2025 Volvo EX90

Failure of the onboard AC charging component, known as the Grid to High Voltage Converter A (GHCA) or onboard charger module. This vehicle would not charge on AC current, but could only be charged on DC current. This is a safety issue, as you may get stranded without access to a DC capable charger, since AC is the primary source for a majority of EV owners. Problem has been confirmed by the dealer. Volvo seems to be aware of the issue, as this is a common failure point according to other Volvo EX90 owners. Warnings that occur is a red illuminated light near the charge port when it is unable to accept a AC charge due to failure.

My 2026 Volvo EX90, with approximately 3,000 miles, experienced a complete vehicle failure while being used as our family vehicle in Phoenix, Arizona. While my nanny was driving my two young children, including my [XXX], the air conditioning stopped functioning during approximately 110–115°F outside temperatures. After she parked, the vehicle’s displays went dark and the vehicle became completely unresponsive. The exterior door handles also stopped functioning normally. My nanny was unable to open the rear doors from outside to remove the children and had to climb through the front seats into the rear passenger area in order to gain access and get them out of the vehicle. The vehicle would not respond to the key, would not restart, and did not respond to Volvo’s recommended reset procedures. Roadside assistance was required and the vehicle was towed to an authorized Volvo dealership. Several days later, the vehicle remains completely inoperable. The Volvo dealer has been unable to power the vehicle on, establish diagnostic communication with it, or open the doors normally. The vehicle is so immobilized that the dealership must place it on dollies simply to move it around the facility. This appears to involve substantially more than an infotainment failure. The incident involved simultaneous loss of climate control in extreme heat, complete vehicle shutdown, and loss of normal exterior door access while young children were passengers. I am particularly concerned about the potential safety implications if this failure were to occur again in extreme heat or in another situation where occupants needed to exit the vehicle quickly. The vehicle remains at the Volvo dealership for diagnosis, and no root cause has yet been identified. Vehicle: 2026 Volvo EX90 Mileage: Approximately 3,000 miles Location: Phoenix/Scottsdale, Arizona Injuries: None Crash: No Fire: No Police report: No Vehicle towed: Yes INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving the car on a state road (45 mph) the car suddenly notified me of an "electrical fault", a light that looks like a turtle came on, and the vehicle lost power and couldn't go any faster than 5 mph. Another vehicle almost rear-ended me around a blind curve because I was moving significantly slower than normal traffic. I pulled into a parking lot, shutdown and restarted the car and everything seemed fine. It happened again a few minutes later so we started to head back home. But the real issue happened a minute or so after the second fault - the fault cleared itself and all of a sudden the vehicle's speed shot up to over 60 mph with very little throttle response or control from me. I slowed the car down using the brakes and continued home. The fault happened again, and cleared itself again in the same manner but this time while I was turning causing me to almost hit a curb while trying to turn. The car is dangerous. These should be taken off the road permanently.

I was parked in a parking lot and when I released my foot from the break, the car accelerated on its own and crashed into the car in front of me. The automatic emergency braking did not deploy. It was most recently a safety risk and put others in the parking lot, particularly the driver in front me, in danger. I have reported this issue to Volvo and they instructed me to get the body of the car repaired and then the dealer will inspect it. I filed an insurance claim with my insurance company and the car is going to be repaired. There were no warning lamps or messages prior to the failure.

I am submitting this complaint because I believe my Volvo electric vehicle has a serious and recurring safety-related defect that has not been permanently repaired despite multiple repair attempts. Since purchasing the vehicle new, it has repeatedly failed to operate as intended, left me stranded multiple times, and continues to display warning messages while driving. I purchased the vehicle new on November 20, 2025, for approximately $85,000 with zero miles. The first failure occurred on December 4, 2025, at approximately 578 miles when the vehicle stopped charging. Volvo attempted repairs, but the same charging defect returned. The vehicle required additional repairs on January 21, 2026 (1,304 miles), early March 2026 (2,846 miles), and April 27, 2026 (3,810 miles). Despite multiple repairs and component replacements, the same issue continued. By the fourth repair, the vehicle had been out of service approximately 80 days. Volvo later approved a manufacturer repurchase; however, while waiting for the repurchase process, the vehicle developed additional failures where it would completely lose power and become inoperable. The vehicle required towing on multiple occasions, leaving me stranded and without transportation. During a later repair visit, Volvo kept the vehicle for approximately 39 days and stated they could not duplicate the problem and that the vehicle was operating as designed. The day after receiving the vehicle back, the same failure occurred again. The vehicle has now required seven repair attempts. Even after the latest repair, I continue to receive dashboard warnings while driving instructing me to stop the vehicle. Due to the repeated failures, loss of vehicle operation, and unresolved warnings, I have lost confidence in the safety and reliability of this vehicle and have changed my driving habits to avoid being stranded. I believe these recurring failures represent a potential safety defect that warrants investigation by NHTSA.

