IllustrationWHEN CAR IS RUNNING, EITHER IN PARK OR DRIVE, THE ENGINE CUTS OUT. WE MUST WAIT 30 SEC TO RESTART. IT WILL THEN RESTART. THIS ACTION HAPPEND BOTH WHEN THE CAR IS IN PARK AND DRIVE. THE ACTION HAPPENED ONCE IN OUR DRIVEWAY AND ONCE COMING OUT OF A CARRY OUT DRIVEWAY.
2010 Volkswagen Routan
Owner reports · Recalls · Investigations
More warning signs than most Routan years
Owner complaints for the 2010 Volkswagen Routan are substantially higher than the model-year median of 63.
About this comparison →How this year compares
Owner complaints by model year
Compare all Routan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
420–25K
2325–50K
3950–75K
3875–100K
45100–150K
11150K+
198 reports with mileage · 42 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 150 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports3 fire reports8 injury reports
Electrical System complaints
150 reportsTHE ELECTRIC REAR SLIDING DOOR HAS BECOME STUCK SHUT AND NO POWER GOES TO THE DOOR. THE KEY BECOMES STUCK AND THE IGNITION AND ARE UNABLE TO REMOVE IT. THERE HAVE BEEN RECALLS FOR THE SAME MAKE AND MODEL WITH THESE ISSUES, BUT THERE ARE NO RECALLS FOR THESE ISSUES TIED TO OUR VIN. *TR
DRIVERS SIDE SLIDING DOOR WILL NOT OPEN. I'VE TRIED ALL KINDS OF WAYS TO OPEN IT AND IT WILL NOT BUDGE. ALSO, WHEN DRIVING, CAR SHUT OFF WITH NO WARNING.
EVERY ONCE IN A WHILE THE CAR DOES NOT START, EVERYTHING WORKS INCLUDING THE WINDOWS, LIGHTS BUT ENGINE DOES NOT START. I HAVE HAD BATTERY, ALTERNATOR, AND STARTER REPLACED, AND IT IS STILL DOING IT. HARD FOR REPAIR SHOP TO DIAGNOSE BECAUSE IT DOESN'T DO IT WHEN IT'S THERE. MOST OF THE TIME IT FINALLY STARTS AFTER ABOUT 8 TO TEN…
Read full complaint
EVERY ONCE IN A WHILE THE CAR DOES NOT START, EVERYTHING WORKS INCLUDING THE WINDOWS, LIGHTS BUT ENGINE DOES NOT START. I HAVE HAD BATTERY, ALTERNATOR, AND STARTER REPLACED, AND IT IS STILL DOING IT. HARD FOR REPAIR SHOP TO DIAGNOSE BECAUSE IT DOESN'T DO IT WHEN IT'S THERE. MOST OF THE TIME IT FINALLY STARTS AFTER ABOUT 8 TO TEN TIMES OF PERIODICALLY TURNING THE KEY. THE VEHICLE IS STATIONARY WHEN THIS HAPPENS.
RECALL: 11V151000 / 28G1/U8 I ALMOST GOT INTO AT LEAST 3 TIMES A BIG ACCIDENT, AS ENGINE SHUTTING OFF SUDDENLY WHILE I'M DRIVING. THIS HAPPENS ANYWHERE: HIGHWAY ; INTERSECTIONS, AND IN HEAVY TRAFFIC. AFTER INSPECTION BY A VOLKSWAGEN SPECIALIST AT 'E&C AUTO REPAIR'. FERNANDO CONCLUSION: ENGINE SHUTTING OFF BECAUSE THEY HA…
Read full complaint
RECALL: 11V151000 / 28G1/U8 I ALMOST GOT INTO AT LEAST 3 TIMES A BIG ACCIDENT, AS ENGINE SHUTTING OFF SUDDENLY WHILE I'M DRIVING. THIS HAPPENS ANYWHERE: HIGHWAY ; INTERSECTIONS, AND IN HEAVY TRAFFIC. AFTER INSPECTION BY A VOLKSWAGEN SPECIALIST AT 'E&C AUTO REPAIR'. FERNANDO CONCLUSION: ENGINE SHUTTING OFF BECAUSE THEY HAVE A PROBLEM WITH THE ELECTRICAL SYSTEM IGNITION SWITCH. THIS IS A SAFETY PROBLEM UNDER VOLKSWAGEN'S RECALL. DRIVING THIS VEHICLE IS AN INCREDIBLE THREAT TO THE PUBLIC ROAD. THE DRIVER, PASSENGERS, AND THE SURROUNDING TRAFFIC PARTICIPANTS ARE EXPOSED TO A SAFETY RISK. BASED ON INFORMATION ON CAMPAIGN 28G1/U8 (MANUFACTURE DATE FROM OCTOBER 2009 THROUGH JUNE 2010), MY VEHICLE (MANUFACTURE DATE: MARCH 2010) IS QUALIFIED FOR REPAIR UNDER A SAFETY RECALL. PLEASE PROVIDE ME AUTHORIZATION NUMBER, FOR A LOCAL DEALERSHIP, TO BE DONE SAFETY REPAIR
IT TURNS ON ALL THE LIGHTS ON THE DASHBOARD SAYING IT NEEDS AUTO ASSIST SERVICE THERE IS NO PROBLEM WITH IT THE DEALER CANNOT TAKE CARE OF IT BECAUSE THEY DON'T TAKE CARE OF VOLKSWAGEN ROUTAN NO MORE
THE ENGINE STALLS AS THE VEHICLE IS DRIVEN AND IT LOCKS THE STEERING WHEEL. THIS HAPPENS WHILE CAR IN MOTION,NOTICED A PREVIOUS RECALL FOR THIS ISSUES HOWEVER IT SEEMS TO BE HAPPENING AGAIN AND I DON'T THINK MY VIN WAS INCLUDED IN RECALL.
