NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
18 reportsClear category filter214,000 miles · May 19, 2011
Fuel System, Gasoline
THIS COMPLAINT IS AGAINST VOLVO AMERICA, I OWN A 1999 VOLVO S70 WITH 214,000 MILES. VOLVO CLAIMS THAT IT HAD A SOFTWARE UPGRADE FOR MY ELECTRONIC THROTTLE CONTROL MODULE. VOLVO HAD A RECALL FOR THIS ITEM, BUT IT ONLY COVERED THIS RECALL UPTO 200,000 MILES. MY VOLVO NEVER HAD THE PART REPLACED, VOLVO ONLY DID A "SOFTWARE UPGRADE.…
Read full complaint
THIS COMPLAINT IS AGAINST VOLVO AMERICA, I OWN A 1999 VOLVO S70 WITH 214,000 MILES. VOLVO CLAIMS THAT IT HAD A SOFTWARE UPGRADE FOR MY ELECTRONIC THROTTLE CONTROL MODULE. VOLVO HAD A RECALL FOR THIS ITEM, BUT IT ONLY COVERED THIS RECALL UPTO 200,000 MILES. MY VOLVO NEVER HAD THE PART REPLACED, VOLVO ONLY DID A "SOFTWARE UPGRADE." THE ETC IS FAILING AND MAY FAIL ON THE FREEWAY, PLACING MY LIFE AND THE LIFE OF OTHER AMERICAN DRIVERS IN DANGER. WHY HAS VOLVO GOT AWAY WITH FAILING ELECTRONICS WHICH WILL TURN THE CAR OFF ON THE FREEWAY AND WILL TAKE PEOPLE'S LIVES. DO SOMETHING ABOUT THIS. *TR
NHTSA ODI #10402140
45,600 miles · May 4, 2011
Fuel System, Gasoline
1999 VOLVO S70. MECHANICAL PROBLEMS STARTED IN 2005.THE VEHICLE WOULD SUDDENLY STALL WITH NO WARNING, USUALLY IN RUSH HOUR TRAFFIC. THE CONSUMER WAS ABLE TO RESTART THE VEHICLE, BUT OFTEN IT WOULD GO NO MORE THAN 20-30 MPH. ALSO, SOME OF THE LIGHTS ON THE DASH WOULD COME ON AND GO OFF. THE CONSUMER HAS TAKEN THE VEHICLE TO THE D…
Read full complaint
1999 VOLVO S70. MECHANICAL PROBLEMS STARTED IN 2005.THE VEHICLE WOULD SUDDENLY STALL WITH NO WARNING, USUALLY IN RUSH HOUR TRAFFIC. THE CONSUMER WAS ABLE TO RESTART THE VEHICLE, BUT OFTEN IT WOULD GO NO MORE THAN 20-30 MPH. ALSO, SOME OF THE LIGHTS ON THE DASH WOULD COME ON AND GO OFF. THE CONSUMER HAS TAKEN THE VEHICLE TO THE DEALER AT LEAST SIXTEEN TIMES.THEY SAY THEY CAN'T DUPLICATE THE PROBLEM, SO THEY CAN'T FIX IT. MEANTIME, MY CAR COMES TO A DEAD STOP ON HOUSTON STREETS AND FREEWAYS WITH 18-WHEELERS, TRUCKS, AND CARS BEHIND IT. THIS A ROLLING COFFIN. I AM GOING TO GET REAR-ENDED AND SOMEONE IS GOING TO BE KILLED. MAYBE SEVERAL "SOMEONE'S". VOLVO OF HOUSTON DOESN'T CARE. WE BOUGHT THE CAR THERE. IT HAS HAD MAINTENANCE SERVICE THERE OVER THE YEARS. THESE PEOPLE TOOK OUR $27,000 AND GAVE US A "KILLER" CAR. I AM TERRIFIED WHEN I HAVE TO DRIVE IT. SINCE 2005, EVERY TIME I GET IN THIS CAR I WONDER IF I WILL GET HOME ALIVE. I WOULD LIKE FOR SOMEONE AT VOLVO TO TAKE THIS CAR AND LET THEIR WIFE, MOTHER, OR DAUGHTER DRIVE IT. LET THEM WORRY ABOUT GETTING KILLED ON A HOUSTON STREET. THIS CAR HAS DONE THIS AT LEAST 20 TIMES, MAYBE MORE. I NEVER KNOW IF I WILL GET WHERE I AM GOING OUT AND I DEFINITELY DON'T KNOW IF I WILL GET HOME A L I V E! THIS CAR IS GOING TO GET SOMEONE KILLED. THIS CAR IS GOING TO GET SOMEONE KILLED. DID I MENTION THAT THIS CAR IS GONG TO GET SOMEONE KILLED?? I WOULD LIKE TO GIVE THIS CAR TO A PRESIDENT OR VICE-PRESIDENT AT VOLVO SO THEY COULD LET THEIR LOVED ONES DRIVE AND WORRY A BOUT "SOMEONE GETTING KILLED". I HAVE DEALT WITH VOLVO SINCE 2005. THEY DON'T CARE. MAKING MONEY BY SELLING CARS IS ALL THAT IS IMPORTANT TO THEM. EVEN IF THE DRIVER GETS KILLED BECAUSE THEY DON'T KNOW HOW TO FIX THE PROBLEM THAT IS GOING TO CAUSE THE DEATH. I ASKED THE [XXX], AT VOLVO OF HOUSTON TODAY IF HE WOULD LIKE TO LET HIS WIFE, MOTHER, OR DAUGHTER DRIVE THIS CAR. HE JUST LOOKED AT ME AND SAID NOTHING. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.
