MY CAR LURCHES FORWARD WHEN YOU ARE IDLING AS WELL AS DRIVING. I WAS ON A BUSY STREET WHEN I PULLED OUT INTO AN ONCOMING LINE OF TRAFFIC WHEN THE MOTOR COMPLETELY DIED LEAVING ME IN THE MIDDLE OF BOTH LANES OF TRAFFIC. AFTER A TIME I WAS ABLE TO RESTART THE VEHICLE. THIS HAS ALSO HAPPENED IN BUMPER TO BUMPER HIGHWAY TRAFFIC. AS …
Read full complaint
MY CAR LURCHES FORWARD WHEN YOU ARE IDLING AS WELL AS DRIVING. I WAS ON A BUSY STREET WHEN I PULLED OUT INTO AN ONCOMING LINE OF TRAFFIC WHEN THE MOTOR COMPLETELY DIED LEAVING ME IN THE MIDDLE OF BOTH LANES OF TRAFFIC. AFTER A TIME I WAS ABLE TO RESTART THE VEHICLE. THIS HAS ALSO HAPPENED IN BUMPER TO BUMPER HIGHWAY TRAFFIC. AS YOU ARE IDLING AT AN INTERSECTION OR AWAITING A TRAIN TO PASS, THE MOTOR RACES AND THEN SLOWS AND ALSO LURCHES AHEAD. FOOT MUST BE HARD ON THE BRAKE OR I COULD REAR END THE VEHICLE IN FRONT OF ME. THIS VEHICLE HAS ONLY ABOUT 65,000 MILES AND I HAVE NO IDEA WHY THIS IS HAPPENING. IT HAS BEEN A GREAT CAR UNTIL THIS STARTED HAPPENING. THE CAR IS NOW SITTING IN THE DRIVEWAY AS AN UNSAFE CONDITION IS CAUSED BY THIS MALFUNCTION.
NHTSA ODI #11348507
158,000 miles · Dec 2, 2017
Air BagsStructureUnknown Or OtherCrashInjury
ON NOVEMBER 9TH MY WIFE WAS DRIVING OUR 2001 VOLVO S80 TO CHURCH. SHE PARKED THE CAR BUT IT BEGAN TO MOVE. IT ACCELERATED AND SHE WOUND UP DRIVING INTO A TREE TO AVOID HITTING OTHER CARS. SHE WAS ALSO WORRIED THAT CHILDREN FROM THE SCHOOL MIGHT BE AROUND. THE CAR WAS IN PARK. THE ENGINE WAS OFF. THE EMERGENCY BREAK WAS ON. THE S…
Read full complaint
ON NOVEMBER 9TH MY WIFE WAS DRIVING OUR 2001 VOLVO S80 TO CHURCH. SHE PARKED THE CAR BUT IT BEGAN TO MOVE. IT ACCELERATED AND SHE WOUND UP DRIVING INTO A TREE TO AVOID HITTING OTHER CARS. SHE WAS ALSO WORRIED THAT CHILDREN FROM THE SCHOOL MIGHT BE AROUND. THE CAR WAS IN PARK. THE ENGINE WAS OFF. THE EMERGENCY BREAK WAS ON. THE STEERING WHEEL WAS TIGHT, MAKING IT DIFFICULT TO STEER SINCE THE ENGINE WAS OFF. THE CHURCH SECRETARY OBSERVED THE INCIDENT. SHE SAW SMOKE COMING OUT OF THE BACK OF THE CAR WHICH WOULD INDICATE THE EMERGENCY BREAK WAS ON. WHEN SHE FIRST REACHED THE CAR WITH MY WIFE IN IT SHE NOTED THAT THE CAR WAS IN PARK.
NHTSA ODI #11051851
103,000 miles · Mar 7, 2009
Power TrainUnknown Or Other
MOST RECENT IS AN UPPER IDLER ARM WENT CAUSING THE TIMING BELT TO SKIP DAMAGING THE MOTOR: COST 4K TO FIX OR 5K TO INSTALL A USED MOTOR. PRESSURE TEST CAME BACK (NO PRESSURE)PISTONS ARE OK. SUNROOF CAVED IN ON MY HEAD. I DID GET CUTUP WITH THE GLASS. CAR STALLED, NEED NEW ALTERNATOR, FUEL LINK SHIELD FELL OFF BOTTOM OF CAR C…
Read full complaint
MOST RECENT IS AN UPPER IDLER ARM WENT CAUSING THE TIMING BELT TO SKIP DAMAGING THE MOTOR: COST 4K TO FIX OR 5K TO INSTALL A USED MOTOR. PRESSURE TEST CAME BACK (NO PRESSURE)PISTONS ARE OK. SUNROOF CAVED IN ON MY HEAD. I DID GET CUTUP WITH THE GLASS. CAR STALLED, NEED NEW ALTERNATOR, FUEL LINK SHIELD FELL OFF BOTTOM OF CAR CAUSING THE FUEL LINE TO DRAG ON ROAD. I HAD TO TAPE THE RUBBER FUEL LINE UP UNTIL GARAGE TO INSTALL A NEW SHIELD. PASSENGER SIDE SAFETY BELT LINKAGE BROKE (NO PASSENGER SIDE SEAT BELT) THERE ARE OTHER 'ROUTINE MAINTAINENCE' TIRES/BRAKES/ ETC THAT I DID HAVE DONE. I'VE TAKE GOOD CAR, BUT THESE LARGE TICKET ITEMS CONTINUE. THERE ARE ALWAYS LIGHTS OUT SOMEWHERE ON THIS CAR. ONE OF THE TIRE RIMS CRACKED AND I NEED A NEW ONE (DANGEROUS TO DRIVE HIGHWAY WITH THAT). I DID NOT THINK VOLVO WOULD EXCEPT SOMETHING LIKE THIS, WHEN I BROUGHT THE CAR TO GENGRIS VOLVO DEALER THEY TOLD ME THAT THAT 'WOULD NOT TOUCH' THIS CAR AND TRADE-IN WAS NOT AN OPTION. THIS CAR IS WORTHLESS WHAT WITH ALL THESE PROBLEMS. THEY TOLD ME THAT THIS MODEL (2000/2001) OF THE S80 T6 ARE LEMONS AND SHOULD NEVER HAVE BEEN MADE ROAD WORTHY. IS THERE ANYTHING YOU ARE ABLE TO DO... I STILL OWE 13K ON THIS WORTHLESS CAR. I SHOULD HAVE NEVER BOUGHT A VOLVO - THIS IS MY SECOND AND AND VERY WILLING TO SHARE THIS WITH OTHER POTENTIAL BUYERS IF NOTHING IS DOME BY VOLVO WITH THIS MATTER... THERE ARE MORE PROBLEMS I CAN SHARE IF YOU ARE INTERESTED. *TR
