IllustrationTL*THE CONTACT OWNS A 2001 VOLVO V70. THE CONTACT STATED THAT FUEL LEAKED FROM THE VEHICLE ONTO THE GARAGE FLOOR. THE MECHANIC STATED THAT THE FUEL SENDING UNIT CRACKED AND CAUSED THE LEAK. THE UNIT WAS REPLACED. THE DEALER WAS NOT NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE 91,000.
2001 Volvo V70
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all V70 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
2125–50K
4750–75K
4475–100K
29100–150K
15150K+
162 reports with mileage · 59 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Vehicle Speed Control. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports2 fire reports7 injury reports
What owners actually said
221 reportsTRANSMISSION WARNING LIGHT APPEARED. BROUGHT TO DEALER AND THE 'UPDATED' THE SOFTWARE WHICH WAS NOT COVERED BY MY WARRANTY. CAR NOW JERKS INTO GEAR. WARRANTY NOW EXPIRED, AND DEALER SAYS THE TRANSMISSION IS 'GOING OUT AND TIME TO TRADE UP' (BUY A NEW VOLVO) *JB
THE ROAD: 2 LANES EACH WAY, WIDE MEDIAN, PAVED SHOULDERS WHICH ROLLED OFF INTO A DRAINAGE DITCH, 60 MPH LIMIT WITH STO PLIGHTS. WHILE IN LEFT BEGAN TO PASS VEHICLE2 [SUV] IN RIGHT LANE. VEHICLE 2 MOVED INTO LEFT LANE FORCING ME ONTO SHOULDER. WHILE ON SHOULDER AND ATTEMPTING TO REENTER LANE AFTER COMPLETING PASS BEGAN TO LOSE …
Read full complaint
THE ROAD: 2 LANES EACH WAY, WIDE MEDIAN, PAVED SHOULDERS WHICH ROLLED OFF INTO A DRAINAGE DITCH, 60 MPH LIMIT WITH STO PLIGHTS. WHILE IN LEFT BEGAN TO PASS VEHICLE2 [SUV] IN RIGHT LANE. VEHICLE 2 MOVED INTO LEFT LANE FORCING ME ONTO SHOULDER. WHILE ON SHOULDER AND ATTEMPTING TO REENTER LANE AFTER COMPLETING PASS BEGAN TO LOSE CONTROL OF CAR. THAT WAS THE LAST MEMORY OF THE EVENTS LEADING UP TO THE ACCIDENT. AT THIS POINT, I BELIEVE THAT THE DRIVER'S AIRBAG DEPLOYED PREMATURELY. IT KNOCKED ME UNCOUNCIOUS, PREVENTING ME FROM TRYING TO CONTROL THE CAR. THE CAR ENDED UP CROSSING THE ROAD TO THE RIGHT SHOULDER. IT LEFT THE ROADWAY AT 20-30 DEGREE ANGLE. IT WENT DOWN INTO A DITCH, AND ROLLED UP A BANK 2-3 TIMES. IT CAME TO REST ON THE DRIVER'S SIDE. THE UPPER PASSENGER SIDE WAS CRUSHED, AND THE CAR WAS TOTALED. THE ROOF OF THE CAR WAS CUT SO THAT I COULD GET OUT RATHER THAN CRAWL THROUGH THE WINDSHIELD. THE SIDE IMPACT AIRBAGS DID NOT DEPLOY IN THE ROLLOVER. THE PASSENGER AIRBAG DID DEPLOY. MY SHOULDER/SEAT BELT WAS ON. *AK I WAS EXTREMELY FORTUNATE TO ONLY HAVE MINOR INJURIES. HOW CAN I INDISPUTABLY DETERMINE WHEN THE AIRBAG DEPLOYED? IS THERE A DATA RECORDER? DO I NEED TO HIRE AN ACCIDENT INVESTIGATOR?