NHTSA ODI #10399141
170,750 miles · Jan 19, 2011
Fuel System, Gasoline
TL* THE CONTACT OWNS A 1999 VOLVO S70. FOR A NUMBER OF MONTHS THE CONTACT COMPLAINED TO AN INDEPENDENT REPAIR SHOP ABOUT THE STRONG SMELL OF GAS ACCUMULATING OVERNIGHT IN THE GARAGE AFTER FILLING THE GAS TANK TO FULL. THE CONTACT WAS ADVISED IT WAS EITHER THE GAS CAP OR THE FUEL TANK. THE GAS CAP WAS REPLACED, BUT THERE WAS STIL…
Read full complaint
TL* THE CONTACT OWNS A 1999 VOLVO S70. FOR A NUMBER OF MONTHS THE CONTACT COMPLAINED TO AN INDEPENDENT REPAIR SHOP ABOUT THE STRONG SMELL OF GAS ACCUMULATING OVERNIGHT IN THE GARAGE AFTER FILLING THE GAS TANK TO FULL. THE CONTACT WAS ADVISED IT WAS EITHER THE GAS CAP OR THE FUEL TANK. THE GAS CAP WAS REPLACED, BUT THERE WAS STILL NO IMPROVEMENT. THE CONTACT RETURNED TO THE REPAIR SHOP WHERE THE PROBLEM WAS IDENTIFIED AS FAILED SEALS ON THE METAL FUEL LINES ENTERING AND EXITING THE LID OF THE FUEL PUMP INSTALLED ON TOP OF THE FUEL TANK UNDER THE TRUNK. THE ADHESIVE OR SEALANT THAT SECURED THE METAL IN THE LINE AND METAL OUT LINE TO THE FILTERS PLASTIC LID HAD CRACKED AND GAS VAPORS AND GASOLINE LEAKED OUT OF THE CRACKS. THE FUEL PUMP WAS REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 170,750. UPDATED 03/15/11 *BF
NHTSA ODI #10377140
209,600 miles · Jul 27, 2008
Fuel System, GasolineVehicle Speed Control
I WAS DRIVING NORMALLY ON A PARKWAY IN WASH DC. SUDDENLY THE ENGINE LOST POWER AND WOULD NOT GO MORE THAN 10 MPH. I "LIMPED" TO A GAS STATION AND TURNED OFF THE ENGINE, INSPECTED FOR LOOSE WIRES, OR OTHER OBSERVABLE DEFECTS. WHEN I STARTED THE CAR AGAIN THE ETS LIGHT WAS ON AND STAYED ON. NOW THE CAR RUNS ERRATICALLY LURCHING FO…
Read full complaint
I WAS DRIVING NORMALLY ON A PARKWAY IN WASH DC. SUDDENLY THE ENGINE LOST POWER AND WOULD NOT GO MORE THAN 10 MPH. I "LIMPED" TO A GAS STATION AND TURNED OFF THE ENGINE, INSPECTED FOR LOOSE WIRES, OR OTHER OBSERVABLE DEFECTS. WHEN I STARTED THE CAR AGAIN THE ETS LIGHT WAS ON AND STAYED ON. NOW THE CAR RUNS ERRATICALLY LURCHING FORWARD OR SPUTTERING OR JUST PLAIN LOSING POWER AT RANDOM. *TR
NHTSA ODI #10235906
206,000 miles · Jun 17, 2008
Engine And Engine CoolingFuel System, Gasoline
AT APPROXIMATELY 206,000 MILES MY CAR WOULDN'T DRIVE OVER 40 MPH, THE ENGINE WOULD REV UP ON ITS OWN AND SPUTTERED THROUGHOUT THE REDUCED RPM RANGE. RPMS WOULD NOT GO OVER ABOUT 3500. CHECK ENGINE LIGHT CAME ON. DROVE IT TO VOLVO DEALER AND THEY REPLACED THE THROTTLE BODY AT AN OUT OF POCKET COST TO ME OF APPROXIMATELY $1,000…
Read full complaint
