Travel assist constantly beeping for no reason. Ok reversing some times the car engages emergency break for no reason. Multiple engine cut outs at various times. Key issues - car not identifying key, delays in starting vehicle and some situations where I am locked in the car
COMPONENT SPOTLIGHT
Volkswagen Tiguan electrical problems
534 distinct owner reports with an electrical-system component in this snapshot.
Includes the electrical-system component and its detailed subcategories. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.
8 crash reports13 fire reports8 injury reports
Reports by model year
YearTopic reportsRecallsInvestigations
20268
00202514
30202421
20202311
10202262
50202125
50202034
30201956
50201843
142201712
40201627
21201523
40201422
33201335
33201223
33201147
34201031
22200940
31Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.
When problems were reported
Mileage at the reported incident
490–25K
7825–50K
5850–75K
2275–100K
18100–150K
4150K+
229 reports with mileage · 305 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What owners actually said
534 reportsThe engine started smoking at 11,000 and new valve seals were replaced in the head. The engine has started to smoke again at 16,800 mile and dealer said the next step would be to replace the head. Car has been to the dealer 6-7 times for electrical and engine problems. The SOS light comes on almost every morning. Driver seat mem…
Read full complaint
The engine started smoking at 11,000 and new valve seals were replaced in the head. The engine has started to smoke again at 16,800 mile and dealer said the next step would be to replace the head. Car has been to the dealer 6-7 times for electrical and engine problems. The SOS light comes on almost every morning. Driver seat memory does not work and dealer can't figure it out after 5-6 times, they have replaced about everything on the seat and it still doesn't work.
I was at a complete stop at the red light, vehicle began shaking and shut down. Gears would not work therefore I was not able to put it in neutral to at least push out of the road. The vehicle then began cranking on and off on its own, without me pushing start/stop engine. This was completely unexpected as the truck is one week …
Read full complaint
I was at a complete stop at the red light, vehicle began shaking and shut down. Gears would not work therefore I was not able to put it in neutral to at least push out of the road. The vehicle then began cranking on and off on its own, without me pushing start/stop engine. This was completely unexpected as the truck is one week old, had a full tank of gas and it was especially dangerous to have shut down on a busy highway. Also when reversing the vehicle makes a weird click noise.
One time the car Just Lost power on the freeway and the e-card engine light came on and the cat Ran rugh and stalled and jerked hard almost causing me to cause a serious accident...I took it to vw and explained the severity and they bypassed that And installed a new water pump..2months later the same thing happened exactly…
Read full complaint
One time the car Just Lost power on the freeway and the e-card engine light came on and the cat Ran rugh and stalled and jerked hard almost causing me to cause a serious accident...I took it to vw and explained the severity and they bypassed that And installed a new water pump..2months later the same thing happened exactly to where I was very lucky and very upset...and took it to them once again and explained more issues where I'm urging . As to the front warning light and motion has came into play a few times witch was shocking...also the car would be on slow mo mode....and constant warning lights would come on the dashboard as well as the car would feel so unstable and Feel as if it were On gear 1/L while in the drive position...also the Eco turn of feature would playout ..and stall from time to time..then the car would get stuck on speed when foot would come off the accelerator to brake before a stop sign or red light intersection witch just started to concern me and I again took these concerns to Rick case vw and They thought I was inventing this story..then the car leaked coolant..and it rusted out the whole bottom of my car ..hoses...and they replaced the thermostat this time around and now the car has misfired..could not start ..idle was ver rough and just vibrated dramatically and damaged coils and spakplugs and blew out fuel inject #2 and can't hold pressure past 30 ..changed out the spak plugs and coils and the car is just crippled and its a safety hazard and in many occasions has almost caused me to cause a serious accident...
The wireless phone charger in my 2023 VW Tiguan does not function as intended and consistently fails to charge any phone, regardless of placement, brand, or case. The charging pad repeatedly disconnects, overheats the phone, or never initiates charging at all, making the feature completely unusable. This is a safety concern beca…
Read full complaint
The wireless phone charger in my 2023 VW Tiguan does not function as intended and consistently fails to charge any phone, regardless of placement, brand, or case. The charging pad repeatedly disconnects, overheats the phone, or never initiates charging at all, making the feature completely unusable. This is a safety concern because it encourages drivers to handle their phones while driving after assuming the vehicle would keep the device charged.
