2004 Volvo V70

TL*THE CONTACT OWNS A 2004 VOLVO V70. WHILE DRIVING APPROXIMATELY 60 MPH ON NORMAL ROAD CONDITIONS, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE ENGINE STALLED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE FAILURE WAS RELATED TO THE FUEL PRESSURE SENSOR. THE VEHICLE WAS REPAIRED. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING), ALTHOUGH THE FAILURES WERE IDENTICAL. THE FAILURE MILEAGE WAS 28,900 AND CURRENT MILEAGE WAS 29,000. UPDATED 12/01/08. *LJ UPDATED 12/01/08. *JB

MY REGULARLY SERVICED VOLVO WAGON'S "SERVICE ENGINE" LIGHT CAME ON. LIKE A GOOD CUSTOMER, TOOK IT TO THE DEALERSHIP. THEY DETERMINED IT TO BE A DEFECT IN THE LEAK DETECTION PROBLEM. SOAKED ME FOR OVER $500 FOR THE REPAIR, WHICH THEY STARTED WITHOUT MY PERMISSION. THE CAR ONLY HAS 50,770 MILES ON IT AND IS A 2004, PURCHASE IN JAN. '04. I AM BEGINNING TO THINK IT IS A CASE OF PRE-PLANNED FAILURE. PLEASE HELP!! *TR

WE RECENTLY HEARD A LOUD "GROWL" COMING FROM THE LEFT REAR WHEEL. THE NOISE GREW FROM A SLIGHT WHINE TO A MODERATE GROWL AS WE HEADED HOME, A JOURNEY OF ~700 MILES. THE SHOP REPLACING THE BEARING STATED THEY HAD HAD A HUGE INCREASE IN VOLVO AWD REAR BEARINGS OF LATE. MODELS FROM '02 THROUGH 07 WITH MILEAGE OF 40-90,000 BEING ABNORMALLY AFFECTED. HAD THE BEARING BEEN ALLOWED TO GET WORSE, THERE COULD HAVE BEEN DEATHS. EVER SEEN A WHEEL FALL OFF AT 60 MPH? *TR

2004 VOLVO V70 2.5T TIRE DEFECT CUSTOMER STATES HE PROVED "V" AND "H" RATED PIRELLI ARE EXACTLY THE SAME IN DIMENSION CAUSING THE EXACT SAME PROBLEMS AS THE OEM TIRE. CUSTOMER WANT INVESTIGATION TO CORRECT SAFETY PROBLEM ON HIS VEHICLE NOT AT HIS EXPENSE**SB THE CONSUMER STATED THE TIRE RUBBED ON THE INNER WHEEL WELL, WHICH CAUSED THE TIRES TO WEAR PREMATURELY. *JB

VOLVO OEM TIRES ON THE 2004 V70 2.5T WITH 17" WHEELS RUB ON THE INNER WHEEL WELL WHEN DOING 1+MPH FULL TURNS. THIS CAUSES WEAR WHICH MAY AFFECT FUTURE PERFORMANCE/SAFETY. OEM TIRES ARE 235/45/17 94V PIRELLI. INDEPENDENT TEST WAS DONE AT A GOODYEAR STORE. RUBBING AREA WAS DOCUMENTED AND PHOTOGRAPHED. VOLVO REFUSES TO ACCEPT RESULTS AND DID NOT SUGGEST ANY INDEPENDENT TIRE TESTING. DEFECT MAY BE A SAFETY HAZARD WHICH THEY ARE REFUSING TO VALIDATE/VERIFY. COMPLAINTS HAVE BEEN FILED WITH THE BBB AGAINST VOLVO DEALERSHIP AND WITH THE NEW JERSEY ATTORNEY GENERALS OFFICE AGAINST VOLVO OF NORTH AMERICA. COMPLAINTS WILL BE FILED WITH THE ATTORNEY GENERALS OF NC AND MI. *TR

THIS IS THE FIFTH TIME THIS PROBLEM OCCURRED, THE LAST ONE BEING YESTERDAY ON 5/7/07. IT HAPPENED THE FIRST TIME ON 9/25/06, THEN 10/03/05, 8/1/06 . DEALER CALLED ON 08 /04/06 , AND SAID CAR WAS READY. HUSBAND CRANKED CAR AND HAD SAME PROBLEM AGAIN. THIS TIME DEALER KEPT CAR UNTIL 8/15/06 , AND HAD NOT HAD PROBLEM AGAIN UNTIL YESTERDAY, AND IT WAS THE SAME PROBLEM AGAIN. DRIVING ABOUT 50 MPH THE ENGINE HESITATED ABOUT THREE TIMES AND THEN THE ELECTRICAL SYSTEM FAILED. THE ENGINE KEPT RUNNING THOUGH NOT AT FULL POWER. THE BRAKES WERE OPERATIVE , BUT THE PEDAL WENT ALMOST TO THE FLOOR. ALL GAUGES FLICKERED AND WENT BLANK. THE AIR CONDITIONER (A/C) FAN KEPT RUNNING, BUT THERE WAS NO COOL AIR. THE WINDOWS WILL NOT OPERATE, THE TURN SIGNALS WILL NOT OPERATE, THERE WERE NO BRAKE LIGHTS. AND I WAS SCARED. WILL TAKE TO DEALER AGAIN TODAY. *AK

2000 V70XCAW CROSS COUNTRY WAGON ETM SYSTEM FAILED. *TS THE AC HOSE COMPRESSOR CONDENSER WAS REPLACED. THE VEHICLE WAS LEAKING GAS AND THE O-RING SEAL ON THE PUMP SENDER WAS REPLACED. THE FRONT PASSENGER WINDOW WAS INOPERABLE WHEN TRYING TO USE THE MASTER CONTROLS. THE DEALER REPLACED THE MODULE SWITCH. THE ENGINE WOULD WHINE AT HIGHWAY SPEEDS WHILE ACCELERATING. THE BATTERY, OIL PAN, UPPER TORQUE MOUNT, ANGLE GEAR, ROTORS, FUEL PUMP, FUEL TANK, FUEL SEAL AND STRUTS WERE ALL REPLACED. THE CV BOOT WAS LEAKING. THE TURBO CHARGER WAS REPLACED BECAUSE OF AN OIL LEAK. *JB