Service Brakes. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Back Over Prevention. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports0 fire reports3 injury reports

Power Train complaints

3 reports

Clear category filter

Mileage unknown · Mar 29, 2026

Electrical SystemPower TrainService Brakes

Brake system failed. I was NOT in one pedal mode. I have up to date software. After break system failed I was unable to put vehicle in park. Parking break could not be applied. Could not turn car off or lock doors. I was driving on interstate when it occurred. I got multiple warnings on display. I was lucky to pull over and no…

Read full complaint

NHTSA ODI #11727849

Mileage unknown · Sep 22, 2025

Electrical SystemPower Train

Read full complaint

2024 Volvo xc40 with 10,000 miles suddenly became completely disabled on the express lane of a highway. The flashers were inoperable. The windows could not be opened. Road ranger was called. Nothing was wrong with the battery. Car was towed to a safe spot. Car was taken to Volvo dealership. Volvo determine that serpentine belt came apart and the tensioner was the cause - a manufacturer defect. This was very dangerous situation for the driver and unusual for a car with such low miles to have such a break in the serpentine belt. Fortunately there was an accident ahead and cars were traveling slowly in the express lane.

NHTSA ODI #11688879

Mileage unknown · Aug 11, 2025

Power TrainService BrakesUnknown Or Other

Read full complaint

I pulled over right side of street to park behind a parked vehicle to a visit house across the street. Was too far out from curb so I backed up about 12-15 feet or so. Put car in drive and slowly started to drive toward curb when car suddenly accelerated very hard. I turned steering to left to avoid hitting the car in front, straightened car out but could not stop it until it stopped about 20-30 feet down the road. Brake was not stopping my car. The acceleration was something like being on a ramp to get on highway and pressing pedal down to get to highway speed. It was a very hard acceleration. Very frightening. I got an appointment tomorrow for volvo service to look at this. Drove the car after this happened and today without any incident. I bought the car new in Mar 2024 and have NEVER experience this.

NHTSA ODI #11679819

Official recalls

25V908000 · Back Over Prevention:software

Dec 23, 2025

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: A rearview camera image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed February 24, 2026. Owners may contact Volvo Car’s customer service at 1-800-458-1552. Volvo Car's number for this recall is R10333. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 16, 2026. This recall replaces previous NHTSA recall number 25V282. Vehicles previously repaired under recall 25V282 will need to have the new remedy performed.

25V392000 · Service Brakes; Service Brakes, Hydraulic:power Assist:electric:control Module:software

Jun 12, 2025

Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 Volvo C40 BEV, 2025 EC40, 2023-2024 XC40 BEV, 2020-2026 XC90 PHEV, 2022-2026 XC60 PHEV, 2023-2025 S60 PHEV, 2024-2025 V60 PHEV, and 2025-2026 EX40 and 2025 S90 PHEV vehicles. In certain driving scenarios while coasting down a hill and using "B" mode or "One Pedal Drive," the vehicle may lose brake function.

Consequence & remedy

Consequence: A loss of brake function increases the risk of a crash.

Remedy: Owners are advised not to use "B" Mode (for plug-in hybrid vehicles) or "One Pedal Drive" (for pure electric vehicles) until the repair has been completed. The brake module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed July 15, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10329.

Additional source detail variants (2)

Service Brakes

Consequence: A loss of brake function increases the risk of a crash.

Remedy: Owners are advised not to use "B" Mode (for plug-in hybrid vehicles) or "One Pedal Drive" (for pure electric vehicles) until the repair has been completed. The brake module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed July 15, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10329.

Service Brakes, Hydraulic:power Assist:electric:control Module:software

Consequence: A loss of brake function increases the risk of a crash.

25V282000 · Back Over Prevention:software

May 8, 2025

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: A rearview camera image that does not display reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.

Remedy: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10320.

24V010000 · Electrical System:software

Jan 10, 2024

Volvo Car USA, LLC (Volvo Car) is recalling certain 2024 XC40 vehicles. A diagnostic error in the Central Electronic Module (CEM) software may cause the left rear turn signal indicator to not function.

Consequence & remedy

Consequence: A nonfunctioning exterior turn signal may not notify other drivers of a turning vehicle, increasing the risk of a crash.

Remedy: The CEM software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed February 16, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10256.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.