← New search

2009 Volkswagen Routan

Owner reports · Recalls · Investigations

More warning signs than most Routan years

Owner complaints for the 2009 Volkswagen Routan are substantially higher than the model-year median of 63.

About this comparison →

When problems were reported

Mileage at the reported incident

249 reports with mileage · 45 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports3 fire reports9 injury reports

What owners actually said

294 reports
Mileage unknown · Jul 22, 2021
Structure

The brackets that hold the automatic door wires brake continuously. Then the wire gets pinched in the door and it causes a large amount of electrical problems. The abs, esp bad, brake, and traction control lights come on when the wire gets pinched. These doors were made very poorly and should have been looked over before this…

Read full complaint

The brackets that hold the automatic door wires brake continuously. Then the wire gets pinched in the door and it causes a large amount of electrical problems. The abs, esp bad, brake, and traction control lights come on when the wire gets pinched. These doors were made very poorly and should have been looked over before this vehicle was made.

NHTSA ODI #11425987

134,000 miles · Apr 19, 2021
Electrical SystemEngineService Brakes

THANK GOD I WAS NOT GOING FAST. VEHICLE SHUT DOWN COMPLETELY WHILE DRIVING. WAS ABLE TO PUT IN PARK AND WAS ABLE TO START IT BACK UP. APPARENTLY, THE ROUTAN IS MANUFACTURED BY CRYSLER AND THIS ISSUE ALSO HAPPENS WITH THE 09 TOWN AND COUNTRIES AS WELL.

NHTSA ODI #11412826

140,000 miles · Mar 17, 2021
Service Brakes

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE ESC WARNING LIGHT SUDDENLY DISPLAYED, AND THE BRAKING SYSTEM ERRONEOUSLY ACTIVATED CAUSING THE VEHICLE TO ABRUPTLY STOP. THE CONTACT STATED THAT AFTER TURNING OFF AND RESTARTING THE VEHICLE, THE VEHICLE OPERATED NORMALL…

Read full complaint

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE ESC WARNING LIGHT SUDDENLY DISPLAYED, AND THE BRAKING SYSTEM ERRONEOUSLY ACTIVATED CAUSING THE VEHICLE TO ABRUPTLY STOP. THE CONTACT STATED THAT AFTER TURNING OFF AND RESTARTING THE VEHICLE, THE VEHICLE OPERATED NORMALLY. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

NHTSA ODI #11403438

115,000 miles · Jan 29, 2021
Air Bags

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THE AIR BAGS WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE ORC MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AS OF YET. A DEALER WAS CONTACTED. UPON INVESTIGATION, THE CONTACT ASS…

Read full complaint

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THE AIR BAGS WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE ORC MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AS OF YET. A DEALER WAS CONTACTED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 16V083000 (AIR BAGS) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.*DT*JB

NHTSA ODI #11390616

104,000 miles · Dec 15, 2020
Electrical SystemEngineSteering

VAN HAS STALLED WHILE DRIVING ON MULTIPLE OCCASIONS. POWER STEERING IS LOST. VEHICLE WILL THEN START RIGHT BACK UP. THIS IS EXTREMELY DANGEROUS FOR A MINIVAN USED TO TRANSPORT MULTIPLE CHILDREN. NO CODES OR FAULTS ARE RECORDED.

NHTSA ODI #11383517

119,000 miles · Oct 16, 2020
Electrical SystemService BrakesSteering

FIVE TIMES IN THE PAST 6 MONTHS THE POWER IN THE VAN BASICALLY TURNS OFF. THE STEERING BECOMES NEXT TO IMPOSSIBLE AND THE BRAKES BECOME EXTREMELY TIGHT TO THE POINT YOU CAN'T EVEN USE THEM. IT IS TERRIFYING TO HAVE ZERO CONTROL OVER YOUR CAR CONSIDERING I HAVE 4 CHILDREN. IT HAS HAPPENED WHILE I WAS GOING ONLY 30MPH AND ALSO WHE…

Read full complaint

FIVE TIMES IN THE PAST 6 MONTHS THE POWER IN THE VAN BASICALLY TURNS OFF. THE STEERING BECOMES NEXT TO IMPOSSIBLE AND THE BRAKES BECOME EXTREMELY TIGHT TO THE POINT YOU CAN'T EVEN USE THEM. IT IS TERRIFYING TO HAVE ZERO CONTROL OVER YOUR CAR CONSIDERING I HAVE 4 CHILDREN. IT HAS HAPPENED WHILE I WAS GOING ONLY 30MPH AND ALSO WHEN I WAS GOING 45 MPH. IT HAPPENS WHEN I'M GOING STRAIGHT AND HAS ALSO HAPPENED WHILE TURNING. SINCE THE LATEST ISSUE I REFUSE TO DRIVE ANYWHERE THAT I CAN'T TAKE BACK ROADS TO.

