WHILE DRIVING, STEERING WHEEL LOCKED UP, CAUSING LOSS OF CONTROL AND AN ACCIDENT, CONSUMER STATED THAT THE STEERING LOCKED LIKE WHEN HAVING A FLAT TIRE, CONSUMER WAS INJURED AFTER REPAIRS, CONSUMER DROVE VEHICLE WHEN THE STEERING LOCKED AGAIN, THE HEAT VENT FOR THE DASH WAS FOUND STUCK IN THE STEERING WHEEL COLUMN, HOWEVER CONSU…
Read full complaint
WHILE DRIVING, STEERING WHEEL LOCKED UP, CAUSING LOSS OF CONTROL AND AN ACCIDENT, CONSUMER STATED THAT THE STEERING LOCKED LIKE WHEN HAVING A FLAT TIRE, CONSUMER WAS INJURED AFTER REPAIRS, CONSUMER DROVE VEHICLE WHEN THE STEERING LOCKED AGAIN, THE HEAT VENT FOR THE DASH WAS FOUND STUCK IN THE STEERING WHEEL COLUMN, HOWEVER CONSUMER WAS INFORMED THIS WAS CAUSED FROM THE ACCIDENT. *SLC
NHTSA ODI #565375
Mileage unknown · May 30, 2002
Power TrainService Brakes, AirSteering
CONSUMER STATES EXPERIENCING PROBLEMS WITH WIRING HARNESS UNDER THE DASH. ON SEVERAL OCCASISIONS THE DASH LIGHTS AND GAUGES OPERATE ERRATICALLY. *TT
NHTSA ODI #565933
Mileage unknown · May 30, 2002
SuspensionUnknown Or Other
CONSUMER IS EXPERIENCING PROBLEMS WITH THE DASH. *TT
NHTSA ODI #565931
Mileage unknown · May 13, 2002
EquipmentSuspensionUnknown Or Other
THE LED DISPLAY THAT CARIES THE VOLMETER FAILED AND WAS REPLACED, BUT FAILED AGAIN. TWO GAUGE ARRAYS ON THE DASH DO NOT HAVE LIGHTS. *YH
NHTSA ODI #565631
Mileage unknown · Apr 1, 2002
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
THE WEIGHT OF THE TRUCK CAUSED MANY PROBLEMS, VOLVO REPLACED THE FRONT SPRINGS WITH HEAVIER ONES, THE RIDE HEIGHT AND REAR END PITCH WAS ADJUSTED SEVERAL TIMES, THE AIR ROD AND AIR RIDE VALVE WERE REPLACED, REAR AXLE WAS ALIGNED, VEHICLE EXPERIENCED HIGH TIRE WEAR, VIBRATION CONTINUED TO OCCUR AFTER SEVERAL ATTEMPTS TO REMEDY TH…
Read full complaint
THE WEIGHT OF THE TRUCK CAUSED MANY PROBLEMS, VOLVO REPLACED THE FRONT SPRINGS WITH HEAVIER ONES, THE RIDE HEIGHT AND REAR END PITCH WAS ADJUSTED SEVERAL TIMES, THE AIR ROD AND AIR RIDE VALVE WERE REPLACED, REAR AXLE WAS ALIGNED, VEHICLE EXPERIENCED HIGH TIRE WEAR, VIBRATION CONTINUED TO OCCUR AFTER SEVERAL ATTEMPTS TO REMEDY THE PROBLEM, VEHICLE WAS EVENTUALLY TURNED BACK IN. *SLC
NHTSA ODI #564875
Mileage unknown · Aug 15, 2001
SuspensionUnknown Or Other
U-BOLTS PROBLEMS; CONSUMER LISTED PHONE NUMBER AS 336-918-07824. *SLC
NHTSA ODI #565080
Mileage unknown · Aug 15, 2001
Unknown Or Other
VEHICLE IS EXPERIENCING DASH PROBLEMS. *JG
NHTSA ODI #565076
Mileage unknown · Aug 15, 2001
Electrical SystemEngine And Engine CoolingEquipment
CONSUMER REPLACED U-BOLT, EXPERIENCED PROBLEMS WITH THE REAR AND FRONT SUSPENSION, FRONT STRUT/SHOCK AND TIRE/WHEEL. *YD
NHTSA ODI #565075
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA04016 · Steering Binding
Opened Jun 24, 2004 · Closed Mar 31, 2005
Status: closed (inferred from source dates) · Steering; Steering:column
ODI'S INVESTIGATIONCONCLUDED THAT THE LEGS THAT RETAIN THE TURN SIGNAL CANCELING RING (TSCR), PART NUMBER 1607363, TO THE STEERING WHEEL INSTALLED IN MODEL YEAR 1998 - 1999 VN AND VHD SERIES VTNA (VOLVO TRUCK NORTH AMERICA) VEHICLES ARE PRONE TO CRACKING AND BREAKING.WHEN THE RETENTION LEGS BREAK, THE SEPARATED PIECES OF THE TSCR TYPICALLYREPOSE IN THE HOST CAVITY IN THE STEERING WHEEL HUB WHERE THEY WERE DEPOSITED.ODIFOUND THAT BROKEN PIECES OF THE TSCR EITHER (1) MIGRATED FROM THEIR HOST CAVITY AND DROPPED COMPLETELY FROM THE STEERING WHEEL ASSEMBLY OR (2) LODGED IN VARIOUS AREAS OF THE STEERING WHEEL PROXIMATE TO THE TSCR.ODI SIMULATED VARIOUS LOCATIONS AND POSITIONS THAT A SEPARATED PIECE OF THE TSCR MIGHT BECOME LODGED WITHIN THE STEERING WHEEL ASSEMBLY, BUT NONE OF THESE SIMULATIONS GENERATED ANY APPRECIABLE INCREASE IN STEERING EFFORT.