In July, Chicagoland was very hot and my car stays in the garage. The piece that holds the sun roof control panel on the ceiling melted and came partially off. It’s been hanging since then since I was told it wasn’t ready to be fixed yet since there is no recall. I’ve been waiting but now my SOS feature is inoperable.
I am experiencing the Driver Door Control Switch / EBS error. When this occurs my emergency break activates when I am driving, throwing me into a complete stop unexpectedly, pulls several check engine lights and a series of loud distracting alert sounds. This is extremely dangerous on the road and I’ve almost been rear-ended mul…
Read full complaint
I am experiencing the Driver Door Control Switch / EBS error. When this occurs my emergency break activates when I am driving, throwing me into a complete stop unexpectedly, pulls several check engine lights and a series of loud distracting alert sounds. This is extremely dangerous on the road and I’ve almost been rear-ended multiple times. I have brought my vehicle in to Volkswagen and European Specialty Auto Shop and they were not able to replicate the issue thus we’re not able to help me. There are several forums online that point to this being a recall issue with Volkswagen and yet my VIN number is showing as not affected. It is my understanding that this issue is being caused by a faulty driver door wiring harness. It is random when this issue occurs. Forums online have led me to believe it is due to weather fluctuations. At this point I no longer feel safe driving my vehicle. This needs to be escalated to a Volkswagen as a public safety concern.
I’ve had my Volkswagen Tiguen since 2021 fresh off the lot. I have been the only owner of the car at about 30,000 miles my head gasket blew, causing the engine to go into default after weeks in the dealer. They replaced the head gasket and stitched it up, the head gasket blew again at this point I was still under warranty so the…
Read full complaint
I’ve had my Volkswagen Tiguen since 2021 fresh off the lot. I have been the only owner of the car at about 30,000 miles my head gasket blew, causing the engine to go into default after weeks in the dealer. They replaced the head gasket and stitched it up, the head gasket blew again at this point I was still under warranty so they agreed to replace the engine. It drove fine after the engine was replaced this year 2025. I started to have a whole host of problems. It began to jerk and hesitate at acceleration. My engine light came on with continuous jerking upon acceleration for weeks until I started to lose power in my engine. I couldn’t go over 50 60 mph. I would always pull the car over power it off and power it back on just to see if it would change and it didn’t do much I had a local mechanic add oil to each tire also drain the engine, which had shards of metal in it. And basically stitch the car back together until we can figure out the bigger issues. It’s only been a day since the oil was added to each tire. I had a very violent jerk of the engine, which made it feel and sound like I blew a tire I got out to look at the tire and it was just fine. It was the backfire of the engine going into the exhaust that caused such the violent jerk. Happy that no one was on the road. If somebody was behind me it would’ve easily been an accident. Most of these dealerships know exactly what’s going on and have been avoiding the big conversation of what to do next they rather just replace and Band-Aid these things into the consumer just gives up. I have two small children and this is the only means of transportation. I’m fearful that I’ll be stuck with a car note for a car. I can’t drive.
The defect has occurred since the day the vehicle was leased. The entire multimedia and safety interface shuts down randomly while driving (screen goes black, GPS stops, rear camera and driver-assistance functions stop working). This happens in multiple areas across the city, not in a single location. The dealership initially bl…
Read full complaint
The defect has occurred since the day the vehicle was leased. The entire multimedia and safety interface shuts down randomly while driving (screen goes black, GPS stops, rear camera and driver-assistance functions stop working). This happens in multiple areas across the city, not in a single location. The dealership initially blamed my internet or phone, delaying proper diagnosis. The first available service appointment was more than a month later, and the vehicle was first taken in on January 27, 2025. Since then, the vehicle has been in the shop more than five times across multiple dealerships, including over a month during the most recent repair attempt. I have also been required to visit the dealership more than 30 times for the same issue. Dealership technicians and the service manager stated that the vehicle is defective, that nothing else can be done, and that all repair attempts have failed. The manufacturer claims it is an “environmental connectivity issue” in one spot, which is not accurate. Multiple videos requested and submitted show the failure happening in different areas of the city. At the dealership’s request, I drove with a technician who recorded the failure again. Customer Care instructed me to return the loaner vehicle immediately and take back the defective vehicle, even though it is unsafe to operate. The Customer Care manager refused to speak with me and required an appointment several days later, but they still demanded that I return the loaner and pick up the unsafe vehicle now. When I requested written documentation acknowledging that the vehicle is unsafe, they refused to provide it. This is an unresolved, repeated safety defect that puts me at risk while driving. Please, I'll appreciate any help. Thank you in advance.
The infotainment center freezes and spontaneously disconnects. At first, I though it was my phone and switched carriers. It was not. It also does not recognize my key is present and I have to pshycially lock and unlock it. Sometimes the doors won't open and it happens several times. It is unsafe when I am driving and the gps goe…
Read full complaint
The infotainment center freezes and spontaneously disconnects. At first, I though it was my phone and switched carriers. It was not. It also does not recognize my key is present and I have to pshycially lock and unlock it. Sometimes the doors won't open and it happens several times. It is unsafe when I am driving and the gps goes out and I have been distracted, missed turns and put myself and others in danger. Also, you can only get gas if the doors are unlocked. This is not safe becasuse someone could take your purse or child while you are pumping gas. The vehicle has been updated, keys replaced but nothing has helped the issue. There were no warning lights.
Related Official recalls
326V587000 · Electrical System:body Control Module:software
Sep 10, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2025 Tiguan vehicles. A software error may cause the body control module (BCM) system to reset. This may result in the ignition switching off, resulting in an engine stall. It can also lead to a loss of certain controls, warning lights, exterior lighting, or failure of the rearview camera system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Controls and Displays," and 102, "Transmission shift lever sequence, starter interlock, and transmission braking effect," as well as FMVSS numbers 111 and 108.
Consequence & remedy
Consequence: An unexpected engine stall, loss of exterior lighting or warning lights, or failure of the rearview camera system can increase the risk of a crash.
Remedy: Dealers will update the body control module (BCM) software, free of charge. Owner notification letters are expected to be mailed November 6, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 57KL. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 17, 2026.
18V824000 · Electrical System: Instrument Cluster/panel
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
13V569000 · Electrical System:wiring:fuses And Circuit Breakers; Exterior Lighting
Nov 22, 2013
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2011 Tiguan vehicles manufactured July 2007 through June 2011. Due to a problem with the fuse for the exterior lights, the holder for the fuse that controls the vehicle's exterior lights circuit may melt.
Consequence & remedy
Consequence: If the holder melts, there may be a partial loss of exterior lighting. Reduced vehicle illumination diminishes the vehicle's visibility, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuse, free of charge. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 97Z9/2V.
Additional source detail variants (2)
Exterior Lighting
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2011 Tiguan vehicles manufactured July 2007 through June 2011. Due to a problem with the fuse for the exterior lights, the holder for the fuse that controls the vehicle's exterior lights circuit may melt.
Consequence: If the holder melts, there may be a partial loss of exterior lighting. Reduced vehicle illumination diminishes the vehicle's visibility, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuse, free of charge. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 97Z9/2V.
Electrical System:wiring:fuses And Circuit Breakers
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2011 Tiguan vehicles manufactured July 2007 through June 2011. Due to a problem with the fuse for the exterior lights, the holder for the fuse that controls the vehicle's exterior lights circuit may melt.
Consequence: If the holder melts, there may be a partial loss of exterior lighting. Reduced vehicle illumination diminishes the vehicle's visibility, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuse, free of charge. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 97Z9/2V.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Related NHTSA investigations
2PE15010 · Air Bag Clockspring Failure
Opened Mar 24, 2015 · Closed Sep 28, 2015
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Additional source detail variants (3)
Air Bags:frontal
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Air Bags
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
PE13036 · Partial Loss Of Exterior Lights
Opened Nov 4, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:fuses And Circuit Breakers; Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:back Up Lights:switch; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Additional source detail variants (21)
Electrical System
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Electrical System:wiring:fuses And Circuit Breakers
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:back Up Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:back Up Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:brake Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:brake Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:fog Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:fog Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:hazard Flashing Warning Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:hazard Flashing Warning Lights:unit
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:hazard Flashing Warning Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights:concealment Devices
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights:high/low Beam Dimmer Switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:tail Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:tail Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:turn Signal:flasher Unit
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:turn Signal:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:turn Signal
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.