2003 Volvo XC90

MULTIPLE FAILURES; DOOR LOCK,TIRES WERE WORN TO THE CORD. * BF THE LUG NUTS WERE REPLACED BECAUSE THEY WERE RUSTED WHEN THE VEHICLE WAS DELIVERED, THE DOORS DID NOT FIT PROPERLY, THE RADIO FAILED, THE KEY WOULD NOT TURN IN THE IGNITION, THE LEFT REAR DOOR COULD NOT BE OPENED DUE TO THE PROBLEM WITH THE SEAT MOLDING AND THE TIRE DISPLAYED UNUSUAL WEAR AND WERE WORN SMOOTH TO THE CORD. THE LUG NUTS THAT WERE INSTALLED RUSTED AGAIN. (TIRES/PERRILLI SCORPIAN) *SC *JB

WHILE BACKING PUT OF A PARKING LOT POWER STEERING FAILED, VEHICLE SMOKED THEN CAUGHT ON FIRE. DRIVER SUFFERED FROM SMOKE INHALATION. *AK PRIOR TO THE VEHICLE CATCHING ON FIRE THE CONSUMER WAS INVOLVED IN AN ACCIDENT THE YEAR BEFORE (JULY 12, 2003). THE CONSUMER WAS PRESSING ON THE HORN WHEN THE CRASH OCCURRED. THE CONSUMERS HAND WAS ON THE WHEN THE AIR BAG DEPLOYED. THE DRIVER SUSTAINED SEVERAL BROKEN ONES IN HER RIGHT HAND WHICH REQUIRED 2 SURGERIES, EXTENSIVE PHYSICAL THERAPY AND MANY OTHER MEDICAL PROCEDURES. *NM *LA

RIGHT REAR WHEEL BEARING FAILED. SYMPTOMS WERE THAT THE VEHICLE WOULD NOT ACCELERATE OVER 35 MPH. DASHBOARD WARNING LIGHT INDICATED THAT VEHICLE WAS AT RISK OF TIPPING. CAR WAS STRANDED ON HIGHWAY WHILE RETURNING FROM VACATION SOME 400 MILES FROM HOME. WAS ABLE TO LIMP OFF AND INVOKE VOLVO ROADSIDE ASSISTANCE PROGRAM. VEHICLE WAS TOWED TO DEALER WITHIN 30 MINUTES. DEALER WAS UNABLE TO DIAGNOSE PROBLEM FOR 2 DAYS BECAUSE NO FAULT INFORMATION WAS PROVIDED BY ON-BOARD DIAGNOSTIC COMPUTER. INITIAL SUSPICION WAS A FUEL PRESSURE PROBLEM. DEALER EVENTUALLY DETERMINED THAT RIGHT REAR WHEEL BEARING FAILED, WHICH CAUSED ABS SYSTEM FAULT, WHICH SIGNALED ENGINE NOT TO EXCEED 35 MPH. BEARING REPLACED. STILL WORKING THROUGH DETAILS WITH MY LOCAL DEALER AND VOLVO ZONE REP. I HAVE ALSO EXPERIENCED MANY OF THE ELECTRICAL, TURBO BACK-PRESSURE "HOWL", AND FIT-AND-FINISH PROBLEMS (LOOSE MOLDINGS, DRIVER'S DOOR HANDLED) THAT HAVE BEEN REFERENCED BY OTHERS. NOT WHAT I EXPECTED FOR A VEHICLE IN THIS CATEGORY. *AK

I OWN A VOLVO XC90 T6 AWD. THIS CAR HAS HAD PROBLEMS WITH THE TWIN TURBO-CHARGERS, THE WARNING LIGHTS, A TIRE BLOWOUT, VIBRATIONS IN THE STEERING WHEEL, ALIGNMENT ISSUES, SHORT CIRCUIT IN THE DRIVER'S SIDE CONTROL PANEL, POOR FIT AND FINISH OF THE DRIVER SIDE DOOR PANEL AND A HOST OF OTHER FIT AND FINISH PROBLEMS. THE MOMENTUM VOLVO DEALERSHIP IN HOUSTON, TEXAS AND VOLVO NORTH AMERICA SERVICE REPRESENTATIVE DENIED ANY PROBLEMS BEING A SERIOUS OR RECURRING PROBLEM. THIS ALL TOOK PLACE IN A SPAN OF LESS THAN 10 MONTHS FOR A BRAND NEW VEHICLE.THE CAR SPENT MORE TIME IN THE SHOP THAN IN OUR POSSESSION INITIALLY. THE DEALERSHIP CONTINUED TO FIX THE RECURRING PROBLEMS AND DENIED ANY CHRONIC ISSUES EXISTED. I WISH TO ALERT NHTSA IN THE EVENT ANY OTHER OWNER OF VOLVO XC 1990 HAS SIMILAR COMPLAINTS OR A TRAGEDY OCCURS AS A RESULT OF THE PROBLEMS I HAVE LISTED. *AK

