. I HAVE SPENT $2200 IN THE LAST 3 MONTHS WHILE HERB GORDON TRIES TO FIGURE OUT THE PROBLEM WITH THE BRAKES. THEY HAVE REPLACED THE BRAKE MASTER CYLINDER, CLEANED AND RESEALED THE BRAKE CALIPERS AND NOW AS A LAST RESORT ARE REPLACING THE INTERNAL ABS SYSTEM, WHICH FINALLY FIXED THE PROBLEM. IGNITION SWITCH REPLACED, THE WIND…
Read full complaint
. I HAVE SPENT $2200 IN THE LAST 3 MONTHS WHILE HERB GORDON TRIES TO FIGURE OUT THE PROBLEM WITH THE BRAKES. THEY HAVE REPLACED THE BRAKE MASTER CYLINDER, CLEANED AND RESEALED THE BRAKE CALIPERS AND NOW AS A LAST RESORT ARE REPLACING THE INTERNAL ABS SYSTEM, WHICH FINALLY FIXED THE PROBLEM. IGNITION SWITCH REPLACED, THE WINDSHIELD WIPER BOLTS CAME LOOSE CAUSING THE WINDSHIELD WIPERS TO STOP IN THE MIDDLE OF DRIVING ON A HIGHWAY IN THE RAIN, AIR SENSORS AND OXYGEN SENSORS SEEM TO NEED REPLACING AT LEAST TWICE A YEAR. *NM
NHTSA ODI #10138511
Mileage unknown · May 23, 2005
Electrical SystemFire
UPON STARTING THE VEHICLE, AND BACKING OUT THE DRIVE WAY, CONSUMER SAW SMOKE, SEEMED TO BE COMING FROM UNDER DRIVER'S SEAT. CONSUMER THEN WENT INTO THE HOUSE TO GET WATER. UPON RETURNING TO THE VEHICLE IT WAS ENGULFED IN SMOKE, AND FIRE.*AK *BF *NM
NHTSA ODI #10115446
Mileage unknown · Jun 4, 2002
Electrical System
THE FIRST TWO COMPLAINTS ARE ACTUALLY THE SAME PROBLEM (DISREGARD THE 1ST, "STEERING"). THIS PROBLEM IS CLEARLY THE MOST SIGNIFICANT OF ANY REPORTED; WE HAD TO DISCONNECT THE HORN PERMANENTLY. MECHANICS HAVE TOLD US THAT THE "HORN CONTACTS" WITHIN STEER. *AK
NHTSA ODI #762647
Mileage unknown · Aug 30, 2001
Electrical SystemPower Train
GEAR POSITION SENSOR,S1 & S2 SOLENOIDS: VOLVO HAS KNOWN ABOUT THIS DEFECT FOR SOME TIME AND SHOULD HAVE DECLARED A RECALL.( VOLVO EVEN LOST A SMALL CLAIMS SUIT IN CALIFORNIA OVER THIS FAILURE) WHILE VOLVO PAID $900 OF THE $1300 REPAIR BILL TO REMEDY THE PROBLEM, THEY SHOULD HAVE PAID FOR THE WHOLE BILL. RE: HORN FAILURE, THE VO…
Read full complaint
GEAR POSITION SENSOR,S1 & S2 SOLENOIDS: VOLVO HAS KNOWN ABOUT THIS DEFECT FOR SOME TIME AND SHOULD HAVE DECLARED A RECALL.( VOLVO EVEN LOST A SMALL CLAIMS SUIT IN CALIFORNIA OVER THIS FAILURE) WHILE VOLVO PAID $900 OF THE $1300 REPAIR BILL TO REMEDY THE PROBLEM, THEY SHOULD HAVE PAID FOR THE WHOLE BILL. RE: HORN FAILURE, THE VOLVO MECHANICS SAID VOLVO HAS KNOWN ABOUT THIS PROBLEM ALSO, BUT REFUSES TO DO ANY THING ABOUT IT. MY CAR HAS NOT YET REACHED 50,000 MILES AND I HAVE HAD TO SPEND ABOUT $1,400 DOLLARS TO REPAIR A SUNROOF, REPLACE THE STEERING WHEEL, AND FIX THE SOLENOIDS AND GEAR POSITION SENSORS. I BELIEVE VOLVO SHOULD REIMBURSE ME FOR THESE EXPENDITURES. I HAVE BEEN A VOLVO OWNER SINCE 1972, AND I WILL NEVER BUY ANOTHER VOLVO AGAIN. FOR THE AMOUNT OF MONEY SPENT ON A VOLVO, I COULD HAVE HAD A RELIABLE CAR LIKE A SMALL LEXUS!*AK
NHTSA ODI #751419
Mileage unknown · Jan 15, 2001
Electrical SystemFire
MY CAR BURNED COMPLETELY WITHIN 15-20 MINUTES AFTER LEAVING A CERTIFIED VOLVO DEALERSHIP DUE TO A FIRE. *AK
