service at 1-800-458-1552 or by visiting http://Volvo.custhelp.com. Volvo's number for this recall is R89702.

15V497000 · Air Bags:side/window

Aug 6, 2015

Volvo Cars of N.A., LLC (Volvo) is recalling certain model year 2016 Volvo XC90 vehicles manufactured January 27, 2015, to July 10, 2015. The third row seating side curtain air bags may not fully inflate.

Consequence & remedy

Consequence: Underinflated air bags may not fully protect third row occupants, increasing the risk of injury in the event of a crash.

Remedy: Volvo will notify owners, and dealers will modify the D-pillar interior panels to allow full inflation of the third row airbags, free of charge. The recall began on September 21, 2015. Owners may contact Volvo Customer Care at 1-800-458-1552.

15V342000 · Air Bags:side/window

Jun 3, 2015

Volvo Cars of N.A., LLC (Volvo) is recalling certain model year 2016 Volvo XC90 vehicles manufactured January 27, 2015, to May 19, 2015. The affected vehicles have front seats whose wiring harness for the Side Impact Protection System (SIPS) may have been routed incorrectly.

Consequence & remedy

Consequence: If the wiring harness is routed incorrectly, the wiring may be damaged, disabling the front seat side impact air bag, and increasing the risk of injury to the seat occupant in the event of a crash necessitating deployment of the front seat side impact air bag.

Remedy: Volvo will notify owners, and dealers will inspect the routing of the SIPS wiring, correcting the routing and installing a protective sleeve as necessary, free of charge. The recall began on June 30, 2015. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89571.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.