Additional source detail variants (2)
Steering:column
ODI'S INVESTIGATIONCONCLUDED THAT THE LEGS THAT RETAIN THE TURN SIGNAL CANCELING RING (TSCR), PART NUMBER 1607363, TO THE STEERING WHEEL INSTALLED IN MODEL YEAR 1998 - 1999 VN AND VHD SERIES VTNA (VOLVO TRUCK NORTH AMERICA) VEHICLES ARE PRONE TO CRACKING AND BREAKING.WHEN THE RETENTION LEGS BREAK, THE SEPARATED PIECES OF THE TSCR TYPICALLYREPOSE IN THE HOST CAVITY IN THE STEERING WHEEL HUB WHERE THEY WERE DEPOSITED.ODIFOUND THAT BROKEN PIECES OF THE TSCR EITHER (1) MIGRATED FROM THEIR HOST CAVITY AND DROPPED COMPLETELY FROM THE STEERING WHEEL ASSEMBLY OR (2) LODGED IN VARIOUS AREAS OF THE STEERING WHEEL PROXIMATE TO THE TSCR.ODI SIMULATED VARIOUS LOCATIONS AND POSITIONS THAT A SEPARATED PIECE OF THE TSCR MIGHT BECOME LODGED WITHIN THE STEERING WHEEL ASSEMBLY, BUT NONE OF THESE SIMULATIONS GENERATED ANY APPRECIABLE INCREASE IN STEERING EFFORT.
Steering
ODI'S INVESTIGATIONCONCLUDED THAT THE LEGS THAT RETAIN THE TURN SIGNAL CANCELING RING (TSCR), PART NUMBER 1607363, TO THE STEERING WHEEL INSTALLED IN MODEL YEAR 1998 - 1999 VN AND VHD SERIES VTNA (VOLVO TRUCK NORTH AMERICA) VEHICLES ARE PRONE TO CRACKING AND BREAKING.WHEN THE RETENTION LEGS BREAK, THE SEPARATED PIECES OF THE TSCR TYPICALLYREPOSE IN THE HOST CAVITY IN THE STEERING WHEEL HUB WHERE THEY WERE DEPOSITED.ODIFOUND THAT BROKEN PIECES OF THE TSCR EITHER (1) MIGRATED FROM THEIR HOST CAVITY AND DROPPED COMPLETELY FROM THE STEERING WHEEL ASSEMBLY OR (2) LODGED IN VARIOUS AREAS OF THE STEERING WHEEL PROXIMATE TO THE TSCR.ODI SIMULATED VARIOUS LOCATIONS AND POSITIONS THAT A SEPARATED PIECE OF THE TSCR MIGHT BECOME LODGED WITHIN THE STEERING WHEEL ASSEMBLY, BUT NONE OF THESE SIMULATIONS GENERATED ANY APPRECIABLE INCREASE IN STEERING EFFORT.
PE04014 · Steering Binding
Opened Feb 5, 2004 · Closed Jun 24, 2004
Status: closed (inferred from source dates) · Steering
ODI'S PRELIMINARY EVALUATION FOCUSED ON THE POTENTIAL FOR A BROKEN, BENT, DEFORMED, FRAGMENTED OR DISPLACED TURN SIGNAL CANCELING RING (TSCR), VTNA PART NUMBER 1607363, TO RESTRICT THEVEHICLE OPERATOR'S ABILITY TO TURN THE STEERING WHEEL.THE PE IDENTIFIED THIRTEEN VTNA WARRANTY CLAIMS THAT ALLEGE THAT THE TSCR HAD FAILED AND THAT THE VEHICLE STEERING EFFORT HAD BEEN ADVERSELY AFFECTED.TO DATE, ODI HAS NOT FOUND ANY SAMPLES OF A FAILED TSCR AND HAS NOT BEEN ABLE TO DEFINITIVELY ESTABLISH WHETHER A FAILED TSCR CAN OR CANNOT CONTRIBUTE TO INCREASED STEERING EFFORT.ODI BELIEVES THAT IT IS APPROPRIATE TO CONDUCT FURTHER INVESTIGATION(EA LEVEL) TO BETTER UNDERSTAND THE CHARACTERISTICS OF TSCR FAILURES AND TO ASSESS THE EFFECT, IF ANY, THAT THESE TYPES OF FAILURES COULD HAVE ON VEHICLE STEERING EFFORT.
EA02021 · Front Suspension U-BOLTS Loosen Or Break
Opened Sep 6, 2002 · Closed Nov 6, 2003
Status: closed (inferred from source dates) · Suspension
ODI'SINVESTIGATION DID NOT FIND ANY EVIDENCE THAT LOOSE OR BROKENFRONT SUSPENSION U-BOLTS HAVE CAUSED OR CONTRIBUTED TO ANY CRASHES OR NEAR MISS EVENTS.SEE THE ATTACHED ENGINEERING ANALYSISREPORT FOR FULL TECHNICAL DETAILS.* 1996/1997 BUILT VEHICLES ARE DESIGNATED BY VOLVO AS 1998 MODEL YEAR.
PE01040 · Sleeper Berth Fires
Opened Dec 3, 2001 · Closed Mar 26, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE01041 · Steering Gearbox Or U-JOINT
Opened Dec 3, 2001 · Closed Jun 14, 2002
Status: closed (inferred from source dates) · Steering
No summary supplied.
PE01042 · Steering Axle U-BOLT
Opened Dec 3, 2001 · Closed Sep 6, 2002
Status: closed (inferred from source dates) · Steering
No summary supplied.
1998 Volvo VN610 Problems, Complaints & Recalls | Skip That Year
Illustration