On 9/1/25 while driving 25 mph in the neighborhood the car started shifting very hard. Upon getting back in the driveway and put in park all dashboard light came on. Car would not leave park, parking brake would not work. Windows would not roll down, dash would not turn on, car would not turn off. Got it to the dealership and th…
Read full complaint
On 9/1/25 while driving 25 mph in the neighborhood the car started shifting very hard. Upon getting back in the driveway and put in park all dashboard light came on. Car would not leave park, parking brake would not work. Windows would not roll down, dash would not turn on, car would not turn off. Got it to the dealership and the told me it was a software update that needed to be done.
NHTSA ODI #11684876
Mileage unknown · Sep 27, 2023
Electrical SystemUnknown Or Other
The drainage system from the roof of the vehicle is faulty and causes water to collect in the space between the carpet in the interior of the vehicle and the floor of the vehicle. Key electrical components are located beneath the front passenger seat of the vehicle. When the water collected, it caused key systems, such as collis…
Read full complaint
The drainage system from the roof of the vehicle is faulty and causes water to collect in the space between the carpet in the interior of the vehicle and the floor of the vehicle. Key electrical components are located beneath the front passenger seat of the vehicle. When the water collected, it caused key systems, such as collision warning and other systems to malfunction. When we took the vehicle to the dealership, several other vehicles had to be towed in due to more severe electrical failure as a result of the drainage malfunction.
NHTSA ODI #11546744
Mileage unknown · Apr 4, 2022
SuspensionUnknown Or OtherVehicle Speed Control
The entire vehicle shakes and vibrates violently at 50 mph and over.
NHTSA ODI #11459539
Mileage unknown · Apr 22, 2021
Electrical SystemExterior LightingUnknown Or Other
WHILE I WAS DRIVING IN A BUSY MULTILANE CITY TRAFFIC SITUATION, THE CAR'S CENTER CONSOLE WENT COMPLETELY BLANK AND THE TURN SIGNALS, HAZARD LIGHTS, AND VOLVO ON CALL WERE NOT FUNCTIONING PROPERLY. I AM NOT SURE WHAT ELSE WAS AFFECTED. THIS CONTINUED FOR A FULL 1-2 MINUTES, UNLIKE TIMES BEFORE WHEN THE SYSTEM HAS DONE THE SAME …
Read full complaint
WHILE I WAS DRIVING IN A BUSY MULTILANE CITY TRAFFIC SITUATION, THE CAR'S CENTER CONSOLE WENT COMPLETELY BLANK AND THE TURN SIGNALS, HAZARD LIGHTS, AND VOLVO ON CALL WERE NOT FUNCTIONING PROPERLY. I AM NOT SURE WHAT ELSE WAS AFFECTED. THIS CONTINUED FOR A FULL 1-2 MINUTES, UNLIKE TIMES BEFORE WHEN THE SYSTEM HAS DONE THE SAME THING BUT QUICKLY RE-BOOTED. THE SAFETY OF OTHERS AND MYSELF WAS COMPROMISED, AS I NEEDED TO CHANGE LANES TO GET ONTO THE INTERSTATE. I COULD NOT TELL IF MY SIGNALS WERE FUNCTIONING BECAUSE THE SIGNALS WERE NOT MAKING A CLICKING SOUND AND THE FLASHING SIGNAL INDICATOR LIGHTS WERE COMPLETELY NONFUNCTIONAL. I TRIED THE HAZARD LIGHTS AS WELL, WHICH DID NOT FUNCTION. I PRESSED THE VOLVO ON CALL BUTTON, BUT NOTHING HAPPENED. WHEN I TOOK THE CAR TO THE DEALERSHIP, THE SERVICE MANAGER STATED THAT A "SOFTWARE UPDATE" WAS PERFORMED TO FIX THE PROBLEM, AND WHEN I QUESTIONED HOW I WAS TO KNOW IF THIS WOULD BE A PROBLEM IN THE FUTURE, I WAS TOLD THAT I "WOULDN'T KNOW UNLESS THERE WAS A PROBLEM" AND THEY CLAIMED TO KNOW NOTHING ABOUT WHETHER THE INCIDENT WOULD BE REPORTED TO THE NHTSA. I FEEL UNSAFE DRIVING THIS CAR NOW, WHICH IS IRONIC CONSIDERING THAT I BOUGHT A VOLVO FOR ITS PURPORTED SAFETY.
NHTSA ODI #11413363
26,000 miles · Dec 31, 2019
Unknown Or Other
IN A STATIONARY POSITION, TAILGATE DOES NOT FULLY LATCH WHEN BUTTON PRESSED TO CLOSE IT. HAVE TO MANUALLY PUSH TAILGATE DOWN FOR IT TO FULLY LATCH. DEALERSHIP WAS UNABLE TO FIX THE PROBLEM. PROBLEM HAS BEEN PRESENT SINCE PURCHASE.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Consequence & remedy
Consequence: A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
Remedy: Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Consequence & remedy
Consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
Additional source detail variants (2)
Electrical System:wiring:fuses And Circuit Breakers
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
Fuel System, Gasoline:delivery:fuel Pump
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Consequence & remedy
Consequence: The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Remedy: Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
Additional source detail variants (2)
Visibility/wiper
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Consequence: The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Remedy: Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
Visibility:windshield Wiper/washer:linkages
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Consequence: The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Remedy: Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
Consequence & remedy
Consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
Consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
Consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
Volvo Car USA LLC (Volvo) is recalling certain 2018-2019 XC60 and S90 vehicles. The driver and passenger front seat rail rear flange nuts may not have been installed during assembly.
Consequence & remedy
Consequence: If the nuts are missing, in the event of a crash, the front seat structure and position may be affected, increasing the risk of injury.
Remedy: Volvo will notify owners, and dealers will inspect the front seat rails for missing flange nuts, installing them as necessary, free of charge. The recall began May 7, 2019. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R19931.
Volvo Car USA LLC (Volvo) is recalling certain 2018-2019 Volvo XC60 vehicles. Under certain conditions and cold temperatures, the tailgate lifting arms may freeze which may cause the lifting arms to separate from the vehicle.
Consequence & remedy
Consequence: If the tailgate lifting arms separate, the arms could project rearward with significant force, increasing the risk of injury.
Remedy: Volvo has notified owners, and dealers will replace the tailgate lift arms with an improved designed, free of charge. The recall began May 14, 2019. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89910.
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
Consequence & remedy
Consequence: If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
Remedy: Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
Volvo Car USA LLC (Volvo) is recalling certain 2019 Volvo XC60 hybrid electric vehicles, equipped with certain AeroVironment electric vehicle TurboCord and TurboDock/TurboDX charging systems. Capacitors within these charging systems may fail, possibly resulting in a shock hazard or a fire.
Consequence & remedy
Consequence: An electrical shock or a fire can increase the risk of injury or death.
Remedy: Volvo will notify owners, and dealers will inspect the charge cord, replacing it as necessary, free of charge. The recall began November 1, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39901. Note: Owners are advised not to use the charging cord until it is inspected.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2019 Volvo XC60 Problems, Complaints & Recalls | Skip That Year
Illustration