NHTSA ODI #11364690

180,000 miles · Sep 15, 2020
Electrical SystemEngineExterior Lighting

DASH FLASHING, HARD START AFTER PUTTING IN A NEW FUSE BOX AND AFTER FLASH FROM THE DEALER

NHTSA ODI #11355049

124,000 miles · Sep 14, 2020
Electrical System

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V194000 (ELECTRICAL SYSTEM). THE VEHICLE WAS TOWED TO VOLKSWAGEN…

Read full complaint

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V194000 (ELECTRICAL SYSTEM). THE VEHICLE WAS TOWED TO VOLKSWAGEN OF MACON LOCATED AT 4786 RIVERSIDE DR, MACON, GA 31210, (478)781-7701, TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO START THE VEHICLE. THE CONTACT STATED THAT THE MECHANIC WAS UNABLE TO RETRIEVE ANY INFORMATION FROM THE COMPUTERS IN THE VEHICLE. THE CONTACT WAS INFORMED THAT THE PART NEEDED TO REPAIR THE VEHICLE WAS ON BACK ORDER. THE CONTACT STATED THAT THE TOW TRUCK OPERATOR PROVIDED A DIAGNOSTIC TEST AND INFORMED THE CONTACT THAT THE IGNITION SWITCH MODULE NEEDED TO BE REPLACED. THE IGNITION SWITCH MODULE WAS REPLACED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.

NHTSA ODI #11354945

80,000 miles · Sep 8, 2020
Air Bags

THE PASSENGER SIDE AIRBAG COVER ARE INFLATED , CRACK , BUBBLE, LOOK LIKE THE AIRBAG MAY EXPLOTED.. I CALL VW AND THEY SAY IS IT NORMAL AND NOT SALE THE PART. 2009 MINI VAN. .?? I REALLY NOT THINK THEY CHANGE OR OVERHEATING.. GETTING WORDS .. AND YESTERDAY FROM NOT WEAR THE ROUTAN NOT DRIVE OVER 35 MPH WHEN MY WIFE DRIVING ON …

Read full complaint

THE PASSENGER SIDE AIRBAG COVER ARE INFLATED , CRACK , BUBBLE, LOOK LIKE THE AIRBAG MAY EXPLOTED.. I CALL VW AND THEY SAY IS IT NORMAL AND NOT SALE THE PART. 2009 MINI VAN. .?? I REALLY NOT THINK THEY CHANGE OR OVERHEATING.. GETTING WORDS .. AND YESTERDAY FROM NOT WEAR THE ROUTAN NOT DRIVE OVER 35 MPH WHEN MY WIFE DRIVING ON THE HIGHWAY AND CHECK ENGINE CAME , 4 CODE ,P0733,P0734, P0792. AND ALMOST A TRUCK HIT MY WIFE.. I LOOK ON VW FORUMS AND IT IS COMMON PROBLEM,, WHY THIS IT NOT A RECALL WITH SO MANY PEOPLE COMPLAINING AND PROBLEMS.. UNSAFE TO DRIVE.

NHTSA ODI #11353892

122,000 miles · Jul 9, 2020
Electrical System

MY DRIVERS SIDE BACK SEAT DOOR WILL NOT CLOSE ALL THE WAY AND WILL OPEN BACK UP IF IT DOES NOT LATCH CORRECTLY. THE ENGINE WIRING WILL MAKE MY CARS DASH LIGHTS ALL COME ON AND MAKE THE WIPERS GO OFF. THE DOOR ONLY DOES THIS WHILE STATIONARY HOWEVER, THE DASH LIGHTS GO OFF WHILE IN MOTION ON A REGULAR STREET GOING LESS THAN 40…

Read full complaint

MY DRIVERS SIDE BACK SEAT DOOR WILL NOT CLOSE ALL THE WAY AND WILL OPEN BACK UP IF IT DOES NOT LATCH CORRECTLY. THE ENGINE WIRING WILL MAKE MY CARS DASH LIGHTS ALL COME ON AND MAKE THE WIPERS GO OFF. THE DOOR ONLY DOES THIS WHILE STATIONARY HOWEVER, THE DASH LIGHTS GO OFF WHILE IN MOTION ON A REGULAR STREET GOING LESS THAN 40MPH

NHTSA ODI #11338410

Official recalls

6

16V083000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE

Feb 11, 2016

Volkswagen Group of America, Inc. (VW) is recalling certain model year 2009 Volkswagen Routan vehicles manufactured February 7, 2008, to August 28, 2008. In the affected vehicles, the air bag control units may corrode and fail.

