NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
14 reportsClear category filter151,500 miles · Jul 14, 2016
Electrical System
THE IGNITION SWITCH FREQUENTLY JAMS, LOCKED, IN THE "OFF" POSITION. THE KEY CAN BE INSERTED, BUT THE IGNITION LOCK WILL NOT TURN, MAKING IT IMPOSSIBLE TO START AND OPERATE THE VEHICLE OR TURN ON ACCESSORIES OR TURN THE STEERING WHEEL, RENDERING THE VEHICLE COMPLETELY INOPERATIVE. WHEN THE IGNITION IS IN THE "ON" POSITION, IT C…
Read full complaint
THE IGNITION SWITCH FREQUENTLY JAMS, LOCKED, IN THE "OFF" POSITION. THE KEY CAN BE INSERTED, BUT THE IGNITION LOCK WILL NOT TURN, MAKING IT IMPOSSIBLE TO START AND OPERATE THE VEHICLE OR TURN ON ACCESSORIES OR TURN THE STEERING WHEEL, RENDERING THE VEHICLE COMPLETELY INOPERATIVE. WHEN THE IGNITION IS IN THE "ON" POSITION, IT CAN BE TURNED OFF WITHOUT DIFFICULTY. WHEN IT IS "OFF," HOWEVER, IT FREQUENTLY CAN NOT BE TURNED "ON". A QUICK INTERNET SEARCH REVEALED THAT THIS IS A RATHER COMMON PROBLEM.
NHTSA ODI #10884834
72,592 miles · Sep 14, 2006
Electrical SystemFire
DT*: THE CONTACT STATED WHILE PARKED IN THE DRIVEWAY FOR ONE DAY, SMOKE WAS NOTICED COMING FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CONTACTED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THE WIRING HARNESS CAUSED THE FIRE. THE WIRING HARNESS WAS REPLACED. THE DEALER WAS NO…
Read full complaint
DT*: THE CONTACT STATED WHILE PARKED IN THE DRIVEWAY FOR ONE DAY, SMOKE WAS NOTICED COMING FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CONTACTED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THE WIRING HARNESS CAUSED THE FIRE. THE WIRING HARNESS WAS REPLACED. THE DEALER WAS NOT NOTIFIED. UPDATED 10/18/2006 - THE VEHICLE WAS LAST DRIVEN ABOUT 14 HOURS PRIOR TO THE VEHICLE CATCHING ON FIRE. THE SERVICE DEALER REPLACED THE HARNESS TO THE ABS CONTROL UNIT. *NM
NHTSA ODI #10168235
102,000 miles · Nov 29, 2005
Electrical SystemFire
VOLVO V70 1998 - FIRE IN ENGINE COMPARTMENT - CAR DESTROYED DURING ROUTINE DRIVING, ENGINE STOPS. DRIVER NOTICES SMOKE COMING FROM ENGINE COMPARTMENT AND ELECTRICAL SYSTEMS (LIGHTS) BLINKING. IN A FEW MINUTES THE CAR IS TOTALLY DESTROYED BY FIRE. WHEN I VISITED THE WRECKER'S YARD I FOUND A VOLVO 850 WAGON THAT WAS DESTRO…
Read full complaint
VOLVO V70 1998 - FIRE IN ENGINE COMPARTMENT - CAR DESTROYED DURING ROUTINE DRIVING, ENGINE STOPS. DRIVER NOTICES SMOKE COMING FROM ENGINE COMPARTMENT AND ELECTRICAL SYSTEMS (LIGHTS) BLINKING. IN A FEW MINUTES THE CAR IS TOTALLY DESTROYED BY FIRE. WHEN I VISITED THE WRECKER'S YARD I FOUND A VOLVO 850 WAGON THAT WAS DESTROYED BY FIRE IN THE SAME WAY! *NM
NHTSA ODI #10143876
75,000 miles · Sep 15, 2003
Electrical System
REAR PASSENGER SIDE DOORS CAN NOT BE OPENED MANUALLY OR ELECTRICALLY.*AK CONSUMER STATED THERE IS NO WAY HIS PARAPLEGIC SON CAN EXIT THE VEHICLE IF THERE WAS A FIRE OR COLLISION. LOCK MOTORS FAILED ONCE AND WERE REPLACED. MECHANIC HAD TO BREAK A PART IN THE DOOR TO RELEASE THE LOCK. *PH
NHTSA ODI #10034428
Mileage unknown · Nov 2, 2002
Electrical System
ABS & TRAC OFF LIGHT ARE DISPLAYED RANDOMLY, OBD SCAN SAYS SENSOR FAILED, HAVE INSTALLED TWO SETS OF SENSORS TO NO AVAIL, IT TURNS OUT ENCAPSULATED PC BOARD CRACKS BREAKING SOLDER CONNECTIONS. THE 1996 850 HAD THE SAME PROBLEM. DT
NHTSA ODI #769215
Mileage unknown · Jan 18, 2002
Electrical SystemExterior LightingFuel System, Gasoline
THE GAS CAP DID NOT FIT PROPERLY. *YH
NHTSA ODI #564029
Mileage unknown · May 23, 2001
Electrical SystemEngine And Engine CoolingEquipment