AT APPROXIMATELY 206,000 MILES MY CAR WOULDN'T DRIVE OVER 40 MPH, THE ENGINE WOULD REV UP ON ITS OWN AND SPUTTERED THROUGHOUT THE REDUCED RPM RANGE. RPMS WOULD NOT GO OVER ABOUT 3500. CHECK ENGINE LIGHT CAME ON. DROVE IT TO VOLVO DEALER AND THEY REPLACED THE THROTTLE BODY AT AN OUT OF POCKET COST TO ME OF APPROXIMATELY $1,000. THEY STATED THAT IT WOULD HAVE BEEN COVERED UP TO 200,000 MILES AS THIS PART HAD A RECALL. I DO NOT FEEL THAT I WAS ADEQUATELY NOTIFIED OF THE RECALL. I RECEIVED A LETTER ABOUT A RECALL LAST YEAR AND CALLED THE DEALER TO ASK WHAT IT ALL MEANT SINCE I DID NOT UNDERSTAND IT. THE DEALER SAID IT WAS JUST A SOFTWARE UPGRADE AND WOULD ONLY TAKE ABOUT FIVE MINUTES. I TOOK THE VEHICLE IN FOR THAT SOFTWARE UPGRADE IN MARCH OF 2007 WITH LESS THAN 200,000 MILES ON THE VEHICLE AND THEY DID NOT SAY ANYTHING ABOUT THE ETM / THROTTLE BODY ISSUE. IT SHOULD HAVE BEEN REPLACED AT THAT TIME. *TR
NHTSA ODI #10231286
87,000 miles · Dec 28, 2006
Fuel System, Gasoline
PURCHASED USED CAR 1 WEEK AGO. 87,000 MI. NO PROBLEMS, ETS LIGHT CAME ON. YELLOW LIGHT, NOT RED = NOT AN EMERGENCY. GOT HOME SAFELY, NO ODD BEHAVIOR, AND READ ABOUT IT IN MANUAL, WHICH SAID TO TAKE TO DEALERSHIP, VERY VAGUE DESCRIPTION. WENT TO START CAR, SMELLED GAS, ROUGH IDLING REVVING 1,000 RPMS WHILE PARKED - I WASN'T EV…
Read full complaint
PURCHASED USED CAR 1 WEEK AGO. 87,000 MI. NO PROBLEMS, ETS LIGHT CAME ON. YELLOW LIGHT, NOT RED = NOT AN EMERGENCY. GOT HOME SAFELY, NO ODD BEHAVIOR, AND READ ABOUT IT IN MANUAL, WHICH SAID TO TAKE TO DEALERSHIP, VERY VAGUE DESCRIPTION. WENT TO START CAR, SMELLED GAS, ROUGH IDLING REVVING 1,000 RPMS WHILE PARKED - I WASN'T EVEN TOUCHING THE PEDAL, BLINKING HEADLIGHTS A.K.A INTERMITTENT POWER. IF THIS OCCURRED ON THE ROAD, I CANNOT PREDICT WHAT COULD HAVE HAPPENED. READ SAME COMPLAINTS ONLINE...EXPENSIVE TO REPLACE ETM UNIT, CONTINUED FAILURE, NO RECALL OR WARRANTY COVERAGE. I DO SEE A RECALL ON 11/14/2006 BUT I'M UNSURE IF THIS IS THE SAME PROBLEM. *JB
NHTSA ODI #10177165
119,000 miles · Oct 13, 2005
Fuel System, Gasoline
MY THROTTLE IS DEFECTIVE ON MY 1999 VOLVO S70. THE CAR IDLES TOO LOW AND WILL DIE AT A STOP. MY MECHANIC INFORMED ME ONLY VOLVO CAN REPAIR THIS. *JB
NHTSA ODI #10139616
89,000 miles · Oct 11, 2005
Fuel System, Gasoline
SERVICE ENGINE LIGHT CAME ON. COMPUTER CHECK AT SHOP SPECIALIZING IN VOLVOS SHOWED THROTTLE BODY WAS DEFECTIVE. IT REQUIRED REPLACEMENT. OUR SERVICE SHOP ESTIMATES THEY HAVE HAD TO REPLACE APPROXIMATELY 75 OF THESE.*JB
NHTSA ODI #10139354
91,100 miles · Oct 8, 2005
Fuel System, Gasoline
ETS LIGHT CAME ON STALLING, RUNNING ROUGH ECT... DEALER INSTALLED NEW THROTTLE BODY (ELECTRONIC THROTTLE SYSTEM) COST TO CORRECT $1041.00. *JB
NHTSA ODI #10139099
82,000 miles · Sep 22, 2005
Fuel System, Gasoline
SMELL OF GAS, CHECKED UNDER HOOD GAS LEAK AT FUEL RAIL, DEFECTIVE END CAP ON FUEL RAIL CAUSE OF LEAK REPLACED FUEL RAIL WITH NEW IMPROVED FUEL RAIL FROM DEALER,ORIGINAL FUEL RAIL DEFECTIVE COULD CAUSE FIRE. OLD PART IS AVAILABLE. *NM
NHTSA ODI #10137373
NHTSA investigations
5EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
RQ04004 · Headlight Failure
Opened Jun 8, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Exterior Lighting:headlights; Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
PE00031 · Turn Signal
Opened Aug 15, 2000 · Closed Dec 22, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
Illustration