IllustrationMileage unknown · Dec 26, 2016
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System
TAKATA
NHTSA ODI #10937413
2005 Volvo S80
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all S80 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 15 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports2 fire reports0 injury reports
Electrical System complaints
4 reportsTAKATA
TL* THE CONTACT OWNS A 2005 VOLVO S80. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE'S SPEED REDUCED AND "REDUCED ENGINE PERFORMANCE" APPEARED ON THE INSTRUMENT PANEL. THE VEHICLE SPUTTERED. THE CONTACT STATED THAT THE VEHICLE WAS NOT ABLE TO BE DRIVEN TWO YEARS AGO. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLVO S80. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE'S SPEED REDUCED AND "REDUCED ENGINE PERFORMANCE" APPEARED ON THE INSTRUMENT PANEL. THE VEHICLE SPUTTERED. THE CONTACT STATED THAT THE VEHICLE WAS NOT ABLE TO BE DRIVEN TWO YEARS AGO. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TOWED TO A DEALER, WHO DIAGNOSED THAT THE ETM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT NOTIFIED THE MANUFACTURER. THE APPROXIMATE FAILURE MILEAGE WAS 81,000. THE VIN WAS UNAVAILABLE.
B+ BATTERY CABLE AT STARTER SOLENOID SHORTED TO STARTER CASE AND GROUNDED. CAUSING A FIRE IN ENGINE COMPARTMENT. CAR SHUT DOWN WITHOUT WARNING. ENGINE WENT OFF, LIGHTS WENT OUT ALL IN AN INSTANT. EMERGENCY FLASHERS WERE INOPERATIVE. PULLED OFF TO THE SIDE OF THE ROAD AND STOPPED USING THE EMERGENCY BRAKE. SMOKE WAS COMING …
Read full complaint
B+ BATTERY CABLE AT STARTER SOLENOID SHORTED TO STARTER CASE AND GROUNDED. CAUSING A FIRE IN ENGINE COMPARTMENT. CAR SHUT DOWN WITHOUT WARNING. ENGINE WENT OFF, LIGHTS WENT OUT ALL IN AN INSTANT. EMERGENCY FLASHERS WERE INOPERATIVE. PULLED OFF TO THE SIDE OF THE ROAD AND STOPPED USING THE EMERGENCY BRAKE. SMOKE WAS COMING FROM UNDER THE HOOD. OPENED THE HOOD AND FOUND THE FRONT OF THE ENGINE ON FIRE. EXTINGUISHED THE FLAMES. DISCONNECTED THE NEGATIVE TERMINAL ON THE BATTERY LOCATED IN THE TRUNK, CAR TOWED TO DEALER, IN PROCESS OF REPAIR. *TR
ON 07/21/07 I PURCHASED A 2005 VOLVO S80 T6 FROM MOMENTUM VOLVO IN HOUSTON, TX. IT WAS DELIVERED ON 08/02/2005 BRAND NEW WITH 7 MILES ON IT. THE FOLLOWING ARE AN ACCOUNT OF THE ISSUES AND SAFETY HAZARDS THIS CAR HAS HAD WITHIN THE LAST 18 MONTHS AND 24,000 MILES. THE FIRST ISSUE WAS DAMAGE FROM TRANSIT - FRONT AND REAR BUMPE…
Read full complaint
ON 07/21/07 I PURCHASED A 2005 VOLVO S80 T6 FROM MOMENTUM VOLVO IN HOUSTON, TX. IT WAS DELIVERED ON 08/02/2005 BRAND NEW WITH 7 MILES ON IT. THE FOLLOWING ARE AN ACCOUNT OF THE ISSUES AND SAFETY HAZARDS THIS CAR HAS HAD WITHIN THE LAST 18 MONTHS AND 24,000 MILES. THE FIRST ISSUE WAS DAMAGE FROM TRANSIT - FRONT AND REAR BUMPER HAD TO BE REPAIRED AND PAINTED. THE SECOND ISSUE - CHECK ENGINE LIGHT CAME ON 01/14/06. IT WAS AN EXHAUST LEAK. I ALSO COMPLAINED OF NO AM RECEPTION (FIXED) . THE THIRD ISSUE - CHECK ENGINE LIGHT CAME ON AGAIN ON 01/30/06. THIS TIME IT WAS A FAULTY LEAKAGE DETECTION PUMPED IN THE EXHAUST THAT WAS REPLACED. I COMPLAINED AGAIN OF NO AM RECEPTION. THE FOURTH ISSUE - CAR WAS IN SHOP FOR RECALL WORK FOR AN ELECTRICAL ISSUE WITH THE STARTER SOLENOID AND THE BATTERY CABLES. I INFORMED THEM THERE WAS A POPPING NOISE UNDER THE HOOD AND THAT THERE WAS NOISE WHEN TURNING LEFT. MOMENTUM BLAMED IT ON THE TIRES NEEDING REPLACED ON A CAR THAT HAD 14,913 MILES ON IT - NO WORK DONE. COMPLAINED OF NO AM RECEPTION. THE FIFTH ISSUE - CAR WAS AT MOMENTUM FROM 01/30/07 - 02/08/07 BECAUSE POPPING NOISE UNDER HOOD AND CLICKING NOISE CAR MADE WHEN TURNING SHARPLY TO THE LEFT. EXPLANATION - POPPING NOISE WAS BECAUSE STRUTS WERE NOT TIGHTENED ORIGINALLY. THE CLICKING NOISE WAS NOT FOUND, BUT THEY DID FIND THAT THE POWER STEERING WAS NOT WORKING AND REPLACED THE POWER STEERING AND REPLACED THE STEERING RACK AND STEERING SHAFT. RESOLVED AM ISSUE. THE SIXTH ISSUE - CAR WENT BACK TO SHOP ON 02/09/07 - 02/17/07 BECAUSE OF NOISE WHEN TURNING LEFT. EXPLANATION - FRAME NOT BEING TIGHTENED. CORRECTED. THE SEVENTH ISSUE THAT THEY DID NOT FIX THE SIXTH ISSUE. I DROVE RIGHT BACK TO MOMENTUM. EXPLANATION - FAULTY ELECTRICAL WIRING UNDER DRIVER'S SEAT WHERE TWO WIRES WERE BEING GROUND OUT. *AK THE EIGHTH ISSUE WAS ON APRIL 8, 2007 - AUTOMOBILE HAS POPPING SOUND UNDER HOOD AGAIN THERE IS A METAL GRINDING METAL FROM THE PASSENGER SIDE OF CAR NEAR BACK WHEEL. *AK
Official recalls
521V766000 · Air Bags:frontal:driver Side:inflator Module
Sep 30, 2021
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
10V566000 · Equipment:electrical:navigational System(global Positioning System)
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
09V483000 · Fuel System, Gasoline:delivery:fuel Pump
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V375000 · Equipment:other:labels
Oct 3, 2006
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.
Consequence & remedy
Consequence: A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
05V529000 · Electrical System:starter Assembly:solenoid
Nov 17, 2005
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Consequence & remedy
Consequence: SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTIVATED. AN ELECTRICAL SHORT COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.