THERE HAVE BEEN NUMEROUS ELECTRICAL FAILURES WITH THE CAR ON A ROUTINE BASIS. THERE HAVE ALSO BEEN OIL LEAKS, GASOLINE LEAKS, AIR CONDITIONER FAILURE AND SEAT BELT FAILURES. THE CAR HAS BEEN REPAIRED ALMOST ON A MONTHLY BASIS SINCE THE BEGINNING OF OWNERSHIP. THIS PAST WEEK, IT HAS BEEN REPAIRED THREE TIMES FOR ELECTRICAL PRO…
Read full complaint
THERE HAVE BEEN NUMEROUS ELECTRICAL FAILURES WITH THE CAR ON A ROUTINE BASIS. THERE HAVE ALSO BEEN OIL LEAKS, GASOLINE LEAKS, AIR CONDITIONER FAILURE AND SEAT BELT FAILURES. THE CAR HAS BEEN REPAIRED ALMOST ON A MONTHLY BASIS SINCE THE BEGINNING OF OWNERSHIP. THIS PAST WEEK, IT HAS BEEN REPAIRED THREE TIMES FOR ELECTRICAL PROBLEMS RELATED TO THE SEAT BELTS AND AIR BAGS. THE VOLVO DEALERSHIPS HAVE MADE THE NECESSARY REPAIRS AND WARRANTIES HAVE PAID MOST OF THE COSTS, THE AMOUNT OF TIME THIS CAR HAS SPENT BEING SERVICED IS TOTALLY UNACCEPTABLE. EVEN THE VOLVO DEALER HERE IN FLORIDA (PLANTATION VOLVO) SUGGESTED WE RESEARCH THE FLORIDA LEMON LAW. THE LAW DOES NOT APPLY TO US BECAUSE THE CAR WAS PURCHASED IN MASSACHUSETTS. WE WOULD APPRECIATE ANY ASSISTANCE IN GETTING VOLVO'S ATTENTION THAT THIS PARTICULAR CAR HAS MAJOR FLAWS, ESPECIALLY ELECTRICAL.
NHTSA ODI #745792
Mileage unknown · Aug 15, 2000
Electrical SystemExterior Lighting
WHILE DRIVING WITH HEADLIGHTS ON. THEN, ACTIVATED TURN SIGNAL LIGHTS, AND LIGHT ON DASH PANEL WILL BLINK FAST, AND LET CONSUMER KNOW TO CHANGE THE LIGHT BULBS. ALSO, BATTERY WILL DIE WITHOUT A REASON FOR IT. *AK
NHTSA ODI #867830
Mileage unknown · Dec 14, 1999
Electrical System
THIS CAR HAS BEEN PLAGUED WITH ELECTRICAL PROBLEMS. HEADLIGHT, TAILLIGHT, TURN SIGNALS...ALL HAVE BEEN REPLACED NUMEROUS TIMES. THE STEREO AND BATTERY HAVE ALSO BEEN REPLACED. BOTH THE DRIVERS WINDOW AND THE REAR PASSENGER WINDOWS HAVE MALFUNCTIONED CAUSING THEM TO "STICK" IN THE POSITION THAT THEY ARE IN. THE DEALER HAS REPLACE…
Read full complaint
THIS CAR HAS BEEN PLAGUED WITH ELECTRICAL PROBLEMS. HEADLIGHT, TAILLIGHT, TURN SIGNALS...ALL HAVE BEEN REPLACED NUMEROUS TIMES. THE STEREO AND BATTERY HAVE ALSO BEEN REPLACED. BOTH THE DRIVERS WINDOW AND THE REAR PASSENGER WINDOWS HAVE MALFUNCTIONED CAUSING THEM TO "STICK" IN THE POSITION THAT THEY ARE IN. THE DEALER HAS REPLACED MOST OF THE BULBS AT NO CHARGE. I HAVE HAD 2 REPLACED WHILE ON VACATION AT VARIOUS TIMES. I CAN NOT THINK OF ANYTHING OTHER THEN THE TIRES, THAT IS NOT GOVERNED BY THE ELECTRICAL SYSTEM IN THIS VEHICLE. WITH TWO SMALL CHILDREN, THIS IS OBVIOUSLY A CONCERN TO ME. VOLVO AS A MANUFACTURER HAS PROMISED A FULL SYSTEM CHECK TWO TIMES. IT NEVER HAPPENED. AT THIS POINT, I DON'T KNOW THAT I WOULD TRUST THE CAR EVEN IF IT DID CHECK OUT OK. *AK
NHTSA ODI #716056
Mileage unknown · Nov 20, 1999
Electrical System
"FREEZE" PLUG BLEW OUT WHILE ACCELERATING ONTO FREEWAY. THAT RESULTED IN VERY LOW ENGINE POWER AVAILABLE, A LOT OF NOISE, AND INEFFECTIVE FOOTBRAKES. I WAS ABLE TO STOP THE CAR WITH THE PARKING BRAKE. *AK
NHTSA ODI #715074
Official recalls
5Oct 21, 2004
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, OVER AN EXTENDED PERIOD OF TIME, THE HEADLIGHT SWITCH MAY CEASE TO FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: ON VEHICLES WITH AN ORIGINAL OEM SWITCH, DEALERS WILL REPLACE THE HEADLIGHT SWITCH. ALL OTHER VEHICLES WILL BE INSPECTED TO DETERMINE IF THE SWITCH HAS EEN DAMAGED AND REPLACE ONLY IF NECESSARY. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THERE COULD BE INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET WHICH COULD CAUSE THE FRONT TURN SIGNAL NOT TO FUNCTION AS DESIGNED.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN AN APPROACHING DRIVER THAT THE VEHICLE IS TURNING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT TURN SIGNAL BULB AND SOCKET.