Consequence & remedy

Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.

Remedy: VW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began April 2016. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Air Bags:frontal:sensor/control MODULE-INACTIVE

Volkswagen Group of America, Inc. (VW) is recalling certain model year 2009 Volkswagen Routan vehicles manufactured February 7, 2008, to August 28, 2008. In the affected vehicles, the air bag control units may corrode and fail.

Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.

Remedy: VW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began April 2016. Owners may contact Volkswagen customer service at 1-800-893-5298.

Air Bags:frontal

Volkswagen Group of America, Inc. (VW) is recalling certain model year 2009 Volkswagen Routan vehicles manufactured February 7, 2008, to August 28, 2008. In the affected vehicles, the air bag control units may corrode and fail.

Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.

Remedy: VW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began April 2016. Owners may contact Volkswagen customer service at 1-800-893-5298.

15V194000 · Electrical System:ignition:switch

Apr 1, 2015

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles manufactured June 25, 2008, to July 8, 2009, and 2010 Routan vehicles manufactured October 1, 2009, to August 11, 2010. This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence & remedy

Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including, but not limited to, air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.

Remedy: Volkswagen will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on June 23, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 28H1. Note: This recall supersedes recalls 11V151 and 14V396. Vehicles that previously received an ignition switch trim ring as a recall remedy must have their vehicles remedied again under this campaign. Vehicles that have already received a new ignition switch are not covered by this campaign.

14V396000 · Electrical System:ignition

Jul 1, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence & remedy

Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.

Remedy: Volkswagen will notify owners, and dealers will modify the ignition switch, free of charge. Owners may contact Volkswagen customer service at 1- 800-822-8987. An interim notice was mailed to owners on August 29, 2014. Volkswagen's number for this recall is 28G1/U8. Note: This campaign is an expansion of NHTSA Recall No. 11V-151.

14V055000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly

Feb 11, 2014

Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.

Consequence & remedy

Consequence: Failure of the rear axle may increase the risk of a crash.

Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.

10V252000 · Electrical System:wiring

Jun 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 ROUTAN VEHICLES MANUFACTURED FROM JUNE 2008 THROUGH JULY 2009. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION. CONTACT WITH A 12V POWER FEED CIRCUIT WITHIN THE HARNESS MAY CAUSE A HIGH RESISTIVE SHORT CIRCUIT WITHIN THE LATCH MECHANISM LOCATED INSIDE OF THE SLIDING DOOR.

Consequence & remedy

Consequence: THIS COULD RESULT IN AN OVERHEATED LATCH AND A FIRE WITHIN THE REAR SLIDING DOOR COULD OCCUR.

Remedy: VOLKSWAGEN WILL INSPECT THE SLIDING DOOR WIRE TRACK WIRE ASSEMBLY AND THE SLIDING DOOR POWER DRIVE UNIT WIRE ASSEMBLY FOR DAMAGE, REPAIR/REPLACE AS NECESSARY, TIE STRAP THE TWO HARNESSES TOGETHER AND ROUTE THE HARNESSES UNDER THE SLIDING DOOR WEATHER STRIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 15, 2010. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V244000 · Equipment:other:owners/service/other Manual

Jul 1, 2009

VOLKSWAGEN IS RECALLING 18,500 MY 2009 ROUTAN VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE OWNER'S MANUAL WAS PRINTED WITHOUT THE FMVSS NO. 208 REQUIRED INFORMATION EXPLAINING THAT NO OBJECTS SHOULD BE PLACED OVER THE OR NEAR THE AIR BAG ON THE INSTRUMENT PANEL.

Consequence & remedy

Consequence: ANY SUCH OBJECTS COULD CAUSE INJURY TO THE VEHICLE'S OCCUPANTS IN THE EVENT OF A CRASH SEVERE ENOUGH TO CAUSE THE AIR BAG TO INFLATE.

Remedy: DEALERS WILL SEND AN OWNER'S MANUAL INSERT CONTAINING THE REQUIRED AIR BAG INFORMATION FOR OWNER INSTALLATION OR DEALERS WILL INSTALL IN THE EVENT THE OWNER PREFERS ASSISTANCE FROM THE DEALER. THE RECALL BEGAN ON JULY 31, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.