NHTSA ODI #739415
Mileage unknown · Sep 12, 2000
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
IGNITION COIL REPLACED. *SLC
NHTSA ODI #554552
Mileage unknown · Feb 14, 2000
Electrical SystemVehicle Speed ControlFire
AT 70 MPH, ON CRUISE CONTROL, HAVING BEEN ON THE HIGHWAY CONTINUOUSLY FOR 60+ MILES, THE CRUISE CONTROL CUT OUT, THROTTLE DID NOT RESPOND, SMOKE STARTED BILLOWING FROM BEHIND VEHICLE, ENGINE QUIT AND WITHIN APPROX. 10 SECONDS OF COMING TO STOP AND DRIVER EXITING VEHICLE, CAR WAS ENGULFED IN FLAMES. CONTACTED VOLVO AND THEY REFUS…
Read full complaint
AT 70 MPH, ON CRUISE CONTROL, HAVING BEEN ON THE HIGHWAY CONTINUOUSLY FOR 60+ MILES, THE CRUISE CONTROL CUT OUT, THROTTLE DID NOT RESPOND, SMOKE STARTED BILLOWING FROM BEHIND VEHICLE, ENGINE QUIT AND WITHIN APPROX. 10 SECONDS OF COMING TO STOP AND DRIVER EXITING VEHICLE, CAR WAS ENGULFED IN FLAMES. CONTACTED VOLVO AND THEY REFUSED COMMENT AFTER THEIR INVESTIGATION.
NHTSA ODI #718734
Mileage unknown · Oct 19, 1999
Electrical SystemSteering
DEALER INSPECTED THE STEERING WHEEL AND STATED THAT IT WILL COST $700 TO REPLACE IT. DEALER STATED THAT NONE OF THE OTHER 850 OWNERS HAD ANY PROBLEMS WITH THEIR HORNS. *AK
NHTSA ODI #713567
Mileage unknown · Apr 26, 1999
Electrical System
STEERING WHEEL ELECTRICAL WIRING CONNECTORS SHORTED OUT CAUSING HORN TO BURN. MJS
NHTSA ODI #545145
Mileage unknown · Mar 22, 1999
Electrical System
HORN STUCK IN ON-POSITION WHILE DRIVING ON FWY. HAD TO PULL ONTO SHOULDER AND DISCONNECT WIRES AT HORN. DEALER DETERMINED SHORT OCCURRED INSIDE STEERING COLUMN. COLUMN REPLACED AT A COST OVER $360. VOLVO CUSTOMER SERVICE LINE NOTED THIS HAS BEEN A RECURRENT PROBLEM WITH THIS MAKE/MODEL. REFUSED TO PROVIDE FURTHER DETAILS. …
Read full complaint
HORN STUCK IN ON-POSITION WHILE DRIVING ON FWY. HAD TO PULL ONTO SHOULDER AND DISCONNECT WIRES AT HORN. DEALER DETERMINED SHORT OCCURRED INSIDE STEERING COLUMN. COLUMN REPLACED AT A COST OVER $360. VOLVO CUSTOMER SERVICE LINE NOTED THIS HAS BEEN A RECURRENT PROBLEM WITH THIS MAKE/MODEL. REFUSED TO PROVIDE FURTHER DETAILS. *AK
ON CERTAIN PASSENGER VEHICLES, AFTER PROLONGED EXPOSURE TO HEAT, THE FUEL TANK MAY SEEP OR LEAK FUEL AT THE POINTS WHERE THE HEAT SHIELD IS ATTACHED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: VOLVO WILL INSPECT THE FUEL TANK AND REPLACE IT IF ANY EVIDENCE OF FUEL SEEPAGE OR LEAKAGE IS FOUND. ALL VEHICLES WILL RECEIVE NEW REINFORCEMENT BUSHINGS AT THE HEAT SHIELD ATTACHMENT POINTS TO PREVENT FUTURE LEAKS. THIS RECALL WILL BE CONDUCTED AS A SAFETY RECALL IN THE HOT WEATHER STATES OF ALABAMA, ARKANSAS, ARIZONA, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, AND UTAH, AND AS A SERVICE RECALL IN THE OTHER 33 STATES AND THE DISTRICT OF COLUMBIA. THE RECALL BEGAN ON SEPTEMBER 24, 2004. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
SOME OF THE JACKS SUPPLIED WITH THE VEHICLES DO NOT HAVE THE NECESSARY LOAD CAPACITY.