Aug 30, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.
Consequence & remedy
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLIGHT SWITCH.
Aug 30, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONTAL PASSENGER AIR BAG MAY BE OVERLY SENSITIVE TO CERTAIN ELECTROSTATIC DISCHARGE.
Consequence & remedy
Consequence: THIS COULD POSSIBLY CAUSE AN INADVERTENT DEPLOYMENT.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL GROUND WIRE IN THE PASSENGER SIDE TO ASSURE SUFFICIENT GROUNDING.
Oct 14, 1998
VEHICLE DESCRIPTION: STATION WAGONS EQUIPPED WITH THIRD SEATS. USERS OF THE THIRD SEAT, WHEN EXITING THE VEHICLE, CAN COME IN CONTACT WITH THE TAILPIPE.
Consequence & remedy
Consequence: CONTACT WITH THE TAILPIPE CAN RESULT IN PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE LENGTH OF THE VEHICLE'S TAILPIPE AND, IF NECESSARY, REPAIR THE TAILPIPE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ04004 · Headlight Failure
Opened Jun 8, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Exterior Lighting:headlights; Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
PE00031 · Turn Signal
Opened Aug 15, 2000 · Closed Dec 22, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
PE99005 · Fuel Leakage
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE98043 · Exhaust Pipe Burns
Opened Aug 5, 1998 · Closed Oct 21, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ODI OPENED THIS INVESTIGATION BASED ON TWO REPORTS OF CHILDREN RECEIVING BURNS ON THEIR LEG FROM THE HOT EXHAUST PIPE WHILE EXITING 1998 MODEL YEAR V70 WAGONS VIA THE REAR LIFTGATE.THESE VEHICLES WERE EQUIPPED WITH A DEALER INSTALLED REAR FACING CHILDREN'S AUXILIARY SEAT (AUXILIARY SEAT).ENTRY TO ANDEXIT FROM THE AUXILIARY SEAT IS ONLY AVAILABLE THROUGH THE REAR LIFTGATE.THE END OF THE EXHAUST PIPE, OR EXHAUST PIPE EXTENSION, ON THE V70 MODEL PROTUDES BEYOUND THE REAR BUNPER FASCIA THRUS INCREASING THE LIKELIHOOD THAT AUXILIARY SEAT OCCUPANTS WILL BURN THEMSELVES WHEN EXITING THE VEHICLE.ADDITIONALLY, A THIRD CHILD WAS ALSO BURNED ON IT'S LEG WHILE WALKING AROUND THE REAR OF THE VEHICLE.VOLVO'S ANALYSIS OF THIS ISSUE REVEALED 14 ADDITIONAL REPORTS RESULTING IN 18 INJURIES.VOLVO HAS AGREED TO CONDUCT A SAFETY RECALL ON THE AFFECTED VEHICLES.ALL REGISTERED OWNERS OF THE SUBJECT VEHICLES WILL NOTIFIED VIA FIRST CLASS MAIL, AS VOLVO CANNOT DETERMINE WHO MAY HAVE HAD AN AUXILIARY SEAT INSTALLED IN THEIR VEHICLE.THE NOTIFICATION TO ALL SUBJECT VEHICLE OWNERS WILL ALSO EFFCTIVELY INFORM THOSE OWNERS WHO MAY WISH TO HAVE AN AUXILIARY SEAT ADDED TO THEIR VEHICLES IN THE FUTURE.
Illustration