2012 Volvo XC60

My left front door failed to open using the outside handle. I have tried unsuccessfully to fix the problem by removing the inside door panel, the door window, and the surrounding hardware and electrical components. I contend that this is a safety hazard because a)a rescuer would fail to get the driver out of the vehicle in case of an accident and b)the door could open while driving because the latch contains a defective part. Other Volvo models have been recalled because of this problem, but my Vin number is currently not included in the recall. I contend that it should be recalled for my vehicle.

SEVERE INTERIOR WATER LEAK FROM TOP OF WINDSHIELD WHENEVER IT RAINS, DURING A CARWASH, ETC. - CREATING VISIBILITY PROBLEMS FOR THE DRIVER & A RESULTING SAFETY HAZARD SINCE THE WINDSHIELD IS NOT SUITABLY SEALED. THE VEHICLE HAS BEEN GARAGE PARKED, NEVER BEEN IN ANY TYPE OF COLLISION, AND NEVER BEEN DAMAGED IN ANY WAY. WINDSHIELD LEAKAGE IS A COMMON ISSUE WITH VOLVOS, EVEN THOUGH THE MANUFACTURER AND LOCAL DEALERSHIPS CONTINUE TO DENY THERE IS A PROBLEM.

THE VEHICLE'S WINDSHIELD HAS BEEN LEAKING WATER THROUGH THE TOP OF THE DASHBOARD. WHEN IT RAINS, THE WINDSHIELD LEAKS ALL OVER. I HAVE BEEN FOLLOWING FORUMS AND IT IS A COMMON PROBLEM IN THIS PARTICULAR MODEL OF VOLVO BUT HAS NOT BEEN A RECALL. IF THIS CONTINUES I'M AFRAID SOMEONE DRIVING COULD LOOSE VISIBILITY IF ITS RAINING. EVEN THROUGH THE CARWASH THIS VOLVO MODELS LEAK WATER. SOMETHING NEEDS TO BE DONE.

I BOUGHT MY XC60 IN 2012 FROM GERALD JONES VOLVO IN EVANS, GA. APPROXIMATELY IN 2017 MY WIFE NOTICE WATER COMING INSIDE THE CAR FROM THE WINDSHIELD ON THE DRIVER'S SIDE. AT THAT TIME, I HAD THE DEALERSHIP LOOK AT THE WINDSHIELD AND SUNROOF. THEY FOUND NOTHING WRONG. THE WATER CONTINUED TO LEAK IN THE CAR, BUT IN JULY 2017, THE NAVY TRANSFERRED ME TO JAPAN AND THE CAR WAS STORED IN A MILITARY APPROVED FACILITY. I WAS NOT ABLE TO GET THE WINDSHIELD REPAIRED PRIOR TO LEAVING OVERSEAS. WHEN WE RETURNED IN JULY 2019, WE WERE REMINDED OF THE LEAK WHEN WE TOOK THE CAR THROUGH A CARWASH. FINALLY, ON 10 JAN 2020 AFTER I MADE THE CLAIM WITH MY INSURANCE COMPANY, I TOOK IT TO SAFELITE IN FALLSCHURCH, VA. THE TECHNICIANS CHECKED THE WINDSHIELD AND THEY COMMENTED THAT THEY HAVE SEEN A LOT OF VOLVO'S WITH FACTORY INSTALL ISSUES WITH WINDSHIELDS. I CHECKED YOUR WEBSITE FOR RECALLS AND THERE WERE NONE. WHEN THE TECHNICIANS REMOVED IT THEY FOUND THAT THE SEAL WAS NEVER BONDED TO THE WINDSHIELD AT THE VERY TOP OF THE WINDSHIELD AND THE WINDSHIELD WAS LOOSE ALL ALONG THE ROOFLINE. I'VE ATTACHED PICTURES. I BELIEVE THIS IS A MAJOR SAFETY PROBLEM. I SEARCHED THE INTERNET FOR OTHERS THAT HAD SIMILAR COMPLAINTS AND FOUND A LOT OF PEOPLE WITH THIS SAME YEAR, MAKE, AND MODEL HAVE COMPLAINED. THIS SHOULD BE A MANDATORY SAFETY RECALL. THERE APPEARS TO BE A SERIOUS PROBLEM WITH THESE VEHICLES AND COULD CAUSE SERIOUS INJURIES IN A COLLISION, IF NOT DEATH. THIS DEFECT IS CONSISTENT WHETHER WE ARE IN MOTION OR SITTING STILL. IT LEAKS ALL THE TIME.

DURING RAIN, THE DRIVER'S SIDE OF THE WINDSHIELD LEAKS. WITH RESEARCH OF THE ISSUE, MANY PEOPLE HAVE COMPLAINED. THE PROBLEM IS PRESENT DUE TO A PRIMER ON THE GLASS THAT IS FAILING. THIS BLACK PRIMER IS APPLIED IN A THIN LAYER TO THE WINDSHIELD. THE ADHESIVE BEING USED BY VOLVO, REQUIRES THIS PRIMER PROMOTE A PROPER BOND BETWEEN THE GLASS AND THE ADHESIVE (POLYURETHANE). HOWEVER, THIS PRIMER IS SEPARATING FROM THE GLASS. THE BIGGEST CONCERN VOLVO OWNERS SHOULD BE AWARE OF IS NOT THE POTENTIAL OF A WATER LEAK. THE WINDSHIELD IS A STRUCTURAL COMPONENT OF THE VEHICLE. IF THE WINDSHIELD IS NOT BONDED TO THE VEHICLE PROPERLY IT WILL COMPROMISE THE SAFETY OF THE OCCUPANTS IN THE EVENT OF AN ACCIDENT. THE WINDSHIELD SUPPORTS THE AIRBAGS UPON DEPLOYMENT, CRUMPLE ZONE FUNCTION DURING A COLLISION, AND THE ROOF IN THE EVENT OF A ROLLOVER.

OVER A PERIOD OF THE LAST 45 DAYS ON TWO SEPARATE OCCASIONS,IN RAIN, AT HIGHWAY SPEED OF 55MPH+, THE OVERALL PERFORMANCE OF THE DRIVER INPUTS FAILED TO FUNCTION. WHEN DRIVING, TURNING THE WHEEL TO LEFT/RIGHT TO CHANGE LANES OR PULL TO THE SLOW LANE; MADE THE CAR FEEL AS IT WANTED TO SPIN OUT UNCONTROLLABLY.TO MOVE THE STEERING WHEEL LEFT, THE CAR WANTED TO GO RIGHT. WHEN GOING STRAIGHT THERE WAS A WOBBLY UNSTABLE FEELING, AND WAS NOTICEABLE TO PASSENGERS IN THE CAR. THE ISSUE DID NOT OCCUR AT LOWER SPEEDS AND CAR PERFORM NORMALLY. THE SENSATION WAS SIMILAR TO THE INPUT ON A BOAT. THE ONLY CORRECTION WHICH WORKED WAS TO SLOW DOWN TO 40-45 AND TAKE SIDE ROADS. AT LOWER SPEEDS BRAKE TESTING AND OTHER MANEUVERS WERE PERFORMED WITHOUT ISSUE.