STARTED HAVING A KEY FOB ISSUE AROUND 80K MILES. IGNITION WOULD NOT TURN OFF CORRECTLY CAUSING BATTERY TO DRAIN. SPOKE WITH VW INFORMED ME NO RECALL. ISSUE ESCALATED TO THE POINT THAT THE KEY FOB WILL RANDOMLY EJECT FROM THE IGNITION WHILE THE CAR IS RUNNING AND IN MOTION. SOMETIMES THE CAR WILL LOSE POWER AND HAVE TO BE PULLE…
Read full complaint
STARTED HAVING A KEY FOB ISSUE AROUND 80K MILES. IGNITION WOULD NOT TURN OFF CORRECTLY CAUSING BATTERY TO DRAIN. SPOKE WITH VW INFORMED ME NO RECALL. ISSUE ESCALATED TO THE POINT THAT THE KEY FOB WILL RANDOMLY EJECT FROM THE IGNITION WHILE THE CAR IS RUNNING AND IN MOTION. SOMETIMES THE CAR WILL LOSE POWER AND HAVE TO BE PULLED OVER AND RESTARTED. OBVIOUSLY THIS IS NOT SAFE WHILE DRIVING DOWN THE HIGHWAY.
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START INTERMITTENTLY. WHILE DRIVING, THE KEY FELL OUT OF THE IGNITION SWITCH AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REFERRED THE CONTACT TO THE LOCAL DEALER. BRUNSWICK VOLKSWAGEN …
Read full complaint
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START INTERMITTENTLY. WHILE DRIVING, THE KEY FELL OUT OF THE IGNITION SWITCH AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REFERRED THE CONTACT TO THE LOCAL DEALER. BRUNSWICK VOLKSWAGEN (1420 INDUSTRIAL PKWY S, BRUNSWICK, OH 44212, (833) 269-4092) DIAGNOSED THAT THE WIN MODULE AND TWO KEYS WERE NEEDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 190676488. THE FAILURE MILEAGE WAS 140,000. THE VIN WAS NOT AVAILABLE.
THE ENGINE STALLS AS THE VEHICLE IS DRIVEN AND IT LOCKS THE STEERING WHEEL. THIS HAPPENED ABOUT 8 TIMES WITHIN THE PAST 24 MONTHS. WE DISCOVERED THAT 12,000 AND MORE ROUTAN 2009 AND 2010 HAVE BEEN RECALLED FOR THE SAME PROBLEMS WITH SOME FATALITIES REPORTED DUE TO THIS DEFECT: IGNITION MODULS AND ELECTRONIC MODULS. VW AND GM…
Read full complaint
THE ENGINE STALLS AS THE VEHICLE IS DRIVEN AND IT LOCKS THE STEERING WHEEL. THIS HAPPENED ABOUT 8 TIMES WITHIN THE PAST 24 MONTHS. WE DISCOVERED THAT 12,000 AND MORE ROUTAN 2009 AND 2010 HAVE BEEN RECALLED FOR THE SAME PROBLEMS WITH SOME FATALITIES REPORTED DUE TO THIS DEFECT: IGNITION MODULS AND ELECTRONIC MODULS. VW AND GM-CHRYSLER ARE NOT SUPPORTING THE VW. DEALER REPAIR/REPLACEMENT AS MY VW ROUTAN SEEMS NOT HAVING BEEN TRACKED DOWN DURING INITIAL RECALLS.
Official recalls
215V194000 · Electrical System:ignition:switch
Apr 1, 2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles manufactured June 25, 2008, to July 8, 2009, and 2010 Routan vehicles manufactured October 1, 2009, to August 11, 2010. This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including, but not limited to, air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on June 23, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 28H1. Note: This recall supersedes recalls 11V151 and 14V396. Vehicles that previously received an ignition switch trim ring as a recall remedy must have their vehicles remedied again under this campaign. Vehicles that have already received a new ignition switch are not covered by this campaign.
11V151000 · Electrical System:ignition:switch
Mar 1, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2010 ROUTAN VEHICLES MANUFACTURED FROM OCTOBER 2009 THROUGH JUNE 2010. SOME VEHICLES MAY EXPERIENCE INADVERTENT IGNITION KEY DISPLACEMENT FROM THE RUN TO ACCESSORY POSITION WHILE DRIVING CAUSING THE ENGINE TO SHUT OFF.
Consequence & remedy
Consequence: AN ENGINE SHUTTING OFF SUDDENLY WHILE DRIVING COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE WIN MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.