NHTSA ODI #10261018
163,000 miles · May 2, 2008
Power TrainUnknown Or Other
RE: VOLVO S80 T6 2001 HAVE HAD ENGINE SURGING FOR A WHILE. NOW THE TRANSMISSION FAILED WITH A MAJOR MELTDOWN AND DAMAGE. ALWAYS DID FREQUENT MAINTENANCE. ALSO HAD A CATALYTIC CONVERTER GO OUT. MUST BE A DEFECT. SAW OTHERS WITH SIMILAR PROBLEMS ON LINE. *TR
NHTSA ODI #10226523
86,281 miles · Jun 22, 2006
Electrical SystemUnknown Or Other
WHILE ON A ROAD TRIP, MY 2001 VOLVO S80 STARTED LURCHING FORWARD AND SPEEDING UP/SLOWING DOWN BY ITSELF. THE CAR WAS IDLING ERRATICALLY AND WOULD STALL OUT. AS I WAS AWAY FROM HOME AND NEEDED TO RETURN SOON, I TOOK MY CAR TO BE CHECKED OUT. I WAS TOLD THAT I NEEDED A NEW ELECTRONIC THROTTLE MODULE. I HAD NO CHOICE BUT TO H…
Read full complaint
WHILE ON A ROAD TRIP, MY 2001 VOLVO S80 STARTED LURCHING FORWARD AND SPEEDING UP/SLOWING DOWN BY ITSELF. THE CAR WAS IDLING ERRATICALLY AND WOULD STALL OUT. AS I WAS AWAY FROM HOME AND NEEDED TO RETURN SOON, I TOOK MY CAR TO BE CHECKED OUT. I WAS TOLD THAT I NEEDED A NEW ELECTRONIC THROTTLE MODULE. I HAD NO CHOICE BUT TO HAVE THE CAR FIXED AT A COST OF OVER $800.00. NOW I FIND OUT THAT VOLVO KNEW OF PROBLEMS WITH THIS PARTICULAR PART AND THAT THERE MAY BE A RECALL AND I AM VERY ANGRY THAT I HAD TO PAY TO REPLACE A PART THEY (VOLVO) KNEW WAS DEFECTIVE!!! ADDITIONALLY, AND MORE IMPORTANTLY, I WONDER ABOUT THE POTENTIAL DANGER I AND MY FAMILY WERE UNKNOWINGLY SUBJECTED TO DUE TO VOLVO'S DECISION TO NOT INFORM CONSUMERS OF THIS DEFECT. *JB
NHTSA ODI #10160432
45,000 miles · May 3, 2005
Unknown Or Other
CONTACT STATES: CONSUMER RECEIVED A RECALL NOTICE ABOUT THE OWNERS VEHICLE. CONSUMER WAS UNABLE TO GET IT SERVICED IN HIS AREA AS OF LAST WEEK, AND WAS BEING SENT OUT OF STATE TO OREGON TO CORRECT THE RECALL. THERE WERE VOLVO MECHANICS LOCALLY THAT WERE CERTIFIED TO FIX THE CAR. LOCAL DEALERSHIP SOLD OUT. ACTUAL COMPLAINT CONC…
Read full complaint
CONTACT STATES: CONSUMER RECEIVED A RECALL NOTICE ABOUT THE OWNERS VEHICLE. CONSUMER WAS UNABLE TO GET IT SERVICED IN HIS AREA AS OF LAST WEEK, AND WAS BEING SENT OUT OF STATE TO OREGON TO CORRECT THE RECALL. THERE WERE VOLVO MECHANICS LOCALLY THAT WERE CERTIFIED TO FIX THE CAR. LOCAL DEALERSHIP SOLD OUT. ACTUAL COMPLAINT CONCERNED VOLVO NOT ALLOWING THE CERTIFIED MECHANICS TO DO THE WORK AND REQUIRING CONSUMER TO GO OUT OF STATE.*AK
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The driver side frontal air bag inflator may rupture, sending metal fragments into the passage compartment, when the driver side air bag is deployed.
Consequence & remedy
Consequence: Metal fragments can strike vehicle occupants increasing the risk of serious injury or death.
Remedy: Volvo Car will notify owners, and dealers will replace the driver side air bag module, free of charge. The recall began April 20, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10058.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
VEHICLE DESCRIPTION: SEDANS AND WAGONS. THE REAR OUTBOARD SEAT BELT ANCHORAGE BOLTS MAY HAVE BEEN INCORRECTLY TIGHTENED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE ANCHORAGE BOLTS AND TIGHTEN TO THE CORRECT TORQUE LEVEL. OWNER NOTIFICATION BEGAN MAY 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
2001 Volvo S80 Problems, Complaints & Recalls | Skip That Year
Illustration