BEGINNING JANUARY 2007, OUR 2001 V70 WOULD "SHIFT HARD" WHEN SHIFTING FROM "P" TO "D" OR FROM "R" TO "D" OR WHEN ACCELERATING FROM A LOW SPEED. WE THOUGHT IT WAS THE WEATHER CAUSING THE ISSUE DUE TO IT BEING INTERMITTENT. IT BECAME WORSE AND SHIFT BECAME HARDER. APPT IN APRIL CONCLUDED IT "MAY BE" THE TCM. SOFTWARE WAS UPGRA…
Read full complaint
BEGINNING JANUARY 2007, OUR 2001 V70 WOULD "SHIFT HARD" WHEN SHIFTING FROM "P" TO "D" OR FROM "R" TO "D" OR WHEN ACCELERATING FROM A LOW SPEED. WE THOUGHT IT WAS THE WEATHER CAUSING THE ISSUE DUE TO IT BEING INTERMITTENT. IT BECAME WORSE AND SHIFT BECAME HARDER. APPT IN APRIL CONCLUDED IT "MAY BE" THE TCM. SOFTWARE WAS UPGRADED AND WE WERE TOLD THERE WOULD BE AN "ADJUSTMENT" PERIOD. ALL UNDER WARRANTY. TOOK A WEEK TO FIX WHAT WAS NOTED AS ONLY NEEDING 30 MINUTES TO FIX. END OF JUNE, CALLED TO STATE SAME THING IS HAPPENING THAT THE ISSUE WASN'T FIXED. VOLVO CHECKED WARRANTY AND CONTRACT ENDED JUST THREE WEEKS PRIOR. JULY 10, TOOK V70 IN FOR "DIAGNOSTIC" AND WE NEED A "NEW TRANSMISSION". VOLVO WILL NOT TAKE RESPONSIBILITY NOR SEE THE PROBLEM AS PRE-EXISTING. NOR WILL THEY SEE THE ISSUE AS UNRESOLVED FROM THE INITIAL VISIT. NO DIAGNOSTIC APPARENTLY DONE THE FIRST TIME. COINCIDENTALLY DEALER REPORTED THERE WERE MORE ISSUES WITH THE CAR SUCH AS SUSPENSION WHICH WAS FIXED JUST RECENTLY. WE HAD PUT NO MORE THAN A FEW HUNDRED MILES ON THE CAR SINCE THE LAST VISIT AND ALL OF THESE ISSUES ARE JUST APPEARING, COINCIDENTALLY AFTER WARRANTY EXPIRED. THERE WERE NO ISSUES LESS THAN 60 DAYS AGO, AT LEAST NONE REPORTED TO US. THIS INCIDENT HAS HAPPENED TO OTHER CONSUMERS AT THE SAME DEALERSHIP. VOLVO IS NOT COOPERATIVE AND WE HAD CAUGHT THE MECHANICS IN DECEITFUL STATEMENTS BY "REMINDING" THEM THAT WAS ALREADY DEALT WITH...FUNNY HOW IT WAS NO LONGER SOMETHING THAT NEEDED TO BE FIXED. THE "NEW TRANSMISSION" IS STILL NEEDED APPARENTLY AFTER A TOTAL OF ONLY 80K MILES ON THE CAR. IT WAS AT ABOUT 42K WHEN WE BOUGHT IT IN DEC OF 2003. *TR
2001 V70 HEADLIGHT BULB SOCKET ON RUNNING LIGHTS H& BULB BURNED UP. THIS CAUSED THE HEADLIGHT ON DRIVERS SIDE TO FAIL.
CUSTOMER'S SEAT BELT ON A 2001 VOLVO V70 WOULD NOT PULL OUT. THE PLASTIC TRIM PIECE IN THE "B" PILLAR WHERE THE SEAT BELT SLIDES THROUGH HAD BROKEN, CAUSING THE BELT TO DOUBLE UP ON RETRACTION AND SEIZE UP. THIS IS A BRITTLE PIECE OF PLASTIC AND BREAKS FAIRLY OFTEN WITH MINOR IMPACTS. THIS WOULD SEEM TO BE A CRITICAL FAULT IN A …
Read full complaint
CUSTOMER'S SEAT BELT ON A 2001 VOLVO V70 WOULD NOT PULL OUT. THE PLASTIC TRIM PIECE IN THE "B" PILLAR WHERE THE SEAT BELT SLIDES THROUGH HAD BROKEN, CAUSING THE BELT TO DOUBLE UP ON RETRACTION AND SEIZE UP. THIS IS A BRITTLE PIECE OF PLASTIC AND BREAKS FAIRLY OFTEN WITH MINOR IMPACTS. THIS WOULD SEEM TO BE A CRITICAL FAULT IN A MAJOR SAFETY DEVICE.
