I TOOK MY CAR TO THE DEALER BECAUSE IT WAS NOT PASSING SMOG AND HAD TROUBLE FOR SEVERAL YEARS. SO THE SMOG DEALER TOLD ME TO TAKE IT TO THE DEALER. I TOLD THE DEALER THAT I WAS TRYING TO PASS SMOG, BUT THE CAR HAD BEEN DRIVING VERY GOOD IN SPITE OF THE SMOG PROBLEM. THEY REPLACED EVERYTHING THAT YOU CAN IMAGINE AT A COST OF OVER…
Read full complaint
I TOOK MY CAR TO THE DEALER BECAUSE IT WAS NOT PASSING SMOG AND HAD TROUBLE FOR SEVERAL YEARS. SO THE SMOG DEALER TOLD ME TO TAKE IT TO THE DEALER. I TOLD THE DEALER THAT I WAS TRYING TO PASS SMOG, BUT THE CAR HAD BEEN DRIVING VERY GOOD IN SPITE OF THE SMOG PROBLEM. THEY REPLACED EVERYTHING THAT YOU CAN IMAGINE AT A COST OF OVER 10,000 DOLLARS WHICH BOTH OF US SPENT IN A TWO MONTH PERIOD. BUT AFTER THEY GOT IT TO PASS SMOG I NOTICED ANOTHER MORE SERIOUS PROBLEM, IT WOULD STOP RUNNING IN THE MIDDLE OF TRAFFIC. I TOLD THEM ABOUT THIS NEW PROBLEM AND THEY REPLACED THE KEY AND IT STILL STOPPED ON ME 3 X ON THE FREEWAY AND STREETS. I RETURNED THE CAR GOING DOWN THE MAIN STREETS FOR 2 HOURS AND LIFT IT WITH THE COMPANY. MCKEVITT VOLVO IN SAN LEANDRO CA. THEY WANTED TO CHARGE ME BUT I TOLD THEM MY ARE DID NOT HAVE THIS PROBLEM UNTIL THEY WORKED ON IT! I NEED A WORKING CAR AND I AM IN DEPT AS A RESULT OF THEIR WORK. I AM A 65 YEAR OLD RETIRED TEACHER BUT I CAN'T AFFORD THIS DEPT. 11
WHY AREN'T YOU DOING ANYTHING ABOUT VOLVO BUILDING CRAP? THEY SHOULD BE IN JAIL. ETM - DESIGN WAS UNACCEPTABLE FROM A DAY ONE. THE ETM IS CAUSING SURGING, STALLING AND MANY OTHER SYMPTOMS. ONCE VOLVO STARTED TO REPLACE SOME OF THEM, THEY USED NEW ONES WITH EXACTLY THE SAME FLAWED DESIGN. ABS MODULE - IS KNOWN FOR CAUSING LOSS …
Read full complaint
WHY AREN'T YOU DOING ANYTHING ABOUT VOLVO BUILDING CRAP? THEY SHOULD BE IN JAIL. ETM - DESIGN WAS UNACCEPTABLE FROM A DAY ONE. THE ETM IS CAUSING SURGING, STALLING AND MANY OTHER SYMPTOMS. ONCE VOLVO STARTED TO REPLACE SOME OF THEM, THEY USED NEW ONES WITH EXACTLY THE SAME FLAWED DESIGN. ABS MODULE - IS KNOWN FOR CAUSING LOSS OF BRAKING POWER, EARLY BRAKE PADS WEAR AND DAMAGING TRANSMISSION. FRONT BRAKE CALIPERS - RUST ON CALIPERS IS SQUEEZING RUBBER BOOTS AROUND SLIDING PINS. DAMAGE TO ROTORS, PADS AND WHEEL BEARINGS. FRONT LIGHTS LOW BEAMS - UNACCEPTABLE LIGHT OUTPUT. FRONT SEAT BELTS - ARE CUTTING INTO SIDE TRIM AND SIDE TRIM IS CUTTING INTO SEAT BELTS. WIND SHIELD WIPERS - HIGHEST SPEED IS USELESS IN HEAVY RAIN. CRUISE CONTROL - RPM SURGES WHILE GOING 55MPH AND TURNING ON THE CRUISE CONTROL. DO SOMETHING! *TR
NHTSA ODI #10424559
189,000 miles · Dec 14, 2010
Electrical System
2000 V70 VOLVO -- CANNOT REMOVE KEY FROM IGNITION. MUST WAIT 1-10 MINUTES, OR USE SECOND KEY TO LOCK CAR WITH FIRST KEY STILL IN IGNITION. KEY CAN USUALLY BE REMOVED AFTER 1-10 MINUTES. *TR
NHTSA ODI #10370615
97,000 miles · Mar 11, 2009
Electrical System
THE IGNITION KEY CANNOT BE REMOVED FROM THE SWITCH AFTER THE ENGINE IS CUT OFF. *TR
NHTSA ODI #10261524
Mileage unknown · Apr 14, 2008
Electrical System
CAN NOT REMOVE KEY FROM STEERING WHEEL IGNITION. *TR
NHTSA ODI #10224475
Mileage unknown · Jan 29, 2008
Electrical System
I HAVE A 2000 V70 VOLVO THAT I HAVE A PROBLEM REMOVING THE KEY FROM THE IGNITION . I HAVE A SECOND KEY THAT I USE TO LOCK THE CAR WITH . I CAN NOT REMOVE THE KEY . IS THERE A RECALL FOR THIS PROBLEM? *CN
NHTSA ODI #10216361
54,000 miles · Oct 24, 2006
Electrical System