Consequence: A RAISED VEHICLE CAN FALL OFF THE JACK INCREASING THE LIKELIHOOD FOR PERSONAL INJURY OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT AND REPLACE SUSPECT JACKS WITH A JACK MEETING THE LOAD REQUIREMENTS FOR THESE CARS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA03008 · Fuel Tank Leaks
Opened Jun 11, 2003 · Closed Jul 28, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
THIS ENGINEERING ANALYSIS WAS OPENED ON JUNE 11, 2003, BASED ON 54 REPORTS OF FUEL TANK LEAKS.THE SUBJECT VEHICLES WERE 1993 THROUGH 1996 MODEL YEAR (MY) 850 VEHICLES. MODEL 850 WAS ALSO PRODUCED IN MY 1997 AND WAS INCLUDED IN THIS INVESTIGATION. ANALYSIS OF THE DATA REVEALS TWO DISTINCT ISSUES. FIRST, THE 1994 THROUGH 1997 MY VEHICLES STAND OUT BY ACCOUNTING FOR 95 PERCENT OF THE REPORTED LEAKS.THESE VEHICLES SHARE THE SAME FUEL TANK DESIGN (PN 9142618). THE 1993 MY VEHICLE USES A DIFFERENT FUEL TANK DESIGN (PN 9141101).SECONDLY, THE FAILURES OCCURRED PREDOMINANTLY IN HOT CLIMATES, E.G., CALIFORNIA, ARIZONA, TEXAS, FLORIDA, GEORGIA, LOUISIANA, ETC.TESTING OF FUEL TANKS FROM CONSUMER VEHICLES AT THE VEHICLE RESEARCH AND TEST CENTER CONFIRMED LEAKS THROUGH CRACKS IN THE FUEL TANK WALL AT A HEAT SHIELD MOUNTING ATTACHMENT IN THE 1994 THROUGH 1997 MY FUEL TANKS (PN9142618). DETAILS OF THE TESTS ARE AVAILABLE IN TEST REPORT VRTC-DCD3060.VOLVO WILL CONDUCT A SAFETY RECALL ON ALL MY 1994 THROUGH 1997 VEHICLES ORIGINALLY SOLD OR REGISTERED IN THE FOLLOWING 17 HOT STATES: CA, AZ, NM, TX, LA, MS, AL, GA, SC, FL, NC, TN, AR, OK, UT, NV, AND HI.ALL 1994 THROUGH 1997 MY VEHICLES IN ALL OTHER STATES WILL BE REMEDIED UNDER A SERVICE CAMPAIGN.THE REMEDY FOR BOTH THE RECALL AND SERVICE CAMPAIGN IS TO INSTALL A NEW BUSHING AT EACH HEAT SHIELD ATTACHMENT POINT (3 PER TANK).ALSO, ALL TANKS (VEHICLES IN ALL STATES) WILL BE INSPECTED FOR FUEL SEEPAGE AT THE HEAT SHIELD ATTACHMENT POINTS AND VOLVO WILL REPLACE ANY TANK SHOWING SIGNS OF FUEL SEEPAGE.THE NEW BUSHINGS WILL PREVENT HEAT SHIELD STRESSES FROM BEING TRANSFERRED TO THE THREE HEAT SHIELD MOUNTING ATTACHMENTS ON THE FUEL TANK.THE SAFETY RECALL IS FILED UNDER NHTSA SAFETY RECALL NUMBER 04V368.THIS INVESTIGATION IS CLOSED.
THE OFFICE OF DEFECTS INVESTIGATION OPENED THISINVESTIGATION ON JANUARY 16, 2003.THE BASIS FOR OPENING THE INVESTIGATION WAS 15 CONSUMER REPORTS ALLEGING GASOLINE LEAKING FROM THE FUEL STORAGE TANK.VOLVO PROVIDED 43 ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION, 4 OF WHICH WERE DUPLICATES OF THE 15 ODI REPORTS. THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
1995 Volvo 850 Problems, Complaints & Recalls | Skip That Year
Illustration