I HAVE A 2001 VOLVO V70. I GOT A MESSAGE THAT THE LEFT HAND TURN SIGNAL BULB WAS OUT. I BOUGHT A NEW BULB TO REPLACE IT, AND IT DID NOT FIX THE PROBLEM. THE DEALER FOUND THAT IT WAS A PROBLEM WITH THE SOCKET, AND SUBSEQUENTLY REPLACED IT. THIS SOLVED THE PROBLEM. MY COMPLAINT IS THAT A RECALL FOR THIS VERY PROBLEM WAS ISSUED FO…
Read full complaint
I HAVE A 2001 VOLVO V70. I GOT A MESSAGE THAT THE LEFT HAND TURN SIGNAL BULB WAS OUT. I BOUGHT A NEW BULB TO REPLACE IT, AND IT DID NOT FIX THE PROBLEM. THE DEALER FOUND THAT IT WAS A PROBLEM WITH THE SOCKET, AND SUBSEQUENTLY REPLACED IT. THIS SOLVED THE PROBLEM. MY COMPLAINT IS THAT A RECALL FOR THIS VERY PROBLEM WAS ISSUED FOR VOLVO V70S FROM 1998-2000, (NHTSA CAMPAIGN ID NUMBER : 00V405000 ). IT SEEMS TO ME THAT THIS RECALL SHOULD BE CHANGED TO INCLUDE 2001 MODELS, AS CLEARLY, THE ISSUE WAS NOT RESOLVED WITH THE NEW MODEL YEAR. *JB
WHILE TRAVELING ON I-25 AT 65 MPH THE GLASS SUN OOF EXPLODED AND SHOWERED BOTH OF US WITH SHARDS OF GLASS. THERE WAS NO WARNING. JUST A LOUD BOOM AND THE GLASS BROKE. 2001 VOLVO STATION WAGON V-70. *AK
ANTILOCK SYSTEM AND STABILITY TRACKING SYSTEM FAILED ABRUPTLY DURING BREAKING. NO CRASH OCCURRED, ONLY THE SYSTEM'S WARNING LIGHTS CAME ON AND STAYED ON. LUCKY I WAS NOT IN A PANIC BREAK POSITION AS THEN THE ABS WOULD NOT HAVE FUNCTIONED. I HAVE MADE ARRANGEMENTS TO REPAIR THE SYSTEM INDEPENDENT OF THE VOLVO DEALERSHIP SINCE …
Read full complaint
ANTILOCK SYSTEM AND STABILITY TRACKING SYSTEM FAILED ABRUPTLY DURING BREAKING. NO CRASH OCCURRED, ONLY THE SYSTEM'S WARNING LIGHTS CAME ON AND STAYED ON. LUCKY I WAS NOT IN A PANIC BREAK POSITION AS THEN THE ABS WOULD NOT HAVE FUNCTIONED. I HAVE MADE ARRANGEMENTS TO REPAIR THE SYSTEM INDEPENDENT OF THE VOLVO DEALERSHIP SINCE IT IS MUCH CHEAPER AND A MORE EFFECTIVE FIX IS POSSIBLE THAN USING VOLVO PARTS WHICH AFTER WEB SEARCHING IS CLEARLY DEFECTIVE. SEEMS EVERY VEHICLE WITH THIS SYSTEM IS FAILING AT ABOUT 65 TO 80K MILES. MY 2001 V70 T5 FAILED AT 70K.
THE CONSUMER'S 2001 VOLVO V70 IS BEING RECALLED. **CC THE CONSUMER IS CURRENTLY STATIONED OVERSEAS AND WOULD LIKE TO KNOW HOW TO HAVE THIS RECALL WORK REPAIRED. *NM
Official recalls
821V800000 · Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module
Oct 14, 2021
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2001-2007 V70 and XC70 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed December 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10136.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2001-2007 V70 and XC70 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed December 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10136.
Air Bags:frontal
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2001-2007 V70 and XC70 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed December 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10136.
10V566000 · Equipment:electrical:navigational System(global Positioning System)
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
09V483000 · Fuel System, Gasoline:delivery:fuel Pump
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V441000 · Vehicle Speed Control
Nov 15, 2006
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
04V451000 · Engine And Engine Cooling:cooling System:fan
Sep 13, 2004
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
03V284000 · Equipment:other:labels
Aug 1, 2003
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TAKE THEIR VEHICLE TO A VOLVO DEALER FOR INSTALLATION OF THE GUIDE, IT WILL BE PERFORMED AT NO CHARGE TO THE OWNER. OWNER NOTIFICATION BEGAN ON DECEMBER 19, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
01V100000 · Seat Belts:front:anchorage
Mar 26, 2001
VEHICLE DESCRIPTION: SEDANS AND WAGONS. THE REAR OUTBOARD SEAT BELT ANCHORAGE BOLTS MAY HAVE BEEN INCORRECTLY TIGHTENED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE ANCHORAGE BOLTS AND TIGHTEN TO THE CORRECT TORQUE LEVEL. OWNER NOTIFICATION BEGAN MAY 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
01V101000 · Seat Belts:front:anchorage
Mar 26, 2001
VEHICLE DESCRIPTION: WAGONS. THE BOLTED JOINT, USED FOR ATTACHING THE BRACKET THAT IS PART OF THE INSTALLATION HARDWARE FOR THE ISOFIX-TYPE CHILD RESTRAINT, MAY HAVE BEEN INCORRECTLY TIGHTENED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE ANCHORAGE BOLTS AND TIGHTEN TO THE CORRECT TORQUE LEVEL. OWNER NOTIFICATION BEGAN MAY 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.