DT*: THE CONTACT STATED WHILE DRIVING 25 MPH AND ABOVE, THE VEHICLE COMPLETELY LOST POWER. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO REPLACED BATTERY CABLES AND THE CONTROL MODULE. THE CONSUMER STATED SOMETIMES IT WOULD TAKE ANYWHERE FRO 30 SECONDS TO 2 MINUTES BEFORE THE VEHICLE RESUMED NORMAL OPERATION AFTER STALLING. U…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 25 MPH AND ABOVE, THE VEHICLE COMPLETELY LOST POWER. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO REPLACED BATTERY CABLES AND THE CONTROL MODULE. THE CONSUMER STATED SOMETIMES IT WOULD TAKE ANYWHERE FRO 30 SECONDS TO 2 MINUTES BEFORE THE VEHICLE RESUMED NORMAL OPERATION AFTER STALLING. UPDATED 12/01/06. *JB
NHTSA ODI #10171726
79,500 miles · Dec 29, 2005
Electrical System
I AM SUBMITTING ETM FAILURE IN MY 2000 VOLVO V70 SE WAGON IN OCTOBER OF 2005. I AM CONCERNED FOR MY SAFETY DRIVING THIS CAR BECAUSE THE CAR HESITATES UPON ACCELERATION, THERE'S SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE) AND SOMETIMES WHEN THE ETS INDICATOR HAS ENGAGED WHILE MY FOOT IS ON THE…
Read full complaint
I AM SUBMITTING ETM FAILURE IN MY 2000 VOLVO V70 SE WAGON IN OCTOBER OF 2005. I AM CONCERNED FOR MY SAFETY DRIVING THIS CAR BECAUSE THE CAR HESITATES UPON ACCELERATION, THERE'S SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE) AND SOMETIMES WHEN THE ETS INDICATOR HAS ENGAGED WHILE MY FOOT IS ON THE BRAKE THE CAR SURGES FORWARD AS IF I WERE GIVING IT A LOT OF GAS. I WENT TO THE DEALER IN CULVER CITY, CALIFORNIA, TODAY, DECEMBER 28, 2005, AND THE MODULE WAS NOT REPLACED BUT, THE SERVICE REPS DID SAY THEY CLEANED THE THROTTLE - WHATEVER THAT IS - AND UPGRADED THE SOFTWARE PROGRAM ON THE COMPUTER. FIVE MINUTES AFTER LEAVING THE VOLVO SERVICES DEPARTMENT THE ETM FAILED AGAIN. I CALLED THE DEALER AND THEY TOLD ME THEY DID ALL THAT THEY COULD DO. *JB
NHTSA ODI #10146320
26,000 miles · Sep 29, 2005
Electrical SystemVehicle Speed Control
DT: THE CONTACT STATED VEHICLE STALLED/DIED, AND LOST POWER. THROTTLE CONTROL MODULE WAS REPLACED. *AK *JB
NHTSA ODI #10133899
63,000 miles · Sep 12, 2005
Electrical System
DT: WHILE DRIVING AT 35 MPH VEHICLE STALLED LOST POWER DUE TO THROTTLE BODY FAILURE. DEALER REPLACED THROTTLE BODY. *AK
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, OVER AN EXTENDED PERIOD OF TIME, THE HEADLIGHT SWITCH MAY CEASE TO FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: ON VEHICLES WITH AN ORIGINAL OEM SWITCH, DEALERS WILL REPLACE THE HEADLIGHT SWITCH. ALL OTHER VEHICLES WILL BE INSPECTED TO DETERMINE IF THE SWITCH HAS EEN DAMAGED AND REPLACE ONLY IF NECESSARY. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THERE COULD BE INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET WHICH COULD CAUSE THE FRONT TURN SIGNAL NOT TO FUNCTION AS DESIGNED.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN AN APPROACHING DRIVER THAT THE VEHICLE IS TURNING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT TURN SIGNAL BULB AND SOCKET.
ON CERTAIN STATION WAGONS, THE TAILGATE LOCKING MECHANISM MAY HAVE BEEN INCORRECTLY MANUFACTURED WHICH, IN COMBINATION WITH COLD TEMPERATURES, COULD CAUSE IMPROPER LOCKING OF THE TAILGATE.
Consequence & remedy
Consequence: THE TAILGATE MAY NOT LOCK PROPERLY.
Remedy: DEALERS WILL REPLACE THE LOCKING MECHANISM FOR THE TAILGATE. OWNER NOTIFICATION BEGAN SEPTEMBER 25, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
2000 Volvo V70 Problems, Complaints & Recalls | Skip That Year
Illustration