2016 Volkswagen Passat

While driving on a residential street the VW Front Assist suddenly engaged the brakes. There was no car in front or any cars driving in the area. The car came to a complete stop. The only explanation may be that it had been recently raining in Seattle and it was also late in the day so the sun was low in the sky. There was also a metal plate on the street that appeared to be reflective with the rain. We have had incidents like this in the past while driving over the University Bridge as well which is a metal grated draw bridge in Seattle. We are extremely concerned that the brakes will engage and we will be rear ended. I had the dealership inspect the Front Assist feature on Thursday April 17th, 2025 and they have no indication of any fault with the system. The radar sensor that the feature relies upon was properly aligned and in working order. This system makes our car less safe to drive than if it was permanently disabled. Rain followed by sunshine is common in Seattle creating situations where the Front Assist will be triggered incorrectly putting us and other motorists at risk.

The contact owns a 2016 Volkswagen Passat. The contact stated that while attempting to accelerate above 35 MPH, there was an abnormal burning odor inside the vehicle and the EPC warning light had illuminated briefly then the vehicle stalled. The contact was able to pull over onto the side of the road however, the vehicle failed to restart. The vehicle was towed to the residence, and the contact reached out to a local mechanic to diagnose the vehicle. The contact was informed that the fuel pump module, and the fuel pump needed to be replaced. The vehicle was repaired; however, the failure persisted, and the vehicle failed to restart. The contact referenced NHTSA Campaign Number: 17V509000 (FUEL SYSTEM, GASOLINE) however, the VIN was not included. The manufacturer was notified of the failure. The approximate failure mileage 77,000.

The contact owns a 2016 Volkswagen Passat. The contact stated that the vehicle was vibrating abnormally while in park(P) and had started jerking while driving. The contact stated that while driving and exceeding 70 MPH, the shaking and vibrating became worse. The contact stated that the vehicle was leaking oil on top of the engine. The EPC warning light remained illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed. The contact was informed that the breather valve, oil separator, the lower and upper timing cover, all four coil pack connectors, the coolant fluid and brake fluid, rear brake pads, wheel alignment, and engine air filters needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 145,000.

The contact owns a 2016 Volkswagen Passat. The contact stated that after the dealer had performed a fuel induction on the vehicle, the check engine warning light illuminated. The vehicle was taken back to the dealer, where it was diagnosed that the catalytic convertor had failed and needed to be replaced; however, the part to do the repair was not available. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 98,000.

Air bag error light is on and steering wheel controls/horn are inoperable. Cause is most likely a clock spring failure as has been reported in numerous VW vehicle models including the 2016 VW Passat but the current recall 69L2 doesn’t appear to cover our vehicle. With recall problems on numerous other vehicles, it is hard to believe this isn’t caused by the same issue. Repair cost is estimated at $900 for an item that should be covered by VW.

During sharp turn would hear cracking sound coming from steering wheel, after some days air bag warning light appeared on dahsboard and honk and steering wheel buttons stopped working. Dealer replaced the clockspring under warranty that fixed airbag warning issue, but still had honk and steering wheel buttons persisted. Dealer recommended replacing steering wheel control button module to fix both honk and steering wheel buttons. It appears all the problems are related and should have been fixed under warranty

I own a 2016 VW Passat that I'm thinking of painting yellow and I don't like yellow. I was driving going about 75 mph on freeway in Idaho and a truck from the slow lane started merging over into my lane I went to hit horn and it didn't work. I hit my brakes and I mean hard because he obviously didn't see me and he merged over into my lane but had I not braked as hard and when I did it would of been a collision. That's how I discovered my horn didn't work. I'm not a person who pulls up to someones house and taps the horn nor do I use it if someone is sitting at an intersection after the light turns green as if to say, "Come on, pay attention, the light's green, now go" I don't like to do that because it makes everyone look and can cause confusion. I use it to prevent an accident! My clock spring went out on me a year ago. I'm told that's why horn doesn't work. Its also why my airbag light is on and my cruise doesn't work (which may not be a safety issue but I have found myself driving much over speed limit without trying to) and none of my driver assist features work. All controls connected to steering wheel don't work. I'm assuming since the light is on neither does the airbag and I know the horn doesn't. I see there have been recalls on this but looks like they drew the line at 2014. Checking into it further a lot of their cars, newer than 2014, like mine a 2016 have had same issue. I also see that the ones that were taken in for recall and replaced, broke again. I read that that led to an investigation. I don't see any more info. I learned that clock springs are supposed to last the lifetime of the car, so shouldn't there be a recall on the newer cars too, like mine 2016? I'm not impressed with VW, this is my 2nd one and will be my last. I now have to get a new water pump at 70K. I really would like to see a recall on clock springs and would like to know what the conclusion to the investigation was. Thanks, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI

The contact owns a 2016 Volkswagen Passat. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and stalled. In addition, the check engine warning light illuminated. The vehicle was taken to an independent mechanic but was unofficially diagnosed; however, the mechanic noticed that the engine was misfiring. The mechanic performed a tune-up on the vehicle, but the failure reoccurred. The vehicle was not repaired. The vehicle was not diagnosed or repaired by the independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact researched the failure and identified five unknown recall repairs with the same description of the failure; however, the contact was informed that the recall repairs had been previously completed on the vehicle. The contact stated that the vehicle was purchased new, and the contact had been the sole owner of the vehicle. The contact stated that no recall repairs had ever been completed on the vehicle. The failure mileage was unknown.

I believe my clockspring has malfuncioned and though it has had multiple recalls my car is not listed for recall. My horn is no longer working, as well as all the buttons in my steering wheel including cruise control and my airbag light is on. This is all directly correlated to a clockspring malfunction and I believe my vehicle should be recalled for saftey reasons.