This vehicle locks itself even with a fully charged key tag inside it. The driver is not able to open the car by lifting any of the door handles. It has occurred 3 separate times. It will only open with a key card. Should the driver not have a key card outside of the vehicle, it must be towed to the dealership for service. The dealer has been advised of the problem, although the service department is unable to identify why or how this occurs. This has happened at various times of the day, including late at night, and we reside in a rural area with very limited alternate transportation. No warning messages appear prior to the problem.

The vehicle has experienced repeated intermittent electrical-system-related failures since the start of the lease, which have remained unresolved despite eight months of formal engagement with Volvo and multiple service and software-related repair attempts by Volvo. Most recently, on May 15, 2026, while operating the vehicle in approximately 90°F Arizona temperatures, the vehicle displayed a “Limited Performance / Electrical System Temporarily Limited” warning message. Shortly afterward, the driver was temporarily unable to re-enter the vehicle, despite the exterior door handles deploying normally. Vehicle access was restored only after several minutes. The side view mirrors would not open. Driving for two minutes did not resolve this. After ten minutes of remaining parked the mirrors reconnected. This latest incident follows prior issues including: •Loss of charging capability during a long distance trip (which forced us to drive 50MPH on a 75MPH highway, putting our car and other drivers at risk.) •Multiple incidents involving loss of instrument displays while driving •Intermittent vehicle access and lock-related issues •Unexpected seatbelt tensioning while the vehicle was in motion Volvo previously indicated that software updates and related service efforts should address the issues. However, after the updates the vehicle continues to exhibit intermittent electrical-system-related problems affecting reliability and normal operation.

The contact owns a 2025 Volvo EX90. The contact stated that while the vehicle was parked, an over-the-air software update was attempted but failed. The vehicle locked during the update process and remained inoperable for approximately one hour after the update was completed. On a separate occasion, the vehicle failed to shift into gear while driving on the interstate. The message that the vehicle was not in gear was displayed. The download process took an extended period and after the update was completed the vehicle operated as intended. Additionally, the infotainment system turned black and was inoperable, while the instrument panel was dark, and caused the turn signal indicator and speedometer to become inoperable. The instrument panel was flashing. The vehicle was taken to the dealer where it was determined that the battery was in low power mode. The vehicle was not repaired but was manually updated by the dealer, bypassing the over-the-air process. The manufacturer was notified of the issue. The approximate failure mileage was 1,115.

On November 28, 2025, my 2025 Volvo EX90 displayed a headlight warning message on the dashboard and the headlights failed to function properly while parked and after starting the engine. The defect temporarily resolved but recurred on December 5, 2025. A headlight defect that is not immediately apparent to the driver poses a serious safety risk before or during nighttime driving. The symptoms are consistent with NHTSA Safety Recall No. 25V-071 (Volvo internal reference R10298), which covers 2025 EX90 vehicles and involves unexpected headlight malfunction. I request that NHTSA investigate whether my vehicle's defect is related to Recall No. 25V-071 and whether the recall remedy has been properly implemented. If unrelated to Recall No. 25V-071, I request that NHTSA investigate this as a separate unreported safety defect. Other 2025 EX90 owners may be experiencing the same issue without reporting it. Volvo has contacted me directly on multiple occasions to schedule a central computer replacement on my vehicle. I understand this replacement is being offered to all 2025 EX90 owners. I request that NHTSA investigate whether this widespread hardware replacement is related to the safety defect I experienced and whether it should have been conducted as a formal safety recall. When brought in for repair on December 13, 2025, the service department advised parts were on indefinite backorder with no estimated delivery date. The vehicle remained at the service center for 47 days while Volvo was unable to supply the necessary parts. I request that NHTSA evaluate whether this represents an adequate response to a safety-critical defect.