I WAS INVOLVED IN A REAR-END COLLISION WITH MY 2 CHILDREN IN A VOLVO XC90. MY SEAT BACK FAILED DURING THE ACCIDENT AND I AM NOT REFERRING TO THE WHIPS SYSTEM. I SUSTAINED MULTIPLE INJURIES INCLUDING A WHIPLASH INJURY AS WELL AS INJURIES OF MY BACK AND LEFT SHOULDER THAT I BELIEVE WERE EXACERBATED BY THE SEAT BACK ASSUMING A FAIRLY RECLINED POSITION. I ALSO FEAR THAT IF EITHER OF MY CHILDREN HAD BEEN SITTING BEHIND THE DRIVERS SEAT (ESPECIALLY IN A REAR-FACING INFANT SEAT) THEY COULD HAVE BEEN SERIOUSLY INJURED AS A RESULT OF THIS FAILURE OF THE SEAT BACK. THE VOLVO DEALER/REPAIR SHOP HAS IMPLIED THAT MY WEIGHT HAD SOMETHING TO DO WITH THIS FAILURE. I WEIGHED ABOUT 218-222 POUNDS AT THE TIME OF THE ACCIDENT. *LA

FOR BOTH OUR 2001 VOLVO S60 2.4T AND OUR 2003 VOLVO XC90 2.5T AWD THERE HAVE BEEN UNSUCCESSFUL ATTEMPTS TO REPAIR A TRANSMISSION DEFECT (ESSENTIALLY SAME TRANSMISSION IN BOTH VEHICLES PER VOLVO TECH SUPPORT). BETWEEN 2ND AND 3RD THERE IS INTERMITTENT/UNPREDICTABLE FAILURE TO ENGAGE 3RD IN TIMELY FASHION WITH RESULTANT LOSS OF ACCELERATION AS VEHICLE IS FUNCTIONALLY IN NEUTRAL WITH ENGINE RACING FOR ~0.5-2.5 SECONDS. THIS CAN BE EXTREMELY DANGEROUS ESPECIALLY WHEN PULLING ON TO A HIGHWAY. WE HAVE EXPERIENCED 2 NEAR COLLISIONS (ALMOST BEING STRUCK FROM BEHIND). VOLVO TECH SUPPORT ACKNOWLEDGES A FLAW IN ENGINEERING WHEREBY SERVO FLUID AIR LOCK OCCURS IN THE 2001. A NEW TRANSMISSION IS SCHEDULED TO BE REPLACED FOR OUR S60, BUT IF THE PROBLEM IS STILL OCCURING IN OUR 2003, WILL THIS REALLY CORRECT THE PROBLEM AS THE TRANSMISSIONS ARE BASICALLY IDENTICAL? THE 2003 XC90 VOLVO SAYS CAN BE REPAIRED WITH "UPGRADED SOFTWARE" (WHICH IS SCHEDULED FOR THAT VEHICLE) BUT THIS REMEDY FAILED WHEN PERFORMED ON OUR 2001 S60. WE HAVE LET THE DEALER KNOW WE FEEL BOTH VEHICLES ARE UNSAFE WITH THIS PROBLEM AND WE ARE NOW STUCK WITH THEM TRYING TO REMEDY BOTH VEHICLES' GLARING DEFECTS. WE ARE NOT AWARE OF A FEDERALLY MANDATED RECALL TO REPAIR THIS VOLVO ACKNOWLEDGED (SAFETY) DEFECT. CAN NHTSA PURSUE THIS? *AK