2010 Volkswagen Routan

Battery failure due to parasitic draw from Ignition IOD fuse ( J13fuse) reads 0.9 draw and M11 fuse ( hvac system) reads 0.6 draw. First occurrence 2/10/24 and second occurrence 2/11/24. Informed auto repair shop on 2/12/24 and goes in for diagnostic 2/15/24. Abs control module failure( intermittent ) Egr valve replacement (8/9/24 due to overheating but no warning lights due to overheating was displayed which is strange) Speed control sensor was replaced as well 8/9/24 but still has problems getting stuck or not reading the right speed . Consumes fuel faster than normal as well . Getting about 9 miles to the gallon.

This has happened multiple times. The ignition will cut off which make the car engine quit running. Loss of braking, steering, power has left me in the middle of intersections being nearly avoided being ran into. When this happens all the warning lights come on and the engine turns off. The exact problem VW recall number 28H1 is affecting my vehicle.

I WAS DRIVING HOME FROM WORK APPROX. 30-35 MILES PER HOUR AND MY VAN DIED. I LOST POWER STEERING AND BRAKES. LUCKILY I WASN'T SERIOUSLY INJURED. THERE WAS NO WARNING. NO SERVICE ENGINE LIGHT. WITHIN A SPAN OF LESS THAN 2 YEARS IVE ALREADY REPLACED THE FUEL PUMP, THE BATTERY, AND THE ALTERNATOR IS STILL NEW AND UNDER WARRANTY. THE IGNITION/POWER WINDOWS FUSE CONSTANTLY NEEDS ADJUSTING SO I CAN ROLL MY WINDOW UP OR DOWN. ALL THE DASH LIGHTS COME ON RANDOMLY AS WELL. SOMETIMES THE WINDSHIELD WIPERS WOULD COME ON. NEVER HAD A VEHICLE DIE ON ME WHILE DRIVING DUE TO MANUFACTURERS ISSUES. AFTER READING OTHER CONSUMER COMPLAINTS ABOUT THE SAME ISSUES IM VERY CONFIDENT ITS THE TIPM. SOME COMPLAIN THAT THIS COSTS PEOPLE $1 000S ON A CHANCE THAT YOU CAN GET A COUPLE MORE YEARS OUT OF IT. THE VAN WANTS TO TURN OVER AND CONTINUES CRANKING WHEN KEY FOB IS IN IGNITION BUT DOESN'T TURN OVER. I CANNOT GET IT TO START AT ALL.

REPORTED ISSUE TO VW RECALL GROUP VIA TELEPHONE 5/13/2019. THIS IS VERY SIMILAR TO A RECALL THAT TOOK PLACE FOR VW ROUTAN 2009-2010 THAT WERE CREATED BETWEEN THE DATES OF OCTOBER 2019 TO JUNE 2010. OUR VEHICLE WAS CREATED IN AUGUST OF 2010, AND I SUSPECT THE SAME PARTS WERE STILL USED. TWO ISSUES HAVE OCCURRED WITH 2010 VW ROUTAN SEL MINIVAN 4.0L ISSUES STARTED OCCURRING AFTER REPLACING A LOST KEY FOB. KEY FOB WAS ORDERED THROUGH LOCAL VW DEALER (BOB KING VW) AND REPLACED. FIRST ISSUE: CAR WOULD NOT START. PUT KEY INTO IGNITION SWITCH, TURN KEY, THE IGNITION SWITCH CLICKS BUT THE CAR WOULD NOT START. IN ORDER TO START CAR, WAIT AND REPEAT STEPS UNTIL CAR ACTUALLY STARTS. SECOND ISSUE: (HIGHLY DANGEROUS) INTERMITTENT SHUT OFF WHILE DRIVING CAUSING POWER STEERING TO TURN OFF AS WELL AS BRAKES. VERY DANGEROUS COMBINATION DUE TO THE FACT THAT TURNING BECOMES VERY DIFFICULT AS WELL AS BRAKING. IN ORDER TO BRAKE YOU HAVE TO APPLY GREAT FORCE TO BREAK SINCE THERE IS NO POWER TO THE CAR. THIS ISSUE HAS BEEN ENCOUNTERED OVER THE PAST TWO MONTHS AT LEAST FOUR (4) TIMES WHILE THE PRIMARY DRIVER HAS BEEN DRIVING THE VEHICLE. THE FIRST THREE TIMES THE VEHICLE WAS IN MOTION IN A RESIDENTIAL AREA. THE LAST TIME THIS ISSUE OCCURRED 5/13/2019 THE VEHICLE WAS IN MOTION ON A MAJOR ROAD WAY NEAR AN INTERSECTION. EVASIVE MANEUVERS WERE TAKEN TO GET VEHICLE OFF OF ROAD AND INTO A NEARBY PARKING LOT OFF THE STREET.

MY VAN SHUT DOWN WHILE DRIVING FOR THE FOURTH TIME. I WAS SLOWING DOWN TO A STOP AT A LIGHT AND THE ENGINE LOST POWER AND I LOST POWER STEERING AND BRAKES. THIS HAS BEEN HAPPENING MUCH MORE FREQUENTLY NOW THAN BEFORE (WITH 3 TIMES IN THE LAST MONTH). MY VAN IS NOT INCLUDED IN WIN MODULE RECALL AS THE VIN IS A COUPLE OF DIGITS OFF. THIS IS VERY FRUSTRATING AND SCARY.

WHEN DRIVING DOWN THE ROAD GOING ABOUT 30MPH MY CAR SUDDENLY SHUT OFF. NO INDICATOR LIGHTS CAME ON AND MY POWER STEERING WAS GONE AS WELL AS MY ABILITY TO BRAKE WELL. LOOKING ONLINE THEIR WAS A RECALL ON MY MODEL YEAR AND MAKE OF VAN FOR THE SAME PROBLEMS WITH THE IGNITION SWITCH BUT MY VIN NUMBER DID NOT PULL UP A RECALL. I CONTACTED VW AND THEY ALSO STATED MY CAR WAS NOT PART OF THAT RECALL. THANKFULLY I WAS ABLE TO PULL TO SIDE OF THE ROAD SAFELY.

MY VAN HAS SHUT OFF TWICE NOW WHILE DRIVING. BOTH EVENTS HAVE OCCURRED WHILE TURNING RIGHT, AT A SLOW SPEED ON CITY STREETS (ONE TIME WITH MY CHILDREN IN THE VEHICLE). I LOSE POWER STEERING AND BRAKES AND THE ENGINE APPEARS TO SHUT DOWN (RADIO REMAINS ON). WHEN I FIRST TRIED TO RESTART IT, IT WOULDN'T AND THEN THE SECOND ATTEMPT SOUNDED UNUSUAL BUT IT DID START. THE TRACTION CONTROL LIGHT LIT UP ON THE DASHBOARD AS WELL. BOTH TIMES WERE IN GOOD DRIVING CONDITIONS. AFTER THE FIRST TIME, DUE TO MY RESEARCH ON THE ISSUE, I ONLY USE THE FOB WITH NOTHING ELSE HANGING FROM IT. IN ADDITION, I ALSO HAVE THE ISSUE OF THE VEHICLE RANDOMLY NOT STARTING. I USUALLY GET IT TO START BY FIDDLING WITH THE SHIFTER. OF COURSE, MY VAN IS NOT INCLUDED IN THE IGNITION MODULE RECALL, WHICH IS COMPLETELY ABSURD AS IT IS CLEARLY HAPPENING TO A LOT OF US. I LOVE EVERYTHING ABOUT THIS VAN EXCEPT FOR THESE TWO